3. Product Information
Daily Checkup before starting Maintenance & Servicing
•Check the condition & tire inflation by going The oil change should be done as per below
around the vehicle. schedule at authorized workshop.
•Check engine oil and coolant on display
and check for other messages before starting • Engine Every 20,000. km
the engine . • Transmission Every 60,000. km
•Lamps & lights are essential components , • Axles Every 100,000. km
therefore ensure that all are functioning all the
times.
•Check any oil drops on the ground by going Lubricants and Coolant
around the vehicle & inform to concerned to
avoid any fault development. Use only recommended Lubricants & Coolant..
•Drain the water from fuel / water separator. (See Page 4)
• Use Fuchs Maintain Fricofin premix coolant
for topping up, use MB concentrate
Towing Instructions A 000 989 08 25 to increase the coolant
Remove the propeller shaft from the rear axle concentration.
before towing. Inappropriate towing will cause • Do not add ordinary water for topping up.
damage to the transmission, which cannot be • Fill only PENTOSIN in the hydraulic gear shifting
covered under warranty. and clutch actuation system with green filler cap.
Contact any MB Workshop or JIPCO After Sales Department for complete service & 3
JIPCO
product information
4. List of some Recommended Oil & Coolant Available in K.S.A
DB. Sheet Description Supplier Remarks
Coolant
325.0 Fuchs MAINTAIN FRICOFIN Premix FUCHS
MB Coolant Part No. A 000 989 08 25
Steering and cabin. Tilting Oil
236.7 Mobil ATF 220 MOBIL
236.1 Fuchs Titan ATF 4000 FUCHS
Gear Box Oil
235.1 Mobilube GX-A 80W MOBIL
235.1 TITAN Super Gear S ATW 90 APIGL4 FUCHS
Axles Oil
235.0 Mobilube HD-A 85W90 MOBIL
235.0 Titan Super Gear MC 80W 90 APIGL5 FUCHS
Engine Oil
225.6 Shell Rimula Ultra - 10 w 40 SHELL
228.5 Mobil Delvac XHP Extra 10W-40 MOBIL
228.5 T Cargo MC 10W 40 APIGI 4 FUCHS
Hydraulic fluid for hydraulic gear shifting
and clutch actuation Pentosin CHF 11 S hydraulic fluid (Deutsche Pentosin Werke GmbH. Wedel)
345.0 MB Pentosin Part No. A 001 989 24 03
4 Contact any MB Workshop or JIPCO After Sales Department for complete service &
product information JIPCO
5. Safety Batteries
• Display messages on instrument panel must be followed • Check the acid level every week.
according to owners manual • For topping-up batteries use only distilled water.
Display messages in red color : • Keep the terminals always tightly and clean.
Stop the vehicle as soon as possible and repair the • Disconnect the terminal if the truck is parked more
cause of failure than a week.
Display messages in yellow color : • Do not jump start the vehicle, charge batteries or
Stop the vehicle occasionally and repair the cause of install charged batteries, jump starting may result
failure. in damage of electronic components.
• Automatic fuses: if automatic fuses switch off, check the Display Abbreviations
reason before switching on again.
• Tires, insufficient or excessive tire pressure will damage • BS Telligent Brake System.
the tire. • ABS Anti-Lock Braking System.
• Standard inflation. • GM Base Module.
Tire size. 12.00 R 24 = 110 psi. 7.6 bar • GS Gear Control Unit.
Tire size 315 / 80 R 22.5 = 120 psi. 8.3 bar • MR Engine Control Module.
• Use the same capacity of bulbs when replacing. • FM Front Module
• Brakes,: • KS Clutch Control.
Do not start driving until the air pressure warning • INS Instrument Panel.
lamp comes off. • FR Drive Control Module
•When red color error message related to Brake System • HM Rear Module.
(BS) appears while driving, stop the vehicle as soon as • PSM Programmable Special Module
possible and repair cause of failure.
Contact any MB Workshop or JIPCO After Sales Department for complete service &
JIPCO
product information 5
6. Warranty Information Power Train Includes
Definition
Those sub-
Those sub-assemblies which are
Designation assemblies which
•Warranty means that any failure due to material & included
are excluded
assembly fault appearing on your truck during the warranty
period will be repaired free of charge (labor & parts) in a
JIPCO workshop .
Fuel/air filter, AC
Engine housing, the engine itself, compressor, engine
control module, fuel injection system, suspension, power-
Engine turbocharger, air compressor, inlet assisted steering
Vehicle Warranty and outlet manifolds, engine brake, pump, exhaust gas
water pump, fan, generator, starter filter system, belt
•Complete vehicle for one year and unlimited mileage from drive
the first registration date.
The transmission housing, shafts,
gearwheels, bearings, synchronizer, Transmission
Power Train Warranty Mechanical
EPS system, auxiliary drive, splitter suspension, gear
transmission
box, integrated relay valve, range change stick
•Construction side vehicles 6x4, 8x4 & 6x6, 4x4 : group, splitter
XK3 = 3 years or 250,000 km, whichever comes first.
•4X2 & tractor heads. Axle housing, drive, differential, Suspension, brakes,
XK4 = 3 years or 450,000 km. whichever comes first. differential lock, outer planetary brake parts, rear
Driven rear axle
transmission, intermediate axle center
differential, through-drive assembly
•Any repair during the warranty period does not lead to
extension of the initial vehicle warranty period. Shaft articulation, vibration damper,
Propeller shaft -none-
intermediate bearing
6 JIPCO
7. Not Covered Under Warranty Recommendation for Extended Storage
•Wear and tear parts. e.g. (tires, brake pads, clutch, •Disconnect the negative battery terminal when the
wiper blades, lubricants, filters etc.), vehicle is stored for more than one week.
•Repairs due to use of non genuine parts e.g. (oil •Check the acid level and recharge with battery
filter, air & fuel filter, brake pads, etc). charger for 8 hours on weekly basis.
•Repairs due to use of non recommended fluids, •Drive the vehicle for 5 minutes and keep engine
lubricants and coolant. running for 15 minutes weekly basis.
•Repairs due to misuse, over load, engine over •Inflate the tire pressure 2 bar more than normal.
speed, non respect of owner’s manuals guidelines, •Note: Batteries damaged due to lack of
etc. maintenance during storage are not covered under
•Consequent damages due to accidents. warranty.
•Irregular maintenance.
•Indirect warranty costs such as telephone cost,
travel expenses, loss of earnings, the cost of hiring
vehicles, motorway charges, hotel, towing cost.
•Warranty does not apply if damage is caused by
influences due to Force Majeure and chemical
effects.
Example: Seawater influences, high tide, hail,
stone chips, bird droppings, salt, industrial
emissions and dust deposits, pollen, flooding. etc.
JIPCO 7
8. JIPCO Workshop & Spare Parts Location
Jeddah Riyadh
Old Makkah Road, Kilo-14 Khurais Complex , Nasim.
P.O. Box. No. 16673, Jeddah – 21474 P.O. Box. No. 86, Riyadh - 11411
Tel No. (02) 2802319, 6201374 Tel No. (01) 2310026, 2376136
Fax No. (02) 2802317 Fax No. (01) 2376134
Asir Dammam
Asir Branch, Khamis – Mushayt. Dammam – Alkhobar Highway,
P.O. Box. No. 15192, Sultan City. Khalediyah, Dammam
Abha P.O. Box. No. 24, Dammam - 31411
Tel No. (07) 2271888, 2271188 Tel No. (03) 8571123, 8571206
Fax No. (07) 2271117 Fax No. (03) 8571223.
Spare Parts Sales at Hofuf
MSPA Al Hassa.
Dhahran Street
Al Mubarraz , Opposite KFC
Tel: 5311328, Fax 5313984
Juffali Industrial Products Company (JIPCO)
Central After-Sales Department
Madinah Road, K-14, Jeddah 21432
JIPCO 8