SlideShare a Scribd company logo
1 of 3
Radar vs Ultrasonic Level Calibration Points (The Devil’s
in the Details)
People w ho have used Milltronics or Siemens ultrasonic continuous levelmeasurement systems are used to the w ay configuration
is done. It’s not uncommon that w hen they start up their first Siemens radar transmitter they encounter a stumbling block – the 4-
20mA output doesn’t respond correctly.
The radar w illstart up and run, and if the tank level is low , they’llget a valid level reading on the transmitter’s display, but the 4-
20mA w illbe incorrect (too high a percentage). Or, if the tank level is at a medium or high level, both the indicated levelin the
display and the output w illbe maxed out at 20mA. It’s a misunderstanding about w here the span measurement starts from.
The issue is that each technology uses a similar reference point for empty (0% or 4.0mA), but an entirely different referencepoint for
high level (100% or 20.0mA). Using the w rong reference point gives the w rong output or display value.
Take a look at the diagram:
The diagram show sa radar sensor (left)reference point for low (4.0mA or 0%) and high (20.0mA or 100%) level calibration points.
Note that the high calibration point (100%) and the low calibration point (0%) are both a measured distance fromthe sensor
reference point at the bottom of the transmitter’s flange. The subtracted difference (high minus low ) is the 4-20mA levelspan value
or the maximum level value.
Compare that to the ultrasonic reference points (right).
The empty point (P006) is referenced fromthe face of the transducer, (essentially the same as radar). But the high level point
(P007) is is referenced fromthe empty point, and NOT fromthe face of the ultrasonic transducer.
Note also that the P007 arrow startsat the bottom and measures fromthe bottom up, unlike the radar high cal point w here the arrow
starts at the top and measures dow n.
If the high level value is determined from the correct reference point, everything works as expected. If not, the radar’s 4-20mA
output signalis spanned incorrectly and w illmax out w ay below the true high level point.
The table below summarizes the reference points.
Calibration Point Ultrasonic Radar
0% or 4mA
Reference from the top down
100% or 20 mA
Reference from bottom up Reference from top down.
How Does an Ultrasonic Flow Meter Work?
Posted on February 4,2013
Ultrasonic flowmeters measurethe level ina channelbytransmittinga
pulseofsoundfrom the face ofthe sensor to the surfaceofthe flow stream and measuringthe time for the echoto return.
The transittime corresponds to the distance betweenthe face ofthe sensor andthe surfaceofthe water. When the meter
is initiallysetup,a pre-determineddistance(or levelin some meters) is set.This distanceis either the zero level (noflow
present) or a specific level in the flumeor weir. With this initial calibrationitis onlya matter ofsimple arithmeticto determine
the liquidlevel. This levelis then applied to either pre-programmeddischargeequations or strappingtables to outputa flow
rate.
Because the sensoris notin contactwith the water,ultrasonic sensors have no scheduledmaintenance. Ultrasonic
sensors are notaffectedbychemicals,grease,suspendedsolids,or siltin the flow stream.
Performance ofultrasonic flow meters maybe degradedby:
 Strong wind
 Solar heating(ofthe sensor)
 Foam
 Turbulence
 Steam
 False echoes from obstructions
To combattheseproblems a varietyofmethods areused:
 Sensor sunshades (for solar heating)
 Angling the sensor face(to reduce steam condensate build up)
 Proprietarycontrolschemes are usedto adjustamplifier gain (to increaseechostrength)
 Variable blanking distances (to eliminate early/late echo returns)
 Dampeningfactors (applied to reduce peaks and troughs in the outputsignal).
For maximum performance,ultrasonic flowmeters are notrecommended for use on channels less than6-inches [15.24cm]
wide (due to beam spread) or where steam,foam,turbulence,floatingdebris /oil /greaseare present(although as seen
above these conditions can sometimes be mitigated).
To obtain maximum accuracya temperaturesensor [eitherintegral to the ultrasonic sensor(preferred)or as a standalone
sensor]is required to compensatefor changes in airtemperature.
Dead span (thedistancemeasuredfrom the face ofthe sensor in whichsensor exhibits degradedperformance)is typically
1-foot[0.3048m],whilethe range for flowmeasurementsensors is typicallyup to 11-feet[3.353 m].
Under standardconditions (stillair,40-70% relative humidity,72° F[22.22° C]),the level measurementaccuracyof
ultrasonic flowmeters can ± 1/4 to 3/8-inch[0.635to 0.9525cm](dependingupon the change in level).
When mounting a ultrasonic sensorover a flume(or weir) thereis a tradeoffbetweenaccessibility(mounting the sensor
near the sideofthe flume)and maximum potential accuracy(mounting the sensorover the centerlineofthe flume). Ifthe
flow approaching the flume has been properlyconditioned andthe flumeproperlyset,eitherconditionis acceptable.If,
however,the flow has notbeenproperlyconditioned,is turbulence,or is poorlydistributed,readings atthe sidewallmay
differ from thosein the center ofthe flume. Don'tassume,though,that the centerlinereading is automaticallymore
accurate.

More Related Content

Similar to Radar vs ultrasonic level calibration points

Performance checks dasibi ozone-v2
Performance checks dasibi ozone-v2Performance checks dasibi ozone-v2
Performance checks dasibi ozone-v2TAMUK
 
Electronics Lab Equipment.ppt
Electronics Lab Equipment.pptElectronics Lab Equipment.ppt
Electronics Lab Equipment.pptmelvinlozbanoz
 
Electronics Lab Equipment.ppt
Electronics Lab Equipment.pptElectronics Lab Equipment.ppt
Electronics Lab Equipment.pptMWaleed23
 
Guia de instalacion cuenta-personas FastONE
Guia de instalacion cuenta-personas FastONEGuia de instalacion cuenta-personas FastONE
Guia de instalacion cuenta-personas FastONENextPoints
 
Flame Scanners Optimization
Flame Scanners OptimizationFlame Scanners Optimization
Flame Scanners OptimizationMustafa Ali
 
Obstacle detection using ultra sonic sensor
Obstacle detection using ultra sonic sensorObstacle detection using ultra sonic sensor
Obstacle detection using ultra sonic sensorsatyashanker
 
Testing and Troubleshooting 4-20 mA Control Loops Presented by Fluke and Tra...
Testing and Troubleshooting 4-20 mA Control Loops  Presented by Fluke and Tra...Testing and Troubleshooting 4-20 mA Control Loops  Presented by Fluke and Tra...
Testing and Troubleshooting 4-20 mA Control Loops Presented by Fluke and Tra...Transcat
 
Oscilloscope Fundamentals, Hands-On Course at EELive 2014
Oscilloscope Fundamentals, Hands-On Course at EELive 2014Oscilloscope Fundamentals, Hands-On Course at EELive 2014
Oscilloscope Fundamentals, Hands-On Course at EELive 2014Rohde & Schwarz North America
 
Application of MULTIMETER.pptx.pdf
Application of MULTIMETER.pptx.pdfApplication of MULTIMETER.pptx.pdf
Application of MULTIMETER.pptx.pdfManas Ranjan Roul
 
Adaptive filter
Adaptive filterAdaptive filter
Adaptive filterA. Shamel
 
Q46-76-Turbidity-Monitor.pdf
Q46-76-Turbidity-Monitor.pdfQ46-76-Turbidity-Monitor.pdf
Q46-76-Turbidity-Monitor.pdfENVIMART
 
Basic electrical measuring instruments
Basic electrical measuring instrumentsBasic electrical measuring instruments
Basic electrical measuring instrumentsPramod A
 
Basicelectricalmeasuringinstruments 160111044802
Basicelectricalmeasuringinstruments 160111044802Basicelectricalmeasuringinstruments 160111044802
Basicelectricalmeasuringinstruments 160111044802shivmittal6
 
Ac lab final_report
Ac lab final_reportAc lab final_report
Ac lab final_reportGeorge Cibi
 
Halderman ch075 lecture
Halderman ch075 lectureHalderman ch075 lecture
Halderman ch075 lecturemcfalltj
 

Similar to Radar vs ultrasonic level calibration points (20)

Performance checks dasibi ozone-v2
Performance checks dasibi ozone-v2Performance checks dasibi ozone-v2
Performance checks dasibi ozone-v2
 
Electronics Lab Equipment.ppt
Electronics Lab Equipment.pptElectronics Lab Equipment.ppt
Electronics Lab Equipment.ppt
 
Electronics Lab Equipment.ppt
Electronics Lab Equipment.pptElectronics Lab Equipment.ppt
Electronics Lab Equipment.ppt
 
ZERO100L ultrasonic level meter manual. four lines
ZERO100L  ultrasonic level meter manual. four linesZERO100L  ultrasonic level meter manual. four lines
ZERO100L ultrasonic level meter manual. four lines
 
Guia de instalacion cuenta-personas FastONE
Guia de instalacion cuenta-personas FastONEGuia de instalacion cuenta-personas FastONE
Guia de instalacion cuenta-personas FastONE
 
Analog & digital measuring instruments
Analog & digital measuring instrumentsAnalog & digital measuring instruments
Analog & digital measuring instruments
 
Flame Scanners Optimization
Flame Scanners OptimizationFlame Scanners Optimization
Flame Scanners Optimization
 
Obstacle detection using ultra sonic sensor
Obstacle detection using ultra sonic sensorObstacle detection using ultra sonic sensor
Obstacle detection using ultra sonic sensor
 
Testing and Troubleshooting 4-20 mA Control Loops Presented by Fluke and Tra...
Testing and Troubleshooting 4-20 mA Control Loops  Presented by Fluke and Tra...Testing and Troubleshooting 4-20 mA Control Loops  Presented by Fluke and Tra...
Testing and Troubleshooting 4-20 mA Control Loops Presented by Fluke and Tra...
 
Gear flow meter and roots flow meter instruction manual wiring and parameter set
Gear flow meter and roots flow meter instruction manual wiring and parameter setGear flow meter and roots flow meter instruction manual wiring and parameter set
Gear flow meter and roots flow meter instruction manual wiring and parameter set
 
Oscilloscope Fundamentals, Hands-On Course at EELive 2014
Oscilloscope Fundamentals, Hands-On Course at EELive 2014Oscilloscope Fundamentals, Hands-On Course at EELive 2014
Oscilloscope Fundamentals, Hands-On Course at EELive 2014
 
Furuno1
Furuno1Furuno1
Furuno1
 
Application of MULTIMETER.pptx.pdf
Application of MULTIMETER.pptx.pdfApplication of MULTIMETER.pptx.pdf
Application of MULTIMETER.pptx.pdf
 
Radar Level Meter Liquid Level Indication Maximum Reasons And Solutions
Radar Level Meter Liquid Level Indication Maximum Reasons And SolutionsRadar Level Meter Liquid Level Indication Maximum Reasons And Solutions
Radar Level Meter Liquid Level Indication Maximum Reasons And Solutions
 
Adaptive filter
Adaptive filterAdaptive filter
Adaptive filter
 
Q46-76-Turbidity-Monitor.pdf
Q46-76-Turbidity-Monitor.pdfQ46-76-Turbidity-Monitor.pdf
Q46-76-Turbidity-Monitor.pdf
 
Basic electrical measuring instruments
Basic electrical measuring instrumentsBasic electrical measuring instruments
Basic electrical measuring instruments
 
Basicelectricalmeasuringinstruments 160111044802
Basicelectricalmeasuringinstruments 160111044802Basicelectricalmeasuringinstruments 160111044802
Basicelectricalmeasuringinstruments 160111044802
 
Ac lab final_report
Ac lab final_reportAc lab final_report
Ac lab final_report
 
Halderman ch075 lecture
Halderman ch075 lectureHalderman ch075 lecture
Halderman ch075 lecture
 

More from Vohinh Ngo

Nuoc uong tu_thao_moc_925
Nuoc uong tu_thao_moc_925Nuoc uong tu_thao_moc_925
Nuoc uong tu_thao_moc_925Vohinh Ngo
 
Vietnam fm monitor bao cao thi truong tai chinh tien te viet nam thang 4 20...
Vietnam fm monitor   bao cao thi truong tai chinh tien te viet nam thang 4 20...Vietnam fm monitor   bao cao thi truong tai chinh tien te viet nam thang 4 20...
Vietnam fm monitor bao cao thi truong tai chinh tien te viet nam thang 4 20...Vohinh Ngo
 
Sotay ttck at_pvietnam.com_2007
Sotay ttck at_pvietnam.com_2007Sotay ttck at_pvietnam.com_2007
Sotay ttck at_pvietnam.com_2007Vohinh Ngo
 
Huong dan su_dung_dich_vu
Huong dan su_dung_dich_vuHuong dan su_dung_dich_vu
Huong dan su_dung_dich_vuVohinh Ngo
 
Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...
Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...
Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...Vohinh Ngo
 
01 49-bui phuong dai(36-41)
01 49-bui phuong dai(36-41)01 49-bui phuong dai(36-41)
01 49-bui phuong dai(36-41)Vohinh Ngo
 
Quá trình đun nóng
Quá trình đun nóngQuá trình đun nóng
Quá trình đun nóngVohinh Ngo
 
The institute of brewing research scheme
The institute of brewing research schemeThe institute of brewing research scheme
The institute of brewing research schemeVohinh Ngo
 
Doc042.52.20185.dec15 mebak.web
Doc042.52.20185.dec15 mebak.webDoc042.52.20185.dec15 mebak.web
Doc042.52.20185.dec15 mebak.webVohinh Ngo
 
Purpose of wort boiling
Purpose of wort boilingPurpose of wort boiling
Purpose of wort boilingVohinh Ngo
 
Foam stabilizer
Foam stabilizerFoam stabilizer
Foam stabilizerVohinh Ngo
 
Influence of lauter turbidity on wort composition
Influence of lauter turbidity on wort compositionInfluence of lauter turbidity on wort composition
Influence of lauter turbidity on wort compositionVohinh Ngo
 
J.2050 0416.1996.tb00900.x
J.2050 0416.1996.tb00900.xJ.2050 0416.1996.tb00900.x
J.2050 0416.1996.tb00900.xVohinh Ngo
 

More from Vohinh Ngo (20)

Termamyl sc
Termamyl scTermamyl sc
Termamyl sc
 
Nuoc uong tu_thao_moc_925
Nuoc uong tu_thao_moc_925Nuoc uong tu_thao_moc_925
Nuoc uong tu_thao_moc_925
 
Vietnam fm monitor bao cao thi truong tai chinh tien te viet nam thang 4 20...
Vietnam fm monitor   bao cao thi truong tai chinh tien te viet nam thang 4 20...Vietnam fm monitor   bao cao thi truong tai chinh tien te viet nam thang 4 20...
Vietnam fm monitor bao cao thi truong tai chinh tien te viet nam thang 4 20...
 
Sotay ttck at_pvietnam.com_2007
Sotay ttck at_pvietnam.com_2007Sotay ttck at_pvietnam.com_2007
Sotay ttck at_pvietnam.com_2007
 
Huong dan su_dung_dich_vu
Huong dan su_dung_dich_vuHuong dan su_dung_dich_vu
Huong dan su_dung_dich_vu
 
Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...
Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...
Rukovodstvo po tipam piva, meda i sidra. sertifikatsionnaya programma pivnykh...
 
01 49-bui phuong dai(36-41)
01 49-bui phuong dai(36-41)01 49-bui phuong dai(36-41)
01 49-bui phuong dai(36-41)
 
36 evans
36 evans36 evans
36 evans
 
Quá trình đun nóng
Quá trình đun nóngQuá trình đun nóng
Quá trình đun nóng
 
The institute of brewing research scheme
The institute of brewing research schemeThe institute of brewing research scheme
The institute of brewing research scheme
 
Doc042.52.20185.dec15 mebak.web
Doc042.52.20185.dec15 mebak.webDoc042.52.20185.dec15 mebak.web
Doc042.52.20185.dec15 mebak.web
 
Diacety1
Diacety1Diacety1
Diacety1
 
Diacety1
Diacety1Diacety1
Diacety1
 
Business
BusinessBusiness
Business
 
Purpose of wort boiling
Purpose of wort boilingPurpose of wort boiling
Purpose of wort boiling
 
Foam stabilizer
Foam stabilizerFoam stabilizer
Foam stabilizer
 
Influence of lauter turbidity on wort composition
Influence of lauter turbidity on wort compositionInfluence of lauter turbidity on wort composition
Influence of lauter turbidity on wort composition
 
Wort boiling
Wort boilingWort boiling
Wort boiling
 
J.2050 0416.1996.tb00900.x
J.2050 0416.1996.tb00900.xJ.2050 0416.1996.tb00900.x
J.2050 0416.1996.tb00900.x
 
243 s038
243 s038243 s038
243 s038
 

Recently uploaded

Alper Gobel In Media Res Media Component
Alper Gobel In Media Res Media ComponentAlper Gobel In Media Res Media Component
Alper Gobel In Media Res Media ComponentInMediaRes1
 
_Math 4-Q4 Week 5.pptx Steps in Collecting Data
_Math 4-Q4 Week 5.pptx Steps in Collecting Data_Math 4-Q4 Week 5.pptx Steps in Collecting Data
_Math 4-Q4 Week 5.pptx Steps in Collecting DataJhengPantaleon
 
BASLIQ CURRENT LOOKBOOK LOOKBOOK(1) (1).pdf
BASLIQ CURRENT LOOKBOOK  LOOKBOOK(1) (1).pdfBASLIQ CURRENT LOOKBOOK  LOOKBOOK(1) (1).pdf
BASLIQ CURRENT LOOKBOOK LOOKBOOK(1) (1).pdfSoniaTolstoy
 
Introduction to ArtificiaI Intelligence in Higher Education
Introduction to ArtificiaI Intelligence in Higher EducationIntroduction to ArtificiaI Intelligence in Higher Education
Introduction to ArtificiaI Intelligence in Higher Educationpboyjonauth
 
CARE OF CHILD IN INCUBATOR..........pptx
CARE OF CHILD IN INCUBATOR..........pptxCARE OF CHILD IN INCUBATOR..........pptx
CARE OF CHILD IN INCUBATOR..........pptxGaneshChakor2
 
mini mental status format.docx
mini    mental       status     format.docxmini    mental       status     format.docx
mini mental status format.docxPoojaSen20
 
Hybridoma Technology ( Production , Purification , and Application )
Hybridoma Technology  ( Production , Purification , and Application  ) Hybridoma Technology  ( Production , Purification , and Application  )
Hybridoma Technology ( Production , Purification , and Application ) Sakshi Ghasle
 
Concept of Vouching. B.Com(Hons) /B.Compdf
Concept of Vouching. B.Com(Hons) /B.CompdfConcept of Vouching. B.Com(Hons) /B.Compdf
Concept of Vouching. B.Com(Hons) /B.CompdfUmakantAnnand
 
Accessible design: Minimum effort, maximum impact
Accessible design: Minimum effort, maximum impactAccessible design: Minimum effort, maximum impact
Accessible design: Minimum effort, maximum impactdawncurless
 
POINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptx
POINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptxPOINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptx
POINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptxSayali Powar
 
Contemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptx
Contemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptxContemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptx
Contemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptxRoyAbrique
 
Software Engineering Methodologies (overview)
Software Engineering Methodologies (overview)Software Engineering Methodologies (overview)
Software Engineering Methodologies (overview)eniolaolutunde
 
Introduction to AI in Higher Education_draft.pptx
Introduction to AI in Higher Education_draft.pptxIntroduction to AI in Higher Education_draft.pptx
Introduction to AI in Higher Education_draft.pptxpboyjonauth
 
The basics of sentences session 2pptx copy.pptx
The basics of sentences session 2pptx copy.pptxThe basics of sentences session 2pptx copy.pptx
The basics of sentences session 2pptx copy.pptxheathfieldcps1
 
Employee wellbeing at the workplace.pptx
Employee wellbeing at the workplace.pptxEmployee wellbeing at the workplace.pptx
Employee wellbeing at the workplace.pptxNirmalaLoungPoorunde1
 
Interactive Powerpoint_How to Master effective communication
Interactive Powerpoint_How to Master effective communicationInteractive Powerpoint_How to Master effective communication
Interactive Powerpoint_How to Master effective communicationnomboosow
 
Enzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdf
Enzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdfEnzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdf
Enzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdfSumit Tiwari
 
SOCIAL AND HISTORICAL CONTEXT - LFTVD.pptx
SOCIAL AND HISTORICAL CONTEXT - LFTVD.pptxSOCIAL AND HISTORICAL CONTEXT - LFTVD.pptx
SOCIAL AND HISTORICAL CONTEXT - LFTVD.pptxiammrhaywood
 

Recently uploaded (20)

Alper Gobel In Media Res Media Component
Alper Gobel In Media Res Media ComponentAlper Gobel In Media Res Media Component
Alper Gobel In Media Res Media Component
 
9953330565 Low Rate Call Girls In Rohini Delhi NCR
9953330565 Low Rate Call Girls In Rohini  Delhi NCR9953330565 Low Rate Call Girls In Rohini  Delhi NCR
9953330565 Low Rate Call Girls In Rohini Delhi NCR
 
_Math 4-Q4 Week 5.pptx Steps in Collecting Data
_Math 4-Q4 Week 5.pptx Steps in Collecting Data_Math 4-Q4 Week 5.pptx Steps in Collecting Data
_Math 4-Q4 Week 5.pptx Steps in Collecting Data
 
BASLIQ CURRENT LOOKBOOK LOOKBOOK(1) (1).pdf
BASLIQ CURRENT LOOKBOOK  LOOKBOOK(1) (1).pdfBASLIQ CURRENT LOOKBOOK  LOOKBOOK(1) (1).pdf
BASLIQ CURRENT LOOKBOOK LOOKBOOK(1) (1).pdf
 
Introduction to ArtificiaI Intelligence in Higher Education
Introduction to ArtificiaI Intelligence in Higher EducationIntroduction to ArtificiaI Intelligence in Higher Education
Introduction to ArtificiaI Intelligence in Higher Education
 
CARE OF CHILD IN INCUBATOR..........pptx
CARE OF CHILD IN INCUBATOR..........pptxCARE OF CHILD IN INCUBATOR..........pptx
CARE OF CHILD IN INCUBATOR..........pptx
 
mini mental status format.docx
mini    mental       status     format.docxmini    mental       status     format.docx
mini mental status format.docx
 
Hybridoma Technology ( Production , Purification , and Application )
Hybridoma Technology  ( Production , Purification , and Application  ) Hybridoma Technology  ( Production , Purification , and Application  )
Hybridoma Technology ( Production , Purification , and Application )
 
Concept of Vouching. B.Com(Hons) /B.Compdf
Concept of Vouching. B.Com(Hons) /B.CompdfConcept of Vouching. B.Com(Hons) /B.Compdf
Concept of Vouching. B.Com(Hons) /B.Compdf
 
Accessible design: Minimum effort, maximum impact
Accessible design: Minimum effort, maximum impactAccessible design: Minimum effort, maximum impact
Accessible design: Minimum effort, maximum impact
 
POINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptx
POINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptxPOINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptx
POINT- BIOCHEMISTRY SEM 2 ENZYMES UNIT 5.pptx
 
Contemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptx
Contemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptxContemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptx
Contemporary philippine arts from the regions_PPT_Module_12 [Autosaved] (1).pptx
 
Software Engineering Methodologies (overview)
Software Engineering Methodologies (overview)Software Engineering Methodologies (overview)
Software Engineering Methodologies (overview)
 
Introduction to AI in Higher Education_draft.pptx
Introduction to AI in Higher Education_draft.pptxIntroduction to AI in Higher Education_draft.pptx
Introduction to AI in Higher Education_draft.pptx
 
The basics of sentences session 2pptx copy.pptx
The basics of sentences session 2pptx copy.pptxThe basics of sentences session 2pptx copy.pptx
The basics of sentences session 2pptx copy.pptx
 
Employee wellbeing at the workplace.pptx
Employee wellbeing at the workplace.pptxEmployee wellbeing at the workplace.pptx
Employee wellbeing at the workplace.pptx
 
Staff of Color (SOC) Retention Efforts DDSD
Staff of Color (SOC) Retention Efforts DDSDStaff of Color (SOC) Retention Efforts DDSD
Staff of Color (SOC) Retention Efforts DDSD
 
Interactive Powerpoint_How to Master effective communication
Interactive Powerpoint_How to Master effective communicationInteractive Powerpoint_How to Master effective communication
Interactive Powerpoint_How to Master effective communication
 
Enzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdf
Enzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdfEnzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdf
Enzyme, Pharmaceutical Aids, Miscellaneous Last Part of Chapter no 5th.pdf
 
SOCIAL AND HISTORICAL CONTEXT - LFTVD.pptx
SOCIAL AND HISTORICAL CONTEXT - LFTVD.pptxSOCIAL AND HISTORICAL CONTEXT - LFTVD.pptx
SOCIAL AND HISTORICAL CONTEXT - LFTVD.pptx
 

Radar vs ultrasonic level calibration points

  • 1. Radar vs Ultrasonic Level Calibration Points (The Devil’s in the Details) People w ho have used Milltronics or Siemens ultrasonic continuous levelmeasurement systems are used to the w ay configuration is done. It’s not uncommon that w hen they start up their first Siemens radar transmitter they encounter a stumbling block – the 4- 20mA output doesn’t respond correctly. The radar w illstart up and run, and if the tank level is low , they’llget a valid level reading on the transmitter’s display, but the 4- 20mA w illbe incorrect (too high a percentage). Or, if the tank level is at a medium or high level, both the indicated levelin the display and the output w illbe maxed out at 20mA. It’s a misunderstanding about w here the span measurement starts from. The issue is that each technology uses a similar reference point for empty (0% or 4.0mA), but an entirely different referencepoint for high level (100% or 20.0mA). Using the w rong reference point gives the w rong output or display value. Take a look at the diagram: The diagram show sa radar sensor (left)reference point for low (4.0mA or 0%) and high (20.0mA or 100%) level calibration points. Note that the high calibration point (100%) and the low calibration point (0%) are both a measured distance fromthe sensor reference point at the bottom of the transmitter’s flange. The subtracted difference (high minus low ) is the 4-20mA levelspan value or the maximum level value. Compare that to the ultrasonic reference points (right). The empty point (P006) is referenced fromthe face of the transducer, (essentially the same as radar). But the high level point (P007) is is referenced fromthe empty point, and NOT fromthe face of the ultrasonic transducer. Note also that the P007 arrow startsat the bottom and measures fromthe bottom up, unlike the radar high cal point w here the arrow starts at the top and measures dow n.
  • 2. If the high level value is determined from the correct reference point, everything works as expected. If not, the radar’s 4-20mA output signalis spanned incorrectly and w illmax out w ay below the true high level point. The table below summarizes the reference points. Calibration Point Ultrasonic Radar 0% or 4mA Reference from the top down 100% or 20 mA Reference from bottom up Reference from top down. How Does an Ultrasonic Flow Meter Work? Posted on February 4,2013 Ultrasonic flowmeters measurethe level ina channelbytransmittinga pulseofsoundfrom the face ofthe sensor to the surfaceofthe flow stream and measuringthe time for the echoto return. The transittime corresponds to the distance betweenthe face ofthe sensor andthe surfaceofthe water. When the meter is initiallysetup,a pre-determineddistance(or levelin some meters) is set.This distanceis either the zero level (noflow present) or a specific level in the flumeor weir. With this initial calibrationitis onlya matter ofsimple arithmeticto determine the liquidlevel. This levelis then applied to either pre-programmeddischargeequations or strappingtables to outputa flow rate. Because the sensoris notin contactwith the water,ultrasonic sensors have no scheduledmaintenance. Ultrasonic sensors are notaffectedbychemicals,grease,suspendedsolids,or siltin the flow stream. Performance ofultrasonic flow meters maybe degradedby:  Strong wind  Solar heating(ofthe sensor)  Foam  Turbulence  Steam  False echoes from obstructions To combattheseproblems a varietyofmethods areused:
  • 3.  Sensor sunshades (for solar heating)  Angling the sensor face(to reduce steam condensate build up)  Proprietarycontrolschemes are usedto adjustamplifier gain (to increaseechostrength)  Variable blanking distances (to eliminate early/late echo returns)  Dampeningfactors (applied to reduce peaks and troughs in the outputsignal). For maximum performance,ultrasonic flowmeters are notrecommended for use on channels less than6-inches [15.24cm] wide (due to beam spread) or where steam,foam,turbulence,floatingdebris /oil /greaseare present(although as seen above these conditions can sometimes be mitigated). To obtain maximum accuracya temperaturesensor [eitherintegral to the ultrasonic sensor(preferred)or as a standalone sensor]is required to compensatefor changes in airtemperature. Dead span (thedistancemeasuredfrom the face ofthe sensor in whichsensor exhibits degradedperformance)is typically 1-foot[0.3048m],whilethe range for flowmeasurementsensors is typicallyup to 11-feet[3.353 m]. Under standardconditions (stillair,40-70% relative humidity,72° F[22.22° C]),the level measurementaccuracyof ultrasonic flowmeters can ± 1/4 to 3/8-inch[0.635to 0.9525cm](dependingupon the change in level). When mounting a ultrasonic sensorover a flume(or weir) thereis a tradeoffbetweenaccessibility(mounting the sensor near the sideofthe flume)and maximum potential accuracy(mounting the sensorover the centerlineofthe flume). Ifthe flow approaching the flume has been properlyconditioned andthe flumeproperlyset,eitherconditionis acceptable.If, however,the flow has notbeenproperlyconditioned,is turbulence,or is poorlydistributed,readings atthe sidewallmay differ from thosein the center ofthe flume. Don'tassume,though,that the centerlinereading is automaticallymore accurate.