The document describes the QuickStick 100 Motor module from MagneMotion. It is part of a modular system used for conveying vehicles on a track. The motor contains integral controllers and sensors. It can accommodate up to 5 vehicles in motion or queue per 1.5 meter section. The motor provides precise positioning with a repeatability of ±1 mm and can accelerate vehicles up to 2.4 G. It is designed for protection against dust and water.

1. 82.5
QuickStick® 100 Motor
498.0/ 978.0 87.0 T-Slot for Mounting
• QuickStick systems consist of modules that include motors, magnet arrays, controllers, and power supplies.
• QS 100 motors contain integral motor controllers and position sensing.
• Magnet arrays used on the vehicles are 150 mm L (min).
• Up to five (5) vehicles in motion or in queue per meter (150 mm magnet array length).
• Servo repeatability to ±1 mm†.
• T-Slot accommodates Bosch 10 mm T-Slot hardware (e.g., M8 x 1.25, 10 mm T-Block & Spring) for motor mounting.
• Designed for IEC 60529 IP54.
Physical Specifications Environmental Specifications‡
Dimensions*: ½ meter: 87.0 W x 82.5 H x 498.0 L
1 meter: 87.0 W x 82.5 H x 978.0 L
Ambient Temperature: 0 °C to 50 °C
Relative Humidity: 0% to 85%, non-condensing
Weight: ½ meter: 6.6 kg (14.5 lbs)
1 meter: 13.2 kg (29.0 lbs)
* All dimensions are millimeters.
Electrical Specifications Performance Specifications‡
Drive Rating, Max: ½ meter: 48 VDC, 1 A typical, 2.5 A max
1 meter: 48 VDC, 2 A typical, 5 A max
Acceleration, Max: 24 m/s2 (2.4 G) payload dependent
Velocity, Max: 2.5 m/s (490 ft/minute)
Power:
Power drawn by the motor varies based on
the vehicles being used and the maximum
acceleration or velocity of the vehicles.
Servo Repeatability†: ±1 mm nominal
Maximum Payload:
100 kg per vehicle (determined by
magnet array length and support
structure)
† Repeatability is dependent on the size of the gap between the motor and the vehicle and may vary based on track and vehicle
design/structure. Repeatability is not applicable over the gaps between motors.
‡ Operating performance will vary based on payloads, acceleration and velocity settings, and vehicle density.
© 2012 MagneMotion, Inc. All Rights Reserved. Contact MagneMotion for additional information.
139 Barnum Road, Devens, MA 01434, USA
+1 978-757-9100 www.magnemotion.com
990000384 Rev. A
Sold & Serviced By:
ELECTROMATE
Toll Free Phone (877) SERVO98
Toll Free Fax (877) SERV099
www.electromate.com
sales@electromate.com