1. GHULAM ALI
Flate#16 Block#A37Johar Complex
Karachi Pakistan
Karachi: 75500,Pakistan.
Email ID:alimahar37@yahoo.com
Phone: (M). +923003264278 Skype id: alimahar50
EXECUTIVE SUMMARY
POST APPLIED FOR: PLANT OPERATOR
ACADEMIC QUALIFICATION:
• B.SC (Physics, Chemistry &Math) Shah Abdul latif University Khairpur(1st division)
• Intermediate (Pre Engineering)from B.I.S.ESukkur in2009 with “B” Grade.
• Matric (science) fromB.I.S.E Sukkur in 2007 with“A” Grade.
APPRENTICE SHIP TRAINING:
 Two Years Apprentice shiptraining as a Chemical Plant Operator fromLOTTE CHEMICAL PAKISTAN PTA Ltd BinQasim Karachi (FormerlyICI
PakistanPTA Plant). From2010 to 2012.
Technical Experience:
 I have experience of BYCO OIL PAKISTAN LIMITED REFINERY one of the largestOil Refinery in Pakistan,as PLANT
OPERATOR ORC2 SINCE SEPT: 2012 to 26 feb:2016
Employment History
 I have 5 years & 6 Month experience of work experience with Oil & Gas sector. I am responsible for Plant Production, Plant Startup,
Shutdown, Trouble shooting, HSE and Production optimization. I am working on, Amine Gas Treatment Plant, Gas Separation Plant,
NaphthaHydro Treating Unit R.O, Cooling tower and Fuel and Flare Gas system. I have worked in commissioning of Amine Gas Treatment
and Gas Separation Plants
Amine Regeneration unit 2400BPSD
 DCS Operation (centum -VP) yoko gawa
 Gas sweetening process withremoval of H2S byMDEA
 MDEA Absorber & Amine regeneration
 Acid Gas burningincinerator Two/Three phase separator
 Amine storage, mixing andloading
Naphtha Hydro treating Unit 38000BSPD
The capacity of unit is 38 MBPD used for removing sulphur and other unwanted compounds from
Crude Unit Overhead Naphtha & gases.
LPG and Gas recovery unit.
A capacity of unit is 38 MBPD for producing Propane, Butane & Feed for C5-C6 Isom & Platformer
Units. The Gas Plant was single train integrated unit consists of De -Ethaniser, De-Propaniser, De-
Butanizer and De-Isohexanizer.
Monitoring & Trouble Shooting Of:
• Absorber, Flash drumand Regenerator
• Positivedisplacementpump, centrifugal pump and compressors
• Gas separator and knock out drum
• Exchanger, kettle Reboiler,Trim cooler and condenser
• De Etherizers, De Butanizer and De Iso Hexanizer
• Balancedraftand Natural Draft Furnace
SH&E Responsibilities:
• To implement Safety, Health& Environment system for companyas wellas contractor’s employs.
• Process monitoring andoptimization, follow upactivities startupandshut downactivities.
• Investigationandreporting ofall Accidents, incidents & Environmental Incidents.
• Compliance for the use of PersonalProtective Equipment & Additional Safety.
• I have experience inoperationgas processing
• Audit & Followup for Fire water system.
• Productionoperations, Startup& shut downincompliance withSOP, routine operation & trouble shooting, handling emergencysituation.

2. • Fire & gas Detection system.
• H2s, HC(hydrocarbon), Smoke & Flame Detection system.
• Fire sprinkler System
• Commissioning Experience Of Pakistan Largest Refinery BYCO Petroleum Ltd
• Actively participated in pre-commissioning, commissioning & Master start up
• Activities in major BYCO Oil Refinery of Pakistan
• Punch listing,systempressurizing, Water flushingof process lines
• Trial run of all types’ pumps and Compressors,air blowing
• Hydro testing and control valves strokingchecked
Instrument loop checking, function test of heaters, compressors
Lotte Chemical Pakistan PTA limited (ICI)
REVERSE OSMOSIS PLANT & PURIFICATION PLANT
COOLING TOWER, PLANT AND INSTRUMENT AIRCOMPRESSOR
 I have good experience of Petrochemical plantand machinerysuch as steam turbine
 Also good knowledge ofCooling water System and good command on Honeywell PLC system
 Check availabilityof standbyequipment and ensure proper chemical dosing
 Check fire extinguisher availabilityandcheck permit inarea.
 Good troubleshooting,problem solving,information analysis and interpersonal skills.
 Able to work under pressure and with the team in developing improved work processes for the department.
 Demonstrate proficiencyin troubleshooting & qualityof jobs assigned.
 Understand the Maintenance ManagementSystem (Work orders,Preventive/Corrective/and Predictive Maintenance
Major Equipment Work on:
 W Type Reciprocating Instrument & Plant air compressor.
 H2S absorption and removal unit.
 Honey well PLC system
 Steam Turbines
 Centrifugal pumps
 PD pumps
 Heat Exchangers.
 Instrumentation and control system.
 Handle the emergencies as a field operator
HSE and Professional Training:
• PTW (Permit to Work) LOTTE Pakistan PTA Limited
• JOB QUALIFIYING PROGRAMFROMPPTA
• Adopting safe work practice bysafetywork permit system/attitude/training
• Effective andfluent communicationinEnglish
• Fire Fighting & SCBA TrainingBYCO oil Pakistanlimited
• CSE (Confinedspace EntryTechniques).
• I have alsogood knowledge of RCMS Procedure, MCS System & MSDS
• Use of10-minutes ESCAPE set (BreathingApparatus)
• Safety assessment / risk analysis/ safety audit/ hazard identification techniques
• Role oftrade unionin the implementationof social clause of WTO’
• PHA, JSA, LOTOTO System
• H2S awareness
Other Skill:
• Communication & presentation
• Team leader & team player qualities
• Group presentation Skill
• Technical presentation and documentation
• Administration, Documentation & Team Work
• Personal:
• NAME: GhulamAli
• Father’s name: Dost Muhammad
• CNIC: 45101 3521094 5
• BIRTH: 03:02:1991
• Domicile Ghotki
• STATUS: SINGLE
• NATIONALITY: Pakistani
• Religion: ISLAM