2. Contents
SECTION -- GENERAL
Chapter -- General
CONTENTS
Section Description Page
General Instructions
Health and Safety
Precautionary Statements
Safety
Ecology and the Environment
Minimum Hardware Tightening Torques
Federal Emissions Warranty
Consumables
SECTION -- ENGINE
Chapter -- Engine
CONTENTS
Section Description Page
Specifications
Engine Type
Timing System
Valve Timing Gears
Crankcase and Cylinder Block
Crankshaft and Bearings
Connecting Rod
Piston
Tappet
Rocker Arm and Valve
Rotating Counterweight Dynamic Balancer
Cylinder Head
Tightening Torques
Special Tools
3. SECTION -- ENGINE
Chapter -- Engine (Continued)
CONTENTS
Section Description Page
Description and Operation
Sectional Views
Troubleshooting
Overhaul
Engine
Removal
Installation
Compression Test
Disassembly
Assembly
Crank, Main Bearings and Thrust Rings
Rear Cover with Seal and Engine Flywheel
Synchronizing the Timing Gears
Bosch Injection Pump
Cylinder Head
Valve and Rocker Arm
Fuel Injectors
Cooling System Belt
Cylinder Block
Inspection
Crankshaft and Main Bearings
Crankshaft Inspection
Main Bearing Inspection
Main Bearing Cap Bolt Inspection
Crankshaft Front Oil Seal
Removal
Installation
Engine Flywheel
Refacing
Flywheel Bolts
Inspection
4. Download Link
New Holland TN60VA TN75VA TN95VA Repair Manual
SECTION -- ENGINE
Chapter -- Engine (Continued)
CONTENTS
Section Description Page
Connecting Rods
Inspection
Pistons with Rings, Pins, Connecting Rods, Big End Caps and Bearings
Inspection
Assembly
Installation
Valves, Tappets and Camshaft
Valves, Grinding
Dimensions (mm) of Valves and Valve Guides
Valve Timing Check
Tappets Inspection
Camshaft Inspection
Cylinder Head
Inspection
Valve Seats, Grinding
Valve Guides, Replacement
Rotating Counterweight Dynamic Balancer
Assembly
Installation
Exhaust Pipe
Removal
Installation
SECTION -- ENGINE
Chapter -- Cooling System
CONTENTS
5. Section Description Page
Specifications
Special Tools
Description and Operation
Sectional Views
Overhaul
Thermostat
Flushing the System (Models without Cabs)
Flushing the System (Models with Cabs)
Coolant Thermometer
Coolant Pump Drive Belt
Adjustment
Coolant Pump
Removal
Installation
Disassembly
Assembly
Thermostat Valve
Removal
Installation
Radiator
Removal
Installation
SECTION -- ENGINE
Chapter -- Lubrication System
CONTENTS
Section Description Page
Specifications
Description and Operation
Overhaul
Oil Pump
Removal
Installation
SECTION -- ENGINE
Chapter -- Fuel System
CONTENTS
6. Section Description Page
Specifications
Special Tools
Description and Operation
Fuel Injection (Bosch) Pump
Turbocharged Models
Cold Start Compensation (All Models)
Thermostatic Switch
Mechanical Cold-start Accelerator (KSB)
Overhaul
Fuel Tank
Removal
Installation
Injector Sleeves
Inspection
Removal
Installation
SECTION -- ENGINE
Chapter -- Fuel System (Continued)
CONTENTS
Section Description Page
Injectors
Removal
Installation
Bosch Fuel Injection Pump
Removal
Installation
Checking the Fuel Injection Pump Timing with the
Pump Installed on the Tractor
Lock-time the Fuel Injection Pump with Pump
Removed from the Tractor
Fuel Circuit Air Bleeding
SECTION -- CLUTCH
Chapter -- Clutch
CONTENTS
Section Description Page
7. Specifications
LUK / Clutch
LUK Clutch
Tightening Torques
Special Tools
Description and Operation
Sectional Views
Troubleshooting
Overhaul
SECTION -- CLUTCH
Chapter -- Clutch (Continued)
CONTENTS
Section Description Page
Clutch
Removal
Installation
Dual Disk Clutch /
Disassembly
Assembly
Single Disk Clutch (Fitted with Power Shuttle)
Disassembly
Assembly
Checks, Measurements and Repairs
Dual Disk Clutch
Adjustment of / Dual Clutch Release
Adjustment of Single Plate Clutch Release Levers
Transmission Clutch Pedal Adjustment
Mechanical PTO Clutch Control Adjustments
SECTION -- CLUTCH
Chapter -- Servo Assist PTO Control
CONTENTS
Section Description Page
Description of Operation
Sectional Views
Checks, Measurement and Repairs
Adjusting the PTO Clutch Servo Control
8. Hydraulic PTO Servo Assist Cable Adjustment
Adjusting the PTO Switch
SECTION -- TRANSMISSIONS
Chapter -- Mechanical Transmission
CONTENTS
Section Description Page
Specifications
Reverser
Creeper Unit
Transmission and Range Gear
Tightening Torques
Special Tools
Description and Operation
Sectional Views
Troubleshooting
Gearbox, Creeper Unit and Reverser
Creeper Unit
Overhaul
-- Rear Transmission--Gearbox Casing
Removal
Installation
Gearbox Transmission Casing
Disassembly
Assembly
Gearbox Control Lever
Removal
Installation
Range Gear Control Lever
Removal
Installation
Shuttle Control Lever
Removal (Models Fitted With Mechanical Transmission)
Installation
Adjustments
Transmission--Gearbox Casing
9. SECTION -- TRANSMISSIONS
Chapter -- Mechanical Transmission with Splitter
CONTENTS
Section Description Page
Specifications
Reverser
Creeper Unit
Transmission and Range Gear
Splitter
Tightening Torques
Tools
Description and Operation
Sectional Views
Troubleshooting
Gearbox, Creeper Unit and Reverser
Creeper Unit
Splitter Device
Overhaul
Splitter Device and Creeper Unit Gearbox, Shafts and Bearings
Removal
Installation
SECTION -- TRANSMISSIONS
Chapter -- Power Shuttle Transmission with Dual Command
( Speed Power Shift) Function
CONTENTS
Section Description Page
Specifications
Reverser
Creeper Unit
Transmission and Range Gear
Power Shuttle
Tightening Torques
Special Tools
Description and Operation
Sectional Views
Troubleshooting
10. Gearbox, Creeper Unit and Reverser
Overhaul
Gearbox Transmission Casing
Disassembly
Assembly
Power Shuttle Control Valve
Disassembly
Assembly
Accumulator
Disassembly
Assembly
Gearbox Control Valve Solenoid Valve
Removal
Installation
Gearbox Control Valve Solenoid Valve
Removal
Installation
-- Clutch Casing
Disassembly
Assembly
Download Link
New Holland TN60VA TN75VA TN95VA Repair Manual
SECTION -- TRANSMISSIONS
Chapter -- Power Shuttle Transmission with Dual Command
( Speed Power Shift) Function (Continued)
CONTENTS
Section Description Page
Calibrations
HH Menu Access
H -- Clutches A (Lo) and B (Hi) Calibration
11. H -- Clutches A (Lo) and B (Hi) Calibration Values Display
H -- System Configuration
H -- Software Revision Level
H -- Control Switches Diagnosis
H -- Clutch A (LO) Fill Time Modification and Display
H -- Clutch B (HI) Fill Time Modification and Display
H -- Deleting Data from the Non--Volatile
Memory (NVM) (EEPROM)
H -- Voltmeter Functions
HA -- Clutch Pedal Position and Neutral Switch Display
HB -- Transmission Oil Temperature Display
HD -- Shuttle Synchroniser Position
HE -- Gear Change Adjustments
HF -- Faults Stored in the Non--Volatile Storage of the ECU
First Start--up
Diagnostics
ECU Location
Fault Codes
Fault Code Indication
Fault Code Decoding
Wiring Diagram
Power Shuttle Electronic Control Unit Input/Output
Wiring Diagram ( + and + )
Control Unit Description and Operation
Ignition
Shift from (High) Forward to Reverse Gear
Shift from Reverse to (High) Forward Gears
Shift from (Low) Forward Gear to Reverse Gear
Shift from Reverse to (Low) Forward Gear
SECTION -- FWD TRANSFER BOX AND AUTO FWD
Chapter -- FWD Transfer Box
CONTENTS
Section Description Page
Specifications
FWD Electrohydraulic Engagement
Drive Shaft Data
12. Tightening Torques
Special Tools
Description of Operation
Sectional Views
Troubleshooting
Overhaul
Drive Shafts and Guard
Disassembly (Mod TNNA)
Assembly
Drive Shafts and Guard (Mod TNVA)
Disassembly
Assembly
-- Drive Gear Housing Assembly
Removal
Installation
Drive Gear Housing Removed
Disassembly
Assembly
Drive Gear Housing Removed
Removal
Installation
SECTION -- FWD TRANSFER BOX AND AUTO FWD
Chapter -- FWD Transfer Box (Continued)
CONTENTS
Section Description Page
Calibrations
HH Menu Access
H -- System Configuration
H -- Software Revision Level
H -- Control Switch Diagnostics
H -- Deleting Data from the Non--Volatile Memory (NVM) (EEPROM)
H -- Voltmeter Functions
HD -- FWD Engagement Position
HF -- Faults Stored In the Non--volatile Storage of the ECU
First Start--up
Diagnostics
13. ECU Location
Fault Codes
Automatic FWD Fault Codes Indication
Fault Code Decoding
Wiring Diagram
PTO and FWD Electronic Control Unit Input/Output
SECTION -- FRONT AXLE MECHANICAL TRANSMISSION
Chapter -- Front Axle Mechanical Transmission (SuperSteert Axle)
CONTENTS
Section Description Page
Specifications
Tightening Torques
Special Tools
Description and Operation
Sectional Views
Troubleshooting
Hydraulically Controlled Differential Lock -- Front Axle
Overhaul
Front Axle Assembly
Removal
Installation
Pinion and Front Axle Differential Housing
Removal
Installation
Front Axle Differential Drive
Disassembly
Assembly
Front Axle Differential
Overhaul
Front Differential Lock Clutch Assembly
Disassembly
Assembly
Front Epicyclic Final Drive With Brake
Disassembly
Assembly
Wheel Hub Seal With Front Brakes
14. Disassembly
Assembly
Front Epicyclic Final Drive
Disassembly
Assembly
SECTION -- FRONT AXLE MECHANICAL TRANSMISSION
Chapter -- Front Axle Mechanical Transmission (SuperSteert Axle)
(Continued)
CONTENTS
Section Description Page
Wheel Hub Seal Replacement Less Front Brakes
Disassembly
Assembly
Wheel Hubs and Steering Knuckle
Disassembly
Assembly
Steering Knuckle Pins and Bearings
or Disassembly
Assembly
Steering Sensor Replacement
Disassembly
Assembly
Adjustments
Steering Sensor
Pinion
Differential
Pinion Backlash
SECTION -- FRONT AXLE MECHANICAL TRANSMISSION
Chapter -- Front Axle Mechanical Transmission
CONTENTS
Section Description Page
Specifications
Tightening Torques
Special Tools
Description and Operation
15. Sectional Views
Troubleshooting
Overhaul
Front Axle, Assembly
Removal
Installation
Front Axle Pivot Bushings
Replacement
Front Axle Steering Cylinder
Disassembly
Assembly
Wheel Hubs and Steering Knuckle
Removal
Installation
Front Epicyclic Final Drive
Disassembly
Assembly
Front Axle Differential Housing (For Models Without Brakes)
Removal
Installation
and Hydraulically Controlled Differential Lock With Pinion
(For Models Without Brakes)
Disassembly
Assembly
Front Axle Mechanical Differential Lock (Models Without Brakes)
Disassembly (Pinion Removed)
Assembly
SECTION -- FRONT AXLE MECHANICAL TRANSMISSION
Chapter -- Front Axle Mechanical Transmission (Continued)
CONTENTS
Section Description Page
Front Axle Steering Sensor
Replacement
Pinion With Differential Front Axle (Models With Brakes)
Removal
Installation
16. and Pinion With Mechanically Controlled Differential Lock
(Models With Brakes)
Overhaul
Assembly
Front Axle Pinion
Disassembly
Assembly
Mechanical Differential Lock (Electro--hydraulically Controlled)
Disassembly (Pinion Removed)
Assembly
Adjustments
Pinion (For Models Without Brakes)
Leading Drive Wheels Toe--in Check
Front Axle Steering Sensor
Pinion (Models With Brakes)
SECTION -- REAR AXLE MECHANICAL TRANSMISSION
Chapter -- Rear Axle Mechanical Transmission
CONTENTS
Section Description Page
Specifications
Pinion and Differential
Final Drive
Tightening Torques
Special Tools
Description and Operation
Sectional Views
Troubleshooting
Pinion and Differential
Final Drive
Hydraulically Controlled Differential Lock
Overhaul
Rear Transmission Gearbox
Disassembly
Assembly
-- RH or LH Lateral Final Drive Housing Assembly
Removal
17. Installation
Drive Wheel Shaft
Disassembly
Assembly
Epicyclic Final Drive
Removal
Installation
Adjustments
Adjusting the Position of Differential Lock Engagement Sleeve
Adjusting the Pinion
Adjustment of the Clearance Between the Side and Planetary Pinion Teeth
SECTION -- MECHANICAL POWER TAKE--OFF
Chapter -- Mechanical Power Take-off
CONTENTS
Section Description Page
Specifications
Special Tools
Tightening Torques
Description and Operation
Sectional Views
Troubleshooting
Overhaul
Mechanical PTO
Disassembly
Assembly
SECTION -- BRAKES
Chapter -- Brakes
CONTENTS
Section Description Page
Specifications
Tightening Torques
Description and Operation
Sectional Views
Special Tools
Troubleshooting
18. Overhaul
Right or Left Hand Brake
Removal
Installation
Brake Hydraulic Pump
Removal
Installation
Service Brakes Control Pedals Stroke Adjustment (Tractors with Cabs)
Brake Hydraulic System Air Bleeding
-- Parking Brake
Removal
Installation
Adjustments
Handbrake Control Stroke Adjustment
SECTION -- HYDRAULIC SYSTEMS
Chapter -- Rear Mechanical Hydraulic Lift
CONTENTS
Operation Description Page
Specifications
Rear Hydraulic Lift
Implement Hitching Device
Tightening Torques
Special Tools
Description and Operation
Sectional Views
Troubleshooting
Overhaul
Lift Internal Controls (With the Lift Removed)
Disassembly
Assembly
Adjustments
Op Rod Mechanism Adjustments
Lift Arm Descent Speed Adjustments
Upper Stroke Limit Adjustment Check
Operations to be Performed to Adjust the Upper Stroke Limit
of the Lift-O-Matic Device
19. Arm Shaft and Lift Cylinder (With the Lift Removed)
Disassembly
Assembly
Lift Control Valve DA (With Control Valve Removed)
Disassembly
Assembly
Lift Pressure Relief Valve
Removal
Installation
Settings
SECTION -- HYDRAULIC SYSTEMS
Chapter -- Open Center System Auxiliary Control Valves
CONTENTS
Operation Description Page
Specifications
Special Tools
Tightening Torques
Specifications
Sectional Views
Overhaul
Auxiliary Control Valves (With the Unit Removed)
Disassembly
Assembly
Testing
SECTION -- HYDRAULIC SYSTEMS
Chapter -- Electronically Controlled Hydraulic Lift
CONTENTS
Section Description Page
Specifications
Electronically Controlled Hydraulic Lift
Implement Hitching Device
Tightening Torques
Special Tools
Description and Operation
Sectional Views
21. Connection Between the Calibration and Diagnostic Instrument
to the Diagnostic Connector
Fault Codes
Diagnostics
Front/Rear Electronic Lift Electronic Control Unit Input/Output Wiring Diagram
SECTION -- HYDRAULIC SYSTEMS
Chapter -- Non-Stop Flow Gear Pump
CONTENTS
Operation Description Page
Specifications
Hydraulic Pump C
Bosch Hydraulic Pump
Description and Operation
Sectional View
Overhaul
Lift Oil Pump (With the Pump Removed)
Disassembly
Assembly
SECTION -- STEERING
Chapter -- Steering
CONTENTS
Operation Description Page
Specifications
Tightening Torques
Tools
Description and Operation
Sectional Views
Troubleshooting
Overhaul
Hydrostatic Steering Wheel
Removal
Installation
Hydrostatic Steering Control Valve
Removal
Installation
Disassembly (with the control valve removed)
22. Assembly
Bench Testing
SECTION -- STEERING
Chapter -- Non-Stop Flow Gear Pump
CONTENTS
Operation Description Page
Specifications
Hydraulic Pump A
Hydraulic Pump A XRP
Tightening Torques
Description and Operation
Sectional Views
Overhaul
Hydrostatic Steering Oil Pump (with the pump removed)
Disassembly
Assembly
SECTION -- AXLES AND WHEELS
Chapter -- Axles and Wheels
CONTENTS
Section Description Page
Specifications
Sectional View
Tightening Torques
Tools
Troubleshooting
Overhaul
Front Axle Hub
Disassembly
Assembly
Front Axle
Removal
Installation
Stub Axle
Removal
Installation
23. Adjustments
Checking the Alignment of the Leading Wheels
SECTION -- CAB CLIMATE CONTROL
Chapter -- Heating, Ventilation, and Air Conditioning
CONTENTS
Operation Description Page
Safety Precautions
Specifications
Special Tools
Description and Operation
Main Components
Sanden SD H Model Compressor
Condenser
Filter/Dryer
Thermostatic Expansion Valve
Electronic Thermostatic Switch (Antifrost)
Evaporator
Warnings for Air Conditioning System Repair Operations
Cab Heating and Ventilation Controls
Ventilation
Electric Fan
Air Filter
Temperature Control Knob
Ignition Switch
Cab Air Conditioning Controls
Temperature Control Knob
Electric Fan Control Knob
Recovery--Recycling and Evacuation--Charging Stations ()
Filter/Drying, Recharging and Refrigeration Check
Recycling of Recovered Refrigerant
Discharge of Recovered Oil
Transfer of Decontaminated Refrigerant from
Cylinder () to an External Cylinder
Evacuation and Charging the Cab Air Conditioning System
Using the Evacuation/Charging Station
Charging the Graduated Cylinder () of the
24. Evacuation/Charging Station
Evacuation of the Cab Air Conditioning System
SECTION -- CAB CLIMATE CONTROL
Chapter -- Heating, Ventilation, and Air Conditioning (Continued)
CONTENTS
Operation Description Page
Charging the Cab Air Conditioning System (After Evacuation)
With New Oil
Charging the Cab Air Conditioning System
With Refrigerant (After Evacuation)
Summary of the Air Conditioning System Charging Operations
Checking for and Eliminating Any Gas Leaks
Testing for Leaks With Leak Detector
Checking for Refrigerant Leaks Using an Electronic Leak Detector
Leak Detector ()
Refrigerant Gas Leak Test
Adjustments
Troubleshooting
Visual Inspection of Components
Functional Tests
Checking Air Temperature
Checking for Gas Leaks (with Detector )
Overhaul
Cab Heating/Air Conditioning System
Removal
Installation
Cab Heating Unit
Disassembly
Assembly
Cab Air Conditioning System Evaporator Unit
Disassembly
Assembly
Cab Fan Unit
Disassembly
Assembly
25. SECTION -- ELECTRICAL SYSTEM
Chapter -- Instruments
CONTENTS
Section Description Page
Specifications
Analog Instruments
Indicator Light Panel
Transmitters, Sensors and Switches
Electronic Module Instruments
Maintenance
Replacing the Multi-purpose Warning Lights on the Instrument Panel
SECTION -- ELECTRICAL SYSTEM
Chapter -- Components
CONTENTS
Section Description Page
Description of Components
Central Console Panel
Analog Control Panel
Digital Instrument Control Panel
Dashboard Controls
Central Console Controls
Controls on Right--hand Mudguard
(Version With Electronically Controlled Lift)
External Controls
Cab Controls On Cab Ceiling
Cab Air Conditioning Controls
Controls On Right--hand Cab Upright
Maintenance
Electronic Lift Control Lights
Replacement
Front Headlight Bulbs
Replacement
Front Sidelight and Direction Indicator Lamp Bulbs
Replacement
Front and Rear Work Light Bulbs
Replacement
26. Work Light Bulbs On Tractors With Roll Bar
Replacement
Rear Sidelights, Brake and Direction Indicator Light Bulbs
Replacement
Courtesy and Adjustable Reading Light Bulbs
Replacement
Number Plate Light
Replacement
SECTION -- ELECTRICAL SYSTEM
Chapter -- Starting System
CONTENTS
Section Description Page
Specifications
Tightening Torques
Description and Operation
Troubleshooting
Fault Diagnosis
System Testing
Starting System Test on Tractor
Current Absorbed on the Starter Motor Circuit
Starting System Circuit Resistance
Battery Positive Cable
Starter Motor Ground Connection
Battery Ground Cable
Overhaul
Starter Motor
Removal
Installation
Starter Motor
Disassembly
Assembly
Armature Axial End-Float
Testing
Starter Motor Test (Without Load)
Bench Tests
27. SECTION -- ELECTRICAL SYSTEM
Chapter -- Charging System
CONTENTS
Section Description Page
Specifications
Tightening Torques
Description and Operation
Alternator Operation
System Testing and Troubleshooting
Battery Check
Driving Belt Check
Warning Light Check
Alternator Wire Connection Tests
Charging Current and Regulated Voltage Tests
Charging Circuit Voltage Drop Tests
Maximum Alternator Output Test
Overhaul
Alternator
Removal
Disassembly
Assembly
Overhaul
Installation
SECTION -- ELECTRICAL SYSTEM
Chapter -- Battery
CONTENTS
Section Description Page
Specifications
Description and Operation
Overhaul
Battery
Removal
Installation
Battery Checking and Maintenance
Troubleshooting
SECTION -- ELECTRICAL SYSTEM
28. BOOK -
Chapter -- Electrical Circuits
CONTENTS
Section Description Page
Specifications
Electrical Circuit Components
Description and Operation
Location of Fuses and Relays (Version with Cab)
Fuse and Relay Layout on Cab Right--hand Upright
Location of Fuses and Relays (Version Without Cab)
SECTION -- ELECTRICAL SYSTEM
Chapter -- Electrical Circuits (Continued)
CONTENTS
Section Description Page
Power Sockets -- Fig
Symbols Used In Electrical Circuits
Wire Color Coding
Wiring Diagrams and Connections Identification Code
Ground Location Points
Electrical Circuits
Wiring Diagrams
Starter and Recharging Circuit (Diagram A)
Operator Safety Circuit (Diagram B)
Tail/Side Lights, Full Beam, Dipped Beam, Number Plate and Instrument Lighting
(Diagram C)
Direction Indicator and Hazard Lights Circuit (Diagram D)
Wiring Diagrams
Cooling and Heating System, Windscreen Wiper, Rear Window Wiper,
Radio and Internal Lighting (Diagram E)
Cooling and Air--conditioning System, Windscreen Wiper, Rear Window Wiper
and
Internal Lighting (Diagram F)
Work Lights, Rotating Beacon Circuit (Diagram G)
Wiring Diagrams
Power Shuttle Circuit (Transmission Side) (Diagram I/)
Power Shuttle Circuit (Dashboard Side)
29. Rear Electronic Lift Circuit (Diagram L)
Wiring Diagrams
Differential Lock and Brake Lights Circuit (Mechanical FWD Version)
(Diagram M)
Differential Lock and Brake Lights Circuit (Electrohydraulic FWD Version)
(Diagram N)
SECTION -- ELECTRICAL SYSTEM
Chapter -- Electrical Circuits (Continued)
CONTENTS
Section Description Page
Differential Lock and Brake Lights Circuit (Permanent FWD Version)
(Diagram O)
FWD Control Unit Circuit
(Diagram P)
Wiring Diagrams
Transmission Circuit (Version with Permanent FWD and Mechanical Lift)
(Diagram Q/)
Transmission Circuit (Version with Electrohydraulic FWD and Electronic Lift)
(Diagram R/)
Wiring Diagrams S/ -- S/ -- T/ -- T/
Transmission Circuit (Version with WD and Mechanical Lift) (Diagram S/)
Transmission Circuit (Version with WD and Mechanical Lift) (Diagram S/)
Transmission Circuit (Version with Permanent FWD and Electronic Lift)
(Diagram T/)
Transmission Circuit (Version with Permanent FWD and Electronic Lift)
(Diagram T/)
Wiring Diagrams U/ -- U/ -- V -- Z -- W
Transmission Circuit (Version with Permanent FWD and Electronic Lift) --
Dashboard Side (Diagram U/)
Transmission Circuit (Version with Permanent FWD and Electronic Lift) --
Dashboard Side (Diagram U/)
Horn, Power Sockets (Iso -- North America) Circuit (Diagram V)
Digital Instrument Circuit (Diagram Z)
Sensors and Transmitters Circuit (Diagram W)
Power Shuttle Electronic Control Unit Input/Output Wiring Diagram (Diagram X)
Rear Electronic Lift Control Unit Input/Output Wiring Diagram (Diagram Y)
30. Front PTO and FWD Electronic Control Unit Input/Output Wiring Diagram
(Diagram K)
SECTION -- ELECTRICAL SYSTEM
Chapter -- Cab Electrical Components
CONTENTS
Section Description Page
Overhaul
Direction Indicator Switch
Replacement
Installation
Multi--indicator Panel
Removal
Installation
Zero--setting Hours Worked
Setting Hours Worked
Services Electronic Control Unit
Removal
Installation
Power Shuttle Electronic Control Unit
Removal
Installation
Fusebox
Removal
Installation
Fuses -- Relays
Removal
Installation
Loudspeakers
Removal
Installation
Internal Lighting Support Fitting
Removal
Installation
Windscreen Wiper Motor
Removal
Installation
31. Rear Windscreen Wiper Motor
Removal
Installation
SECTION -- PLATFORM, CAB, BODYWORK
Chapter -- Cab
CONTENTS
Operation Description Page
Overhaul
Hood
Removal
Installation
Hood RH/LH Side Panel
Removal
Installation
Instrument Panel Lower Guard
Removal
Installation
Platform Assembly
Removal
Installation
Instrument Panel Support Fitting
Removal
Installation
Front Roll Bar
Removal
Installation
Cab Assembly with Platform
Removal
Installation
-- Cab Windows Seals
Removal
Installing the Window
Seal on Right- or Left-hand Upright
Removal
Installation
Cab Ceiling Fitting