This risk assessment document evaluates the hazards associated with confined space work. It identifies risks such as exposure to live underground utilities, toxic gases, flooding, and restricted evacuation. Initial risks are rated as high. Control measures are outlined to reduce risks, such as obtaining permits, gas monitoring, ventilation, restricted hot works, lifelines, and rescue drills. Residual risks are rated as low when all controls are followed. Additional measures like supervisor monitoring and calibrated gas detectors are recommended to ensure safety protocols are strictly adhered to for confined space work.
21 confined space working risk assessment templates
1. HEALTH SAFETY AND ENVIRONMENT Author: Approved:
RISK ASSESSMENT: ACT/HSE/RA 001 CONFINED SPACE WORKING
Issued: Rev. Date:
Revision: 0
Page 1 of 1 HSEQ -Rev-01(Aug-2018)
No
Specific Task Step
(In sequence of
works)
Hazard Details Consequence/Risk
Initial Risk
Rating Control Measures Residual Risks
Additional Control
Measures
RR
P S RR
1
Planned confined
space work in areas
where live services
may be present
including:
Water;
Sewerage;
Gas;
PRIOR TO ENTRY
Presence oflive
underground services;
Services not in area
specified on drawings;
Presence of
unmarked services;
Risk of asphyxia;
Risk of explosion due to gas ignition;
Risk of flooding of confined space;
Risk of hazardous waste entering
confined space due to live sewerage;
Risk of vehicles / Plant entering
confined space;
4 4
20
HIGH
i. All existing utility service drawings reviewed for known service details and
position;
ii. NOC and Utility provider and HLG permits to be completed,unique
number added and recorded in log;
iii. All services clearlycommunicated to all workers at briefings and TBT’s,
signed offand recorded;
iv. Permit/NOC/JSEA/Approved design Drawings copies to be with task
supervisor in work area for review;
v. Suitable training undertaken for operatives;
LOW
2
Confined space
working –
Deep excavations;
Tanks;
Vessels;
Manholes;
NDRC pits;
Bridge decks;
Pipework;
Sewerage;
Lift shafts;
Ducting;
Etc.
Workers required to
work in confined
space;
Excess or lack of oxygen;
Presence ofToxic gases;
Ingress ofwater or other substances;
Explosion due to build-up of gases;
Sudden water ingress into excavation;
Collapse ofworker;
Restricted emergencyevacuation;
Musculoskeletal disorders;
4 5
20
High
i. Permitto be issued & gas monitoring undertaken ifrequired before works
commence;
ii. No works above, as in lift shafts etc.;
iii. Adequate air circulation & lighting to be maintained in work areas;
iv. Equipmentwhich mayrelease excess oxygen or carbon monoxide gases
shall notbe used in confined space areas withoutadequate extraction;
v. Local weather forecastshould be noted to watch for heavy rains which
may cause flooding;
vi. Special consideration to be given to any hot works or work using toxic
substances inside a confined space;
vii. Materials to be stored well away from confined space area;
viii. Top man to be appointed atthe entry of the confined space area as
required,regular contactwith workers in confined space;
ix. Workers connected to lifeline,leading to outside confined space;
x. Rescue drills to be undertaken as required to ensure rescue procedure is
communicated and understood;
xi. Workers should be physicallyfit and competentto enter and undertake
the work in confined spaces.
xii. Rotation of workers if area cramped / difficult to move;
Workers not
adhering to
requirements;
Gas detector not
calibrated
resulting in
incorrectreading
Supervision to constantly
monitor workers;
Regular TBT’s & Trainings to
be given on working Confined
space;
Gas detector to be calibrated
to standards and
manufacturers
recommendations.
Low
RISK SCORE CALCULATOR
Use the Risk Score Calculator to Determine the Level of Risk of each Hazard
What would be the
CONSEQUENCE
of an occurrence be?
What is the LIKELIHOOD of an occurrence? Hierarchy of Controls
Frequent/Almost certain (5)
Continuous or will happen
frequently
Often (4)
6 to 12 times a year
Likely (3)
1 to 5 times a year
Possible (2)
Once every 5 years
Rarely (1)
Less than once every 5
years
Can the hazard be Eliminated or removed
from the w ork place?
Catastrophic (5)
Multiple Fatalities
High 25 High 20 High 15 Medium 10 Medium 5
Can the product or process be substitutedfor
a less hazardous alternative?
Serious (4)
Class 1 single fatality
High 20 High 16 High 12 Medium 8 Low 4
Can the hazard be engineered aw ay w ith
guards or barriers?
Moderate (3)
Class2 (AWI or LTI) or Class 1
Permanently disabling effects
High 15 High 12 Medium 9 Medium 6 Low 3
Can Administration Controls be adopted
I.e. procedures, job rotation etc.
Minor (2)
Medical attention needed, no work
restrictions. MTI
Medium10 Medium 8 Medium 6 Low 4 Low 2 Can Personal Protective Equipment &
Clothing be w orn to safe guard against
hazards?Insignificant (1)
FAI
Medium10 Medium 4 Low 3 Low 2 Low 1
Project Name: xxx
RA Ref No.: xxx
RA compilation
Date:
Review date:
Date:
Compiled by:
Reviewed by:
Approved by:
Overall Task Details
Working in area designated as a confined space
Relevant Applicable MAS:
00246 – Excavations;
00233 – Lift Shafts
Additional Training required: NOC’s Required for task: