Potential Innovations in Conventional Desalination Systemsacciona
Durante la celebración de la 13º Edición de IWA Leading Edge Conference on Water and Wastewater Technologie Iwa-LET 2016 que se está celebrando estos días en Jerez, Marina Arnaldos y Beatriz Corzo realizaron una ponencia dentro de un taller sobre desalación sostenible.
On occasion of the 13th IWA Leading Edge Conference on Water and Wastewater Technologies (IWA-LET 2016), which is being held in Jerez, Marina Arnaldos and Beatriz Corzo presented two papers in a workshop on sustainable desalination.
Potential Innovations in Conventional Desalination Systemsacciona
Durante la celebración de la 13º Edición de IWA Leading Edge Conference on Water and Wastewater Technologie Iwa-LET 2016 que se está celebrando estos días en Jerez, Marina Arnaldos y Beatriz Corzo realizaron una ponencia dentro de un taller sobre desalación sostenible.
On occasion of the 13th IWA Leading Edge Conference on Water and Wastewater Technologies (IWA-LET 2016), which is being held in Jerez, Marina Arnaldos and Beatriz Corzo presented two papers in a workshop on sustainable desalination.
A project topic for First years Engineering students in Chemistry and environmental studies. It is suggested to perform the stated experiment separately and let me know if you have any problems! Hope it helps!
Supercritical Water Oxidation Of Sewage Sludge An UpdateAquacritox
Wastewater treatment produces a byproduct referred to as Sludge or Biosolids. Biosolids is a source of energy and the Aquacritox supercritical water oxidation process can convert sludge to heat and electricity. This paper describes a demonstration scale plant in Cork, Ireland.
Leachate management of Constructed wetlands_Yuka Ogata_National Institute for...CRL Asia
Research conducted by National Institute for Environmental Studies, Yuka Ogata on developing constructed wetlands. A research with pilot scale Constructed Wetlands at Sainoi landfill site in Nonthaburi province next to Bangkok city is introduced here.
Evaluation of a hybrid forward osmosis systemacciona
Beatriz Corzo , del departamento de I+D de ACCIONA Agua, presentó la ponencia "Evaluation of a hybrid forward osmosis system for agricultural reuse of high salinity wastewater” en la conferencia anual que la asociación europea de desalación ha celebrado en Roma entre los días 22-26 de mayo de 2016.
This article gives an overview of the most important
innovations that are being developed and implemented in
desalination of seawater or brackish water by
membrane technologies.
Desalination Overview and 24 MLD Jaffna SWRO Project May, 2015 - Water Globe.Private Consultants
TA-8668 SRI: Rapid Assessment of Seawater Desalination and
Other Alternative Water Sources for Jaffna Water Supply Water - Globe Consulting Nikolay Voutchkov
Numerous municipal and industrial projects have enabled Degrémont to consolidate its world-leading position in the desalination field, in particular thanks to its mastery of water treatment technologies, its expertise as builder and operator, its operating support tools, its introduction of effective energy-recovery systems to reduce energy consumption, its solutions to preserve the Earth’s flora and fauna
Membrane Separation Technology for Water Treatment in Upstream Oil & Gas Oper...James Robinson
Membrane Separation Technology for Water Treatment in Upstream Oil & Gas Operations
presented by James Robinson on April 20, 2016, at the "Semi-Annual Water & Wastewater Short Course: Issues, Challenges, Solutions & New Technologies" hosted by the Global Petroleum Research Institute (GPRI) at Texas A&M's Department of Petroleum Engineering.
Silvia Jimenez Herrera, ingeniera de I+D en ACCIONA Agua, presenta la ponencia “Novel Process for Produced Water Polishing: Enhanced Flotation Combined With Advanced Oxidation Processes’ durante la conferencia anual que la asociación europea de desalación ha celebrado en Roma entre los días 22-26 de mayo de 2016.
Forging a New Social Contract - SXSW 2011deb schultz
This is the talk i gave at this year's SXSW to describe the new and emergent social contract we are crafting in a hyper connected world - i.e how is all this new tech impacting how we behave culturally, socially and in business.
Note: I included the "notes" inside each slide - for some reason they were not showing up as a transcript
A project topic for First years Engineering students in Chemistry and environmental studies. It is suggested to perform the stated experiment separately and let me know if you have any problems! Hope it helps!
Supercritical Water Oxidation Of Sewage Sludge An UpdateAquacritox
Wastewater treatment produces a byproduct referred to as Sludge or Biosolids. Biosolids is a source of energy and the Aquacritox supercritical water oxidation process can convert sludge to heat and electricity. This paper describes a demonstration scale plant in Cork, Ireland.
Leachate management of Constructed wetlands_Yuka Ogata_National Institute for...CRL Asia
Research conducted by National Institute for Environmental Studies, Yuka Ogata on developing constructed wetlands. A research with pilot scale Constructed Wetlands at Sainoi landfill site in Nonthaburi province next to Bangkok city is introduced here.
Evaluation of a hybrid forward osmosis systemacciona
Beatriz Corzo , del departamento de I+D de ACCIONA Agua, presentó la ponencia "Evaluation of a hybrid forward osmosis system for agricultural reuse of high salinity wastewater” en la conferencia anual que la asociación europea de desalación ha celebrado en Roma entre los días 22-26 de mayo de 2016.
This article gives an overview of the most important
innovations that are being developed and implemented in
desalination of seawater or brackish water by
membrane technologies.
Desalination Overview and 24 MLD Jaffna SWRO Project May, 2015 - Water Globe.Private Consultants
TA-8668 SRI: Rapid Assessment of Seawater Desalination and
Other Alternative Water Sources for Jaffna Water Supply Water - Globe Consulting Nikolay Voutchkov
Numerous municipal and industrial projects have enabled Degrémont to consolidate its world-leading position in the desalination field, in particular thanks to its mastery of water treatment technologies, its expertise as builder and operator, its operating support tools, its introduction of effective energy-recovery systems to reduce energy consumption, its solutions to preserve the Earth’s flora and fauna
Membrane Separation Technology for Water Treatment in Upstream Oil & Gas Oper...James Robinson
Membrane Separation Technology for Water Treatment in Upstream Oil & Gas Operations
presented by James Robinson on April 20, 2016, at the "Semi-Annual Water & Wastewater Short Course: Issues, Challenges, Solutions & New Technologies" hosted by the Global Petroleum Research Institute (GPRI) at Texas A&M's Department of Petroleum Engineering.
Silvia Jimenez Herrera, ingeniera de I+D en ACCIONA Agua, presenta la ponencia “Novel Process for Produced Water Polishing: Enhanced Flotation Combined With Advanced Oxidation Processes’ durante la conferencia anual que la asociación europea de desalación ha celebrado en Roma entre los días 22-26 de mayo de 2016.
Forging a New Social Contract - SXSW 2011deb schultz
This is the talk i gave at this year's SXSW to describe the new and emergent social contract we are crafting in a hyper connected world - i.e how is all this new tech impacting how we behave culturally, socially and in business.
Note: I included the "notes" inside each slide - for some reason they were not showing up as a transcript
Code, Shmode - people trump algorithms. Tummeling for successdeb schultz
A talk to Startup festival Montreal on the importance of People not just Code. In a world where access to information is cheap and we are no longer command-n-control - the human skills of the "tummler" will ensure success.
An ignite talk I did on the correlation between judaism and the internet. The talk was for fun but there is a lot of truth and depth in some of these similarities.
REMOVAL OF TOXIC CHEMICALS AND BIOLOGICAL POLLUTANTS FROM GROUNDWATER WELLS U...ijac123
Water pollution is one of the most important environmental problems in the world. In developing countries,
contaminated water has frequently caused water diseases. Today, water borne toxic chemicals (anions and
heavy metal ions) and biological pollutants pose a great threat to the safety of water supplies. Currently,
the quality of groundwater with respect to pollutants is of great concern. Modified Downflow Hanging
Sponge (DHS) reactor will be a good groundwater treatment technology in the near future, it is used for
excellent removal of heavy metals, anions, organic pollutants and harmful microbes, and also the reactor
has advantages like low cost, easy to apply and satisfaction level. In order to achieve these objectives,
treatment scheme has been investigated. It consists of mixing organic chelator with impure groundwater in
different concentrations followed by a downflow hanging sponge (DHS) reactor
REMOVAL OF TOXIC CHEMICALS AND BIOLOGICAL POLLUTANTS FROM GROUNDWATER WELLS U...ijac123
Water pollution is one of the most important environmental problems in the world. In developing countries,
contaminated water has frequently caused water diseases. Today, water borne toxic chemicals (anions and
heavy metal ions) and biological pollutants pose a great threat to the safety of water supplies. Currently,
the quality of groundwater with respect to pollutants is of great concern. Modified Downflow Hanging
Sponge (DHS) reactor will be a good groundwater treatment technology in the near future, it is used for
excellent removal of heavy metals, anions, organic pollutants and harmful microbes, and also the reactor
has advantages like low cost, easy to apply and satisfaction level. In order to achieve these objectives,
treatment scheme has been investigated. It consists of mixing organic chelator with impure groundwater in
different concentrations followed by a downflow hanging sponge (DHS) reactor. In the presence of 0.5 g/L
of the chelator, the average removal of total NO3 and NO2 and (total dissolved solids) TDS are respectively
72%, 62% and 75%. The results show that, when Cd treated with chelator, the amount decreases from
0.0063 to 0.0 mgL-1 (100%) after 1 h, Cu decreases from 0.0023 to 0.0 mgL-1 (100%) after 1 h, Fe
decreases from 0.4 to 0.0 mgL-1 (100%) after 1 h, Mn decreases from 0.3 to 0.0 mgL-1 (100%) after 1 h and
Zn decreases from 0.012 to 0.0 mgL-1 (100%) after 1 h. Also, the results show removal of fecal coliform .
Decreased from 50 to 0 and the overall removal efficiency of fecal coliform is (100%).
wastewater in NZ, sewage treatment in NZ, process of wastewater in NZ, process of sewage treatment in NZ, primary secondary tertiary treatment of waste water, screening of wastewater, grit removal tanks, sedimentation, process of separation, anaerobic digestors, activated sludge, trickling filters, oxidation ponds, polishing ponds, disinfection of waste water, wetlands, irrigation, UV lamp disinfection of wastewater, chlorine disinfection of wastewater, ozone disinfection of wastewater
Industrial waste water purification procedurepasindulaksara1
The effluent Treatment Plant (ETP) is a method that is used to treat the emanation coming out from many areas of the plant. It includes biological, physical, and chemical processes. It aims to releasing safe water into the environment to prevent it from getting cop0ntaminated. These plants are have been very useful in the process of providing clean water to the environment and have conserved water in a number of ways.
Evaluation of leachate turbidity reduction in sanitary landfills following a ...TELKOMNIKA JOURNAL
This study evaluates the reduction of leachate turbidity in landfills after applying a mixture of banana starch and thermal water. Principal component analysis was applied to study the combined effect with four variables: pH, concentration of starch and thermal water mixture, rapid mixing speed and slow mixing speed. The experimental design involved 16 experiments with repetition in the jar test to obtain the optimum dose while measuring turbidity as a response variable. The results showed that after the oxidation process of organic matter, under optimal conditions determined in the experiment, the mixture of starch and thermal water contributed to the reduction of leachate turbidity by 29.1%.
1. 1
IWOX®
systems engineered by DMT
The next standard in small scale wastewater treatment
Authors: Joost Edens
1
, Robert Lems
2
, Erwin H.M. Dirkse
3
1
Process eng. DMT B(a)Sc,
2
Manager R&D DMT MSc,
3
Managing Director DMT B(a)Sc.
Date: Monday, 04 November 2013
Companies: DMT Environmental Technology, The Netherlands. Viltra, partner of DMT, Northern Ireland.
ABSTRACT
Both technology and environmental awareness drive legislation for wastewater treatment. Now, the leap from 20/30
(BOD: Biological oxygen demand, mg/l / SS: suspended solids, mg/l) to 10/10 or even 5/5 is possible due to a
different design approach. For years, the sewage treatment plant market was dominated by systems from (septic)
tank suppliers, but now an engineering company from Holland (DMT Environmental Technology) has implemented its
experience from large wastewater treatment plants to design small scale sewage treatment plants (STPs). This
downscaling trajectory started in 2000 with concrete systems and developed to light weight modulated systems. The
current generation STPs engineered by DMT are two different systems, both extensively tested with a CE-certification
period of 40 weeks at the independent university “Van Hall Institute”, an accredited test house based in the
Netherlands. Analyzed discharge pollution concentrations showed that qualities lower then 10/10 (The IWOX
®
Premium-Standard) and even lower than 5/5 (mg/l BOD/SS) (The IWOX
®
Superior) were reached with complete
nitrification. The DMT IWOX
®
Superior also removes Nitrogen (N) by denitrification, which is in line with the scope of
the European Framework Directive. Future development of treatment technology will lead to further reduction of SS,
BOD, Nitrogen and Phosphate. It will also become possible to remove pathogens in the discharge. and DMT are
already anticipating these possibilities by developing special filters and Ultra Filtration membranes for their STPs.
With the continuous improving STP’s, easily capable to reach better discharge qualities then described by legislation,
the main question at this moment is : is the current legislation out of date?
KEY WORDS
Biochemical Oxygen Demand, denitrification, The
DMT IWOX
®
, eutrophication, nitrification, small
scale waste water treatment, STP, suspended
solids.
INTRODUCTION
Discharge of domestic wastewater without
treatment has different ecological consequences,
especially in small water courses. Pollution from
BOD, NH4 and SS causes depletion of oxygen,
which results in possible starvation of smaller and
larger organisms. Furthermore, the emission of
nitrogen (N), phosphate (P) in the ground- or
surface water may result in an overload of nutrients
(eutrophication). The overload enhances excessive
growth of various species in both soil (fast growing
vegetation) and water (algae). This can destroy
sensitive and valuable ecosystems or endanger
drinking water facilities. Emission of BOD, SS, N
and P is already restricted for surface water
according to the European Framework Directive,
and will become restricted for groundwater from
2013 as well.
Looking at the UK (Northern Ireland) and the
Republic of Ireland around 25 % of the waste water
is not treated and another 7 % only primarily.
(2004-2005, EPA, McCumsikey, 2007). The
investment in centralized WWTP’s is too expensive
due to the large distances between houses and
farms. To treat the waste water “on-site” is a better
solution for this problem, however the quality of the
treated water greatly depends on the treatment
technology.
HISTORICAL DEVELOPMENT
From the middle ages faeces were dumped
everywhere. Storage tanks were implemented to
prevent spreading of diseases. These septic tanks
mostly consist of only one chamber and remove 25
to 40 % of the pollutant due to settlement. Due to
rotting processes, these septic tanks are smelly
and dangerous (formation of toxic Hydrogen
Sulphide, H2S) as well as possibly explosive due to
the formation of methane gas (CH4). Therefore the
septic tank has been upgraded by adding an air
blower. The implemented oxygen is being brought
into the water limiting the formation of H2S and CH4.
This also enhances the biological degradation of
COD and NH4. However the air bubbles created
turbulence, which prevented particle settlement
and increased the SS-concentration in the
discharge. A large settlement tank was added to
reduce the SS to achieve a final quality of 20 mg/l
BOD and 30 mg/l SS. These systems (figure 1)
now set the standard both in legislation and
technology in Ireland. Reduction to 5/5 is only
possible by non CE-certified reed beds.
At present some STP tank manufacturers are
trying to increase effluent quality to BOD/SS of
15/30 mg/l. With the development of packed media,
rotating disks etc even a discharge of 10/13 has
been claimed. However this design greatly
complicates the system and increases the chance
of failures and still has minimal nitrification and no
nitrogen removal.
2. 2
Figure 1; current storage systems.
Now DMT has entered the market with a STP
which has been engineered based on down scaling
WWTP technology. These systems easily achieve
10/10 effluent quality with complete NH4 removal
and can even reach better than 5/5 with nitrogen
removal. This makes it possible to meet current
and future legislation.
THEORY
Wastewater can contain various pollutants, in total
being determined as the Chemical Oxygen
Demand (COD, mgO2/l). The COD-value
represents the amount of oxygen required to
chemically degrade all pollutants. Part of the COD
is the “biological oxygen demand” (BOD, mg O2/l).
This represents the amount of pollutants which can
be degraded biologically. In domestic wastewater
this usually is 50 to 80 % of the COD. Main
degradation reaction is;
BiomassOHCOOBODCOD ++→+ 222)(
Other pollutants contain nitrogen (N). About 50 %
to 90 % of the nitrogen compound is ammonium
(NH4). Biological degradation goes in three steps;
first the nitrogen compounds are converted to NH4.
The ammonium is then degraded to nitrate (NO3)
with the addition of oxygen. When bacteria are not
aerated any more, the NO3 can be converted to
nitrogen gas (N2) with the addition of BOD. The
harmless N2 (nitrogen gas) is released into the
atmosphere. Degradation reactions are;
NH4 + O2 → NO3 + H + H2O
BOD + NO3 → N2 + CO2 +H2O
Degradation of NH4 to NO3 is called nitrification,
conversion from NO3 to N2 denitrification.
DESIGNING WWTP
Using years and years of experience in wastewater
engineering, DMT started in 2000 designing and
developing small scale treatment plants (STP’s).
Implementing its knowledge from large WWTP’s
resulted in a complete new design for the STP. The
pollutants are solely removed by flocks of micro
organisms (sludge) without interference of packed
media, discs or other carriers. To avoid any change
of clogging, DMT chose specifically using only
activated sludge for treatment, a proved technology.
The only one mechanical part used is a robust
blower. A sophisticated circulation system
equalizes influent flow fluctuations and prevents
sludge build up as well as SS wash out in a
compact two stage settlement tank. The circulation
system also makes it possible to implement both
nitrification as well as denitrification removing
nitrogen from the waste water.
To enable the sludge-water mixture to circulate,
good settlement is required. In normal WWTP this
is accomplished in large clarifiers. Here, sludge
settles and is circulated back. From existing
dimensioning parameters, a novel highly advanced
and compact clarifier has been developed by DMT.
In picture 1 samples of a well functioning activated
sludge system are shown.
Another new development in STP’s is the use of
the denitrification zone. In this zone, conversion of
NO3 to N2 takes place. The formed nitrogen gas
(N2) can escape to the surrounding air and is not
captured in the sludge. Because of this controlled
denitrification, no NO3 is left after treatment and no
flotation of sludge occur in the settlement tank,
further reducing SS concentrations in the effluent.
IWOX
®
engineered by DMT
Using previously explained theory while keeping
the typical domestic wastewater fluctuations (flow,
COD) in mind, DMT developed from waste water
engineering point of view two novel treatment
systems. Starting in 2000, a concrete system was
certified according to high Dutch standards (BRL
K10002). The current light weight modulated
systems are the next generation STP’s, which have
a reduced footprint and still are capable to reach
discharge values of <10/10 or even <5/5 (Van Hall
Institute, CE certification (NEN-EN 12566-3) and
been designed in conjunction with our partner
company . One existing out of 2 tank (3
compartments), named the DMT IWOX
®
Standard
or IWOX
®
Premium. The other one consists out of
3 tanks (5 compartments), the IWOX
®
Superior.
Picture 1; Picture with three samples (left to
right) influent, activated sludge mixture,
effluent.
3. 3
Figure 2; Flow Schedule IWOX
®
Standard-
Premium.
Figure 2 illustrates a simplified flow schedule of the
IWOX
®
Standard-Premium. Raw wastewater enters
the pre-settlement tank, where large solids settle.
The large variations of influent flows are controlled,
and the water flows gradually to the 2
nd
tank. Here,
wastewater is optimally brought into contact with
micro organisms and air. The micro organisms
(present as sludge) settle in a highly advanced
shaped clarification tank and are returned to the
biological compartment. The purified water then
leaves the system.
Figure 3; Flow Schedule IWOX
®
Superior.
Differences between the Superior (Figure 3) and
the Standard-Premium system are the
implemented denitrification zone (NO3 to N2) and
the second clarifier. The denitrification zone makes
it possible to remove nitrogen, and BOD is further
reduced (both consumed by denitrifying bacteria).
Due to the denitrification, the SS in the effluent is
also lowered. The back-up clarification step is
implemented to minimize wash out of SS even at
peak flows or other disturbances. These
differences reduce the BOD and SS concentrations
to the strictest Irish demand of 5/5. Reduction up to
70 % of Nitrogen is caused due to the
denitrification as well.
Graph 1; BOD, SS concentrations and removal
efficiencies of the IWOX
®
Superior.
With these high removal efficiencies shown in
Graph 1, this system is an alternative to the
standard 20/30 systems with a reed bed. The DMT
system requires only 1/14
th
of the surface
compared to a standard system (shown in image 1).
Image 1; Indicative footprint difference between
footprint of an IWOX
®
Superior (0.8 m
2
) and a
classical 20-30 system (3.2m
2
) + reed bed (8 m
2
).
4. 4
Graph 2; Overview development treatment technologies
1) Data from Balmoral Hydroclear, COD estimated
2) The DMT IWOX®
Superior + grid preliminary results
3) Estimated results IWOX®
Superior with membranes
At this moment, DMT is further developing the
systems by implementing a post-clarifying grid
and/or membranes. First tests with the grid indicate
an improvement for advanced reduction or
complete removal of SS. This system will be further
developed in the near future
CONCLUSION
Treatment of wastewater is required to avoid
environmental problems. Current STP systems set
the technology and legislation standard in Ireland,
and are only achieving 20/30 discharge without
nitrogen removal. Further removal to 5/5 is only
possible with addition of non-certified reed bed
systems. Designing from a waste water
engineering point of view rather than just tank
manufacturing led to the easily better performing /
the IWOX
®
systems. These differences in approach
resulted in far higher removal efficiencies of BOD
and SS and also total removal of ammonium, all
achieved in one compact system (Pictures 2 until 5,
below). Following the European Framework
Directive, nitrogen removal is also standard with
the IWOX
®
Superior, reducing
eutrophication in the environment. At this moment,
novel treatment technologies further reducing
nitrogen, phosphates as well as pathogens are in
development. These will become economically
feasible in the near future.
IS CURRENT LEGISLATION OUT OF DATE?
Current available systems reach easily higher
discharge qualities at economical costs then
described by legislation. An upcoming requirement
in Ireland will be nitrogen removal. Could it
therefore be the case that the current legislation is
out of date?
REFERENCES
Balmoral Hydroclear product sheet.
EPA, 2004-2005. Urban Waste Water Discharges
in Ireland for Population Equivalents greater
than 500 persons. Office of Environmental
Enforcement.
Independent University Van Hall Institute,
department of Agricultural University and
Reseach centre Wageningen.
L. M. McCumiskey, 2007. BE, MSc, FIEI, MICE*P.
F. TONER, PhD, Director and Section Head,
respectively, Environmental Research Unit,
Dublin, Water and Environment Journal,
Volume 6 Issue 1, Pages 89 - 100, Published
Online 26 Jul 2007
Graph 2 shows the development of
treatment technologies commencing
septic tanks. According to the ALARA
(As Low As Reasonably Achievable) the
law should be adjusted to the current
economical best technology.
5. 5
Picture 2; Picture of a IWOX
®
Superior after
placement in Ireland
Picture 3; the IWOX
®
Superior being placed in
Ireland
Picture 4; Robust and light-weighted IWOX
®
Superior being placed in Greece
Picture 5; the IWOX
®
after placement in the
Netherlands