Dokumen tersebut membahas tentang HaGun Treatment Plant, suatu sistem pembersih udara yang dirancang untuk menangkap debu dan membersihkan udara hasil pembakaran batubara di industri sebelum dibuang ke lingkungan menggunakan prinsip hujan buatan. Sistem ini diharapkan dapat menanggulangi keterbatasan sistem pembersih udara konvensional.
1. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
1
HaGun TREATMENT PLANT
UNTUK MENANGKAP DEBU HASIL PEMBAKARAN BATUBARA
DI COAL FIRING SYSTEM
Hendra Gunawan
E-mail: gunawan_hagun@yahoo.co.id
Abstract
HaGun TREATMENT PLANT as a dust catcher and the air cleaner coal combustion products. Waste dust from
the furnace was arrested using a low pessure wet steam at the steam room. Furthermore, in the clear air at
room raining. The results of this screening is clean air to be released into the environment.
Keywords: HaGun TREATMENT PLANT, steam room, raining room.
Abstrak
HaGun TREATMENT PLANT sebagai penangkap debu dan pembersih udara hasil pembakaran batubara.
Limbah debu dari furnace ditanggkap menggunakan wet steam low pessure at steam room. Selanjutnya udara di
bersihkan di raining room. Hasil dari penyaringan ini adalah udara bersih untuk dilepaskan ke lingkungan.
Kata Kunci: HaGun TREATMENT PLANT, steam room, raining room.
2. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
2
1. Pendahuluan
Batubara sebagai sumber energi utama di industri dan power plant. Hasil pembakaran batubara berupa debu dan
gas buang yang berpengaruh terhadap keseimbangan ekosistem.
Figure 1 Coal Firing System
http://www.climatetechwiki.org/technology/sup_crit_coal
Selama ini, untuk pengendalian debu dan limbah gas hasil pembakaran batubara dengan menggunakan
Electrostatic precipitator.
An electrostatic precipitator (ESP) is a highly efficient filtration device that removes fine particles, like dust and
smoke, from a flowing gas using the force of an induced electrostatic charge minimally impeding the flow of gases
through the unit.
In contrast to wet scrubbers which apply energy directly to the flowing fluid medium, an ESP applies energy
only to the particulate matter being collected and therefore is very efficient in its consumption of energy (in the form
of electricity).http://en.wikipedia.org/wiki/Electrostatic_precipitator
Wet scrubber. The term wet scrubber describes a variety of devices that remove pollutants from a furnace flue
gas or from other gas streams. In a wet scrubber, the polluted gas stream is brought into contact with the scrubbing
liquid, by spraying it with the liquid, by forcing it through a pool of liquid, or by some other contact method, so as to
remove the pollutants.http://en.wikipedia.org/wiki/Wet_scrubber
Electrostatic precipitator mempunyai kemampuan untuk menangkap debu, namun belum sampai untuk
pembersihan udara yang akan dikeluarkan ke lingkungan, karena debu micro dan gas limbah belum
ditanggulanginya.
Akibat dari sistem Electrostatic precipitator, lingkungan di kawasan indistri masih terkontaminasi oleh debu micro
dan gas limbah.
3. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
3
Pengalaman di lingkungan, hujan mampu menjadi pembersih udara. Hal ini terjadi karena air hujan dan unsur
terkandung didalamnya mampu mengikat polutan yang ada di udara.
Bagaimanakah cara hujan membersihkan udara?
HaGun Treatment Plant dirancang meniru pola hujan dalam membersihkan udara. Sehingga udara dari proses
indistri akan dilepas ke lingkungan dalam kondisi bersih.
Berdasarkan ungkapan di latar belakang, maka dalam hal ini, perlu di lakukan penelitian tentang proses pembersihan
udara menggunakan HaGun Treatment Plant.
2. Pembersih Udara Terdahulu
a. Electrostatic Precipitator
An electrostatic precipitator (ESP) is a highly efficient filtration device that removes fine particles, like dust and
smoke, from a flowing gas using the force of an induced electrostatic charge minimally impeding the flow of gases
through the unit.
In contrast to wet scrubbers which apply energy directly to the flowing fluid medium, an ESP applies energy
only to the particulate matter being collected and therefore is very efficient in its consumption of energy (in the form
of electricity).http://en.wikipedia.org/wiki/Electrostatic_precipitator
Figure 2Conceptual diagram of an electrostatic precipitator
http://en.wikipedia.org/wiki/File:Electrostatic_precipitator.svg
b. Wet scrubber
The term wet scrubber describes a variety of devices that remove pollutants from a furnace flue gas or from other
gas streams. In a wet scrubber, the polluted gas stream is brought into contact with the scrubbing liquid, by spraying
it with the liquid, by forcing it through a pool of liquid, or by some other contact method, so as to remove the
pollutants.http://en.wikipedia.org/wiki/Wet_scrubber
4. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
4
Figure 3 Wet Scruber
A packed bed tower design where the mist eliminator is built into the top of the structure. Various tower designs
exist. http://en.wikipedia.org/wiki/File:Packedtowerex.gif
5. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
5
3. HaGun Treatment Plant dan Karakteristiknya
Figure 4 HaGun Treatment Plant Lay Out.
6. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
6
Figure 5 HaGun Treatment Plant 3D Lay Out
Figure 6 HaGun Treatment Plant System at 3D View
7. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
7
Figure 7 HaGun Treatment Plant System at 3D View
Figure 8 HaGun Treatment Plant System at 3D View
8. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
8
Figure 9 HaGun Treatment Plant at 3D View
Figure 10 Screen at Steam Room
9. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
9
Figure 11 Screen system at Steam Room
4. HaGun Treatment Plant in Collaboration With
10. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
10
.
START
CHIMICAL COMPOTITION
DUST AND AIR AFTER
BURNING
REFERENCE:
CHEMICAL BOOKS, ECOLOGY BOOKS,
MECHANICAL BOOKS
ANALYSIS
CHEMICAL ANALYSIS PHISICAL ANALYSIS
ENGINEERING
ANALYSIS
AUTOMATION
STUDY OF
TREATMENT
PLANT
RISK
ANALYSIS
COST
ANALYSIS
RISK
SAFE
AGREE
OVER
DESIGN OF HaGun
TREATMENT PLANT
ACTION
CONTROL
REPORT
FINISH
DEBIT AND VOLUME
DRAFT OF
TREATMENT PLANT
CUTTING PLAN MAN POWER PLAN
PURCHASING ORDER
& DELIVERY ORDER
MECHANICAL WORKS
CIVIL WORKS
ELECTRICAL WORKS
QUALITY
CONTROL
POOR
GOOD
11. Seminar Nasional
Politeknik Negeri Ujung Pandang
INOVASI BAHAN KONSTRUKSI YANG RAMAH LINGKUNGAN
Peluang mengurangi limbah gas dan debu dari industri serta peluang pemanfaatannya sebagai
bahan tambah pada beton.
11
START
DUSTANDAIRAFTER
BURNING
CONTROL
REPORT
FINISH
LOWPRESSUREOF
STEAM
1st
FILTER
MUDSLURRY
PRIMARYAIR
2nd
FILTERBY
ACID
MUDSLURRY
PRIMARYAIR
3th
FILTERBY
BASES
MUDSLURRY
PRIMARYAIR
4th
FILTERBY
NORMAL
FRESHAIR
POOR
POOR
POOR
POOR