3. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
1. Employing low rotate speed and large diameter up-and-
down conveying device so as to reduce grain crackle ratio.
2. The rubber-
coating technology is applied to main driving wheel of hoister, and its line speed reaches
2m/s.
3. Large drying area, multi drying paths to ensure the average precipitation rate to range f
rom 0.8% to 1.2%.
4. Enhancing the utilization rate of pore plate can enlarge the passing area for hot wind,
which increases the uniformity of grains.
Our grain dryer adopts bi-
directional intersectional drying technique to enlarge the drying area, and the
adjustable grain shunting device to dry grain uniformly, in order to enhance the drying
efficiency and save space for customers.
Various drying modes: air heating furnace, oil burner, steam boiler, etc.
Cheap fuel: rice husk, straw, coal, etc.
4. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
Advanced Drying Technology:
1, Large drying area, good drying medium penetrability, uniform drying, high efficiency.
2, Air heating furnace directly dries grain. During the procedures, grains can circulate continuously an
d rub mutually
to remove the awn, fuzz on their surface, which are discharged by dusting machine. As a result, the cle
anliness of
dried grain is improved.
3, Low temperature balance drying can effectively reduce grain crackle ratio and increase polished ric
e ratio, so as
to improve rice quality.
5. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
4, Man-
machine interface is applied to controlling system, so that the working status of dryer can be displayed
.
It’s easy to handle with either automatic operation or manual operation. Failures will be recognized ea
sily by
displaying automatically so as to facilitate the rectify work, not only safe but also practical.
5, There is no dead area left and the drying process is uniform. The machine is easy to sweep and it ca
n prevent
seeds from mixing together.
6, Applying Japan KETT brand resistance type online moisture detector, which can automatically dete
ct moisture,
control moisture reducing speed, and automatically stop when reaches settled value.
6. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
7, Drive bearing is designed as low rotate speed with three layers of dust proof device to prevent the d
ust from getting inward when bearing turning.
8, After the wet-emitting blower is updated, the maximum volume of passing air can be 17,500
m³/h and the full pressure can be 950Pa. The drying result can be optimized while the running noise ca
n be reduced.
9, The auger vanes are made of 45Mn steel with hardness HRC50 after surface treatment.
7. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
10, The upper and lower augers employ belt to convey, so as to greatly prevent grain from crackling w
hich caused by steel material.
11, Crushing test for single grain shows the purify ratio can reach 99.9%.
Drying layer is changed from the original cold-
rolled plate stencil to stainless steel sheet,
using characteristics of stainless steel thermal conductivity and wear resistance to
improve the
drying rate and service life; Increase the mesh, raise the utilization ratio of plate and
increase
hot air through the area and speed up the drying, improve drying uniformity; Remove the
upper screw conveyor structure, reduce grain damage rate and emptying time, improve
the rate of whole rice.
8. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
Our products are applied to drying rice, corn, wheat, peanut, soybean, mung bean, coffee
bean,sunflower seed and their seeds.
Model Unit 5HX-10 5HX-12.5 5HX-15 5HX-35
Price (FOB) USD 65000 75000 85000 95000
Grain Type and Capacity
Paddy kg 1010-10000 1010-12000 1010-15000 1010-35000
Wheat kg 1100-13000 1230-14000 1230-18000 1230-38000
Suction Fan
Model / 4-72-6A 4-72-6A 4-72-6A LSHG-7A
Type / Centrifugal Fan
Outlet Dia. mm Φ600 Φ600*2
Rotate Speed r/min 1,450
Air Volume m³/h 14500-16500 29000-35000
Full Pressure Pa 700-950 900*1200
9. __________________________________________________________________
______________________________________________________________________________
China Bangla Engineers & Consultants Ltd. Phone: +8801716752370, email: cbecl.info@gmail.com
Web: www.cbecl.info www.cbecl.com Uttara, Dhaka 1230
Hot Blast Furnace
Type / Indirect Heating
Lgnition Mode / Manual Ignition
Fuel Type / Rice Husk Firewood Straw Blind Coal
Total Power kw 11.97 20.97
Dimension(L*W*H) mm 2400*3400*8500 2400*3400*9500 2400*3400*10500 5263*4747*13651
Peformance
Feeding Time min 40-45
Discharging Time min 50-55
Moisture Reducing Rate %/h 0.6-1.0
Safety Device /
Full Volume Alarm, Overload Protection Device, Temperature
Sensor,Control Fuse,Pressure Sensor, Burner Flameout Alarm
Packaging & Shipping
Other Terms:
1. Payment: 35% TT as down payment, 65% before shipment.
2. Validity: 60 days
3. Delivery time: 65 days from down payment.
4. Warranty: 2 years