Understand CARB regulations for trucking companies. Does understanding California CARB regulations make your head spin? This presentation provides you with a simple overview of the CARB regulations that affect small to large trucking fleets.
2. What We’ll Cover
Blow Off Some Steam
Legacy Programs
• HDVIP (Heavy-Duty Diesel Vehicle Inspection Program)
• Idling Reduction Program
• Emission Control Label Program
Trucks And Buses
• Truck and Bus Regulation
• Greenhouse Gas Emission Reduction Measure
• Transport Refrigeration Units (TRUs)
• Diesel-Fueled Auxiliary Power Units
Drayage Trucks
• Drayage (Port or Rail Yard) Truck Regulation
3. Fun California “Facts”
The fastest part of a Californian’s commute is down their driveway
In California you can make $300,000 and still not afford a house
More than clothes come out of the closets
Q: What does a California native and a bottle of beer have in common?
A: They’re both empty from the neck up.
4. HDVIP
Heavy-Duty Diesel Vehicle Inspections Program
• Any vehicle traveling in CA can be inspected
• Uses SAE snap-acceleration test procedure
• Penalties range from Notice of Violation to $1,800 citations
5. Idling Reduction Program
• Requires manual or automatic shutdown after
5 minutes of idling
• 2008 or newer engines must be equipped with
automatic shutdown after 5 minutes idling
• Immediate shutdown at or within 100 feet of
a school or school activity site, restart no
more than 30 seconds before departing
• Fines $300-1000 per day
6. Emission Control Label Program
No 1974 or newer diesel powered heavy-duty
commercial vehicle shall operate in California
without evidence that, at the time of
manufacture, the installed engine met emission
standards at least as stringent as applicable
federal emission standards for the model year of
the engine
7. • Penalty $800 ($500 for non-compliance +
$300 for failure to display label)
8. Truck and Bus Regulation
This regulation requires installation of
particulate matter (PM) retrofits for heavier
trucks beginning January 1, 2012 and
replacement of older truck engines starting
January 1, 2015. By January 1, 2023, nearly all
trucks and buses will need to have 2010 model
year engines or equivalent. Installation cost of a
PM filter ranges from $10,000-20,000.
10. Greenhouse Gas Emission Reduction
Measure
• Applies to 53-foot or longer box-type trailers,
including both dry-van and refrigerated-van
trailers, and all heavy-duty (HD) tractors that
pull them on California highways.
• Applicable tractors and trailers must have Low
Rolling Resistance (LRR) Tires and SmartWay
Verified Aerodynamic Technologies
11. What Are LRR Tires
Low rolling resistance (LRR) tires are tires designed to
improve the fuel efficiency of tractor-trailers by
minimizing their rolling resistance. As tires roll under the
vehicle’s weight, they deflect and dissipate energy into
heat. The rolling resistance of a tire is the energy lost per
unit distance traveled as the tire rolls under load. A tire
with less rolling resistance is more fuel efficient than one
with greater rolling resistance. Estimated fuel savings is
3% from a tractor-trailer combination. Cost ranges from
$0-50 more than traditional tires.
13. Aerodynamic Technologies For Trailers
Aerodynamic technologies are components designed to reduce wind resistance on the
tractor or trailer resulting in improved overall tractor fuel economy and reduced
emissions. EPA has verified the following categories of aerodynamic technologies:
• Trailer Gap Reducer (used in combination with Trailer Side Skirts );
• Trailer Boat Tail (used in combination with Trailer Side Skirts );
• Trailer Side Skirts
• Advanced Trailer End Fairings (includes end fairings and undercarriage devices); and,
• Advanced Trailer Skirts.
SmartWay aerodynamic technologies, when used in combination with one another or in
some cases when used alone, may reduce fuel consumption by an estimated five
percent or greater relative to the truck's baseline, when used in conjunction with an
aerodynamic tractor in highway type operation.
The cost to retrofit a trailer is between $1,000-2,000. And the fuel savings is estimated
to be 6.5% or higher.
16. Transport Refrigeration Units (TRUs)
• Registration-Applications for ARB Identification
Numbers (IDN) are required for all TRUs are
based in CA. IDNs are voluntary for TRUs based
elsewhere. Inspections for TRUs with IDNs are
faster because compliance has been prescreened.
• In-Use Standards-TRUs that operate in CA must
meet performance standards as outlined in the
compliance schedule.
18. Diesel-Fueled Auxiliary Power Units
• Cannot be operated for more than 5 minutes when
within 100 feet of a residential area
• Trucks with 2006 and earlier MY engines can use any
CA or Federally certified APU
• 2007 and newer MY engines must:
– Be fitted with a verified Level 3 particulate control device,
or
– Have its exhaust plumbed into the vehicle’s exhaust system
upstream from the PM filter
– A “Verified Clean APS” label must be affixed to the hood of
the vehicle
19. Drayage (Port or Rail Yard) Truck Regulation
• Applies to all on-road class 7 and class 8
diesel-fueled vehicles that transport cargo to
and from CA’s ports and intermodal rail yards
• Must register trucks in the Drayage Truck
Registry (DTR)
• Trucks must meet emission standards as
outlined in compliance schedule
There are some additional programs that are specific to CA based carriers that I am not covering in this presentation.2% of CA’s Vehicle are heavy-duty, but they make up 30% of nitrogen oxides (smog) and about 65% of particulate matter (soot)
Just a chance to poke some fun at CaliforniaRiding Horses A Texan, a Californian, and a Nevadan were out riding their horses. The Texan pulled out an expensive bottle of tequila, took a long draught, then another, and then suddenly threw it into the air, pulled out his gun and shot the bottle in midair. The Californian looked at the Texan and said, "What are you doing? That was a perfectly good bottle of whiskey!! The Texan replied, "In Texas, there's plenty of whiskey and bottles are cheap. A while later, not wanted to be outdone, the Californian pulled out a bottle of wine, took a few sips, threw the half full champagne bottle into the air, pulled out his gun, and shot it in midair. The Nevadan couldn't believe this and said "What the heck did you that for? That was an expensive bottle of wine! The Californian replied, "In California there is plenty of wine and bottles are cheap." A while later, the Nevadan pulled out a bottle of Sierra Nevada Pale Ale. He opened it, took a sip, took another sip, then chugged the rest. He then put the bottle back in his saddlebag, pulled out his gun, turned, and shot the Californian. The shocked Texan said "Why in the hell did you do that?" The Nevadan replied, "Well, in Nevada we have plenty of Californians and bottles are worth a nickel."
Allowable Levels of Smoke Opacity-All 1991 or newer engines: Must not exceed 40% smoke opacity.-All pre-1991 engines: Must not exceed 55% smoke opacity.Penalties for Excessive SmokeNotice of Violation (NOV): Issued to pre-1991 vehicles that have smoke opacities greater than 55% but less than 70% and have not received a citation in the past 12 months. Similar to a “fi x-it-ticket,” the NOV has no penalty if repairs are made to the engine and proof of repair is submitted to the ARB within 45 days. After 45 days, the NOV becomes a First Level Citation. Only one NOV may be issued to a pre-1991 vehicle within a 12 month period. First Level Citation: Issued to pre-1991 engines with 70% or greater smoke opacity and 1991 and newer engines with greater than 40% opacity, that have not received any citations in the past 12 months. The minimum penalty is $300 if engine repairs are made and proof of repair is submitted to the ARB within 45 days. After 45 days, the penalty increases to $800. Second Level Citation: The penalty for any further violations within a 12 month period is $1800 for each violation. In addition, proof of repair must be submitted and the vehicle must be retested by the ARB in order to clear the citation. In certain cases, the CHP may take a vehicle out of service for an outstanding citation if the penalty has not been paid, or if the vehicle has not been repaired. The DMV can place a hold on the CA registration renewal until the violation is cleared.
Are there situations where idling is allowed?Yes. Idling is allowed in the following situations:You are stuck in trafficWhen idling is necessary to inspect or service your vehicleYou are operating a power take-off deviceYou cannot move due to adverse weather conditions or mechanical failureYou are queuing (must be beyond 100 feet from any residential area)Your truck’s engine meets the optional low-NOx idling emission standard, and your truck is located more than 100 feet from any residential area (clean-idle label required)
Q: Who may replace my engine label?A: Only authorized dealers can replace an engine label. The identity and emissioncharacteristics of your truck must be verified through an authorized dealer toensure that the label information matches the engine hardware.Q: What vehicles are subject to these new requirements?A: All heavy-duty commercial vehicles that are diesel powered and havegross vehicle weight ratings (GVWR) greater than 10,000 pounds.
GVWR over 14,000
Heavier trucks are 26,000 GVWTo take advantage of the phase in option you had to register, by 31 January, 20143 Day pass for one vehicle, once a calendar year.
Saves $30 per $1,000 of fuel purchased. The additional cost can be as high as $900, in that scenario it would take $30,000 in fuel purchased before you break even.
To comply with the regulation, you may purchase a SmartWay certified tractor and/or trailer, which will come equipped with the approved technologies. You may also comply by retrofitting your trailer with approved low rolling resistance tires and one or more of the following aerodynamic technologies:· Trailer rear fairings • Trailer front gap fairings· Trailer side skirts • Other SmartWay approved technologiesThe type or number of technologies required will be based on the percentage of fuel savings of each device. These required percentages can be found in the regulation at: http://www.arb.ca.gov/regact/2010/truckbus10/truckbus10.htm. The simple answer is 5%.
Example: Based on Option 2 of the Large Fleet Compliance Plan above, an owner of 21 (twenty-one) 53-foot box-type trailers would have had to register and report by June 1, 2012, and ensure that 20 percent or four of the 53-foot trailers were equipped with SmartWay verified aerodynamic requirements by June 1, 2012. Additionally, 40 percent or eight of the 53-foot trailers must be equipped with SmartWay verified aerodynamic requirements by January 1, 2013.Note: Model years 2003 to 2009 refrigerated-van trailers (53-foot or longer box-type trailers with reefer units) equipped with 2003 or newer model year transport refrigeration unit engines, are required to be in compliance by January 1, 2018, for 2003 through 2004 model year trailers; by January 1, 2019, for 2005 through 2006 model year trailers; and by January 1, 2020, for 2007 through 2009 model year trailers. (Refer to question 20)
LETRU-Level 2 VDECS that reduces PM emissions by at least 50%ULETRU-Level 3 VDECS that reduces PM emissions by at least 85%
Did not include class 7 scheduleARB Verified Level 3 diesel particulate matter filter
Tell everyone if they will email me, I will get them a copy of this presentation.