This document discusses bioleaching, which uses microorganisms to dissolve metals from ores. The most common microorganisms used are Thiobacillus thiooxidants and Thiobacillus ferrooxidants. Bioleaching can occur directly via microbial contact with ores or indirectly by microbes producing leaching agents. Common applications include copper, uranium, gold and silver, and silica leaching. Bioleaching is used commercially in slope, heap, and in situ leaching with ores placed in piles or left in the ground and irrigated with microbes.

2.  DEFINITION OF BIOLEACHING
 MICROORGANISMS USED IN BIOLEACHING
 CHEMISTRY OF BIOLEACHING
 TYPES
 EXAMPLES
1. COPPER LEACHING
2. URANIUM LEACHING
3. GOLD AND SILVER LEACHING
4. SILICA LEACHING

3. Bioleaching is the process by
which metals are dissolved from
ore bearing rocks using
microorganisms.

4. The most commonly used microorganisms
in bioleaching are;
o Thiobacillus thiooxidants
o Thiobacillus ferrooxidants
other microorganisms which may also be
used are; Bacillus Licheniformis, B. luteus, B
megaterium, B polymyxa, B leptospirillum
ferrooxidants, Pseudomonas flurescens,
Sulfolobus acidocaldarius, etc;

5.  Thiobacillus thiooxidant and T. ferrooxidants
have always been found to be present on the
leaching dump
 The specie of thiobacillus is most extensively
studied gram –ve bacteria which derives
energy from oxidation of fe2
 The reactions mechanisms are two types, i.e.,
• Direct bacterial leaching
• Indirect bacterial leaching

6.  Direct bacterial leaching
in this process, a physical contact
exist between bacteria and ores and
oxidation of minerals takes place though
enzymatically catalysed steps
ex; pyrite is oxidised to ferric sulphate
2FeS2+7O2+2H2O  2FeSo4+2H2So4

7.  Indirect bacterial leaching
in this process the microbes are not in
direct contact with minerals, but leaching
agents are produced by these microbes which
oxidize the ores.

8. There are three commercial process used in
bioleaching;
a. Slope leaching
b. Heap leaching
c. In situ leaching

9.  Here the ores are first ground to get fine
pieces and then dumped into large leaching
dump
 Water containing inoculum of thiobacillus is
continuously sprinkled over the ore
 Water is collected from the bottom and used
to extract metals and generate bacteria in an
oxidation pond

10.  Here the ore is dumped into large heaps
called leach heaps
Water containing inoculum of
thiobacillus is continuously
sprinkled over the ore
Water is collected from the
bottom and used to extract
metal and generate bacteria in an
oxidation pond

11.  In this process the ore remains in its original
position in earth.
 Surface blasting of earth is done to increase
the permeability of water.
 Water containing thiobacillus is pumped
through drilled passages to the ores
 Acidic water seeps through the rock and
collects at bottom

12.  Again, water is pumped from bottom
 Mineral is extracted and water is reused after
generation of bacteria

13. Ores of copper from which copper is
recovered are,
 Chalcocite(Cu2S)
 Chalcopyrite(CuFeS2)
 Covellite(CuS)

14.  Copper leaching is operated as simple heap
leaching and in situ leaching process
 Dilute sulphuric acid is percolated down
through the pile
 Liquid coming out of bottom of pile reach in
mineral
 Liquid is collected and transported to
precipitation plant
 Metal is precipitated an purified

15.  Chalcocite is oxidized to soluble form of
copper
Cu2S+O2+  CuS+Cu2+ +H2O
 Thereafter chemical reactions occur, i.e.
CuS+8Fe +4H2O  Cu+8Fe+SO4+8H
Copper is removed,
Fe0+CuCu+Fe2+
Fe2+ is transferred to oxidation pond
Fe+1/4(O2)+H+Fe3+ +1/2(H2O)

16.  Fe3+ ions produced is an oxidation of ore
 It is pumped back to pile
 Sulphuric acid is added to maintain pH

18.  Uranium is extracted when insoluble
tetravalent uranium is oxidized with a hot
H2So4/FeSo4 solution to make hexavalent
uranium sulphate
 pH required for the reaction is 1.5-3.5
 Temperature: around 35 degree C
following reaction takes place,
U2O+Fe2(SO4)3  UO2SO4+2FeSO4

19.  Uranium leaching is an indirect process
 When T.ferrooxidants are involved in uranium
extraction, they do not directly attack on ore
but on the iron oxidants.
 The pyrite reaction is used for the initial
production of Fe
Reaction;
2FeS+H2O+7 ½[O2]  Fe2[SO4]3+ H2SO4

20.  Microbial leaching of refractory process metal
ores to enhance gold and silver recovery is
one of the promising applications
 Gold is obtained through bioleaching of
arsenopyrite/pyrite
 Silver is also obtained by bioleaching of
arsenopyrite but it is more readily solubilized
than gold during microbial leaching of iron
sulphide.

21. Ores of silica
 Magnesite
 Bauxite
 Dolomite
 Basalt
 Mohanty et al.,(1990) isolated Bacillus
licheniformis from magnesite ore deposits
 Later, it was shown to be associated with
bioleaching, concomitant mineralysis and
silican uptake by the bacterium

22. Thank you