RANGER - EVEREST
WIRING DIAGRAMS

RHD / LHD
MY 2006 - 2008
CONTENTS
RANGER
	

BASE MANUAL

		

DEC. 2005 (F198-30-05L)

	
...
RANGER

CONTENTS
SECTION

TITLE

PREVIOUS

WIRING DIAGRAMS

NEW

GI
(GENERAL INFORMATION)

W
(ELECTRICAL WIRING SCHEMATIC)...
VEHICLE IDENTIFICATION NUMBERS (VIN)
(CHASSIS NUMBERS)

MNB BS******
MNB DS******
MNB LS******
MNB US******

Form No. F1A1...
SYSTEM INDEX
00 GENERAL INFORMATION
R READING WIRING DIAGRAMS
VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2
VEHICLE IDE...
00R

Reading Wiring Diagrams

VEHICLE IDENTIFICATION NUMBER (VIN) CODE

M N B B S 1 D 1 0 6W 1 2 3 4 5 6
Serial No.
Plant
...
Reading Wiring Diagrams

00R

VEHICLE IDENTIFICATION NUMBERS (VIN)

MNB BS******
MNB DS******
MNB LS******
MNB US******

3...
00R

Reading Wiring Diagrams

CONTENTS OF WIRING DIAGRAMS
• This manual comprises the sections shown below.

NEW

PREVIOUS...
00R

Reading Wiring Diagrams
GROUND POINTS
• This shows ground points of the harness.
GROUND POINTS (4SD)
3

G-01 JOINT CO...
00R

Reading Wiring Diagrams

SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM
• These diagrams show the circuits for each system,...
00R

Reading Wiring Diagrams
The number indicates that the circuit
continues to the related system
diagram.

System code

...
00R

Reading Wiring Diagrams

ROUTING DIAGRAM
• The routing diagram shows where electrical components are on the system ci...
00R

Reading Wiring Diagrams
HARNESS SYMBOLS
DESCRIPTION OF HARNESS

SYMBOL

DESCRIPTION OF HARNESS

SYMBOL

FRONT HARNESS...
00R

Reading Wiring Diagrams

SYMBOLS
Symbol

Meaning

Symbol

Meaning

Battery

• Generates electricity through chemical
...
00R

Reading Wiring Diagrams
Symbol
Switch (1)

Meaning

Symbol

• Allows or breaks current flow by
opening and closing cu...
00R

Reading Wiring Diagrams
Symbol

Meaning
• The wiring position can be exchanged freely within the
connector.

Extent o...
00R

Reading Wiring Diagrams
FM

FREQUENCY MODULATION

PNP

PARK/NEUTRAL POSITION

FP

FUEL PUMP

PRC

PRESSURE REGULATOR ...
00P

Electrical System General Procedures

ELECTRICAL PARTS
Battery Cable

B6U000000006W03

• Before disconnecting connect...
Electrical System General Procedures

00P

• Connectors can be disconnected by pressing or
pulling the lock lever as shown...
00P

Electrical System General Procedures

Terminals
Inspection
• Pull lightly on individual wires to verify that they are...
Electrical System General Procedures

00P

• When replacing a pullout fuse, use the fuse puller.

YMU000WAK

ELECTRICAL TR...
Form No. F1A1-10-05L

ELECTRICAL WIRING SCHEMATIC

00E

18
00F
Form No. F1A1-10-05L

FUSE BOX

20
Form No. F1A1-10-05L

COMMON CONNECTOR LIST

00C-1

22
Form No. F1A1-10-05L

COMMON CONNECTOR LIST

23

00C-2
Form No. F1A1-10-05L

COMMON CONNECTOR LIST

00C-3

24
Form No. F1A1-10-05L

COMMON CONNECTOR LIST

25

00C-4
00G-a
Form No. F1A1-10-05L

GROUND POINT

26
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

4

[WL-C, WE-C]

5

3

1

6

C-04
WITH AIR BAG SYSTEM
WITHOUT AIR BA...
00G-b
Form No. F1A1-10-05L

GROUND POINT

28
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)
9

11

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]
(R)-(DR3)

10

C-15
13...
Form No. F1A1-10-05L

DATA LINK CONNECTOR

00D

30
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

(F)-(F2)

[WL-C, WE-C]

C-09

MAIN FUSE BLOCK
(REFER TO 00F SECTION)...
0117
Form No. F1A1-10-05L

CHARGING SYSTEM

32
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[BLACK]
(F)-(E)

C-05

[GRAY]
(F)-(E)

C-06
MAIN FUSE BLOCK
(REFER T...
0119
Form No. F1A1-10-05L

STARTING SYSTEM

34
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[BLACK]
(F)-(E)

C-05

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-3)

0140-1a

36
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

[GRAY]
FUEL PUMP SPEED SENSOR

0140-109
[BLACK]
EGR SOLENOID VALVE
(...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-3)

0140-1b

38
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

[GRAY]
FUEL INJECTION PUMP

0140-113
[BLACK]
(F)-(E)

C-05
[GRAY]
(F...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-3)

0140-1c

40
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[GRAY]
FUEL INJECTION PUMP

3

0140-119
[GRAY]
CKP SENSOR

0140-121
...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-C, WE-C)

0140-2a

42
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

(F)-SHORT CORD

0140-204

F-...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-C, WE-C)

0140-2b

44
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[BLACK]
FUEL INJECTOR No.3

0140-214
[BLACK]
FUEL INJECTOR No.4

[GR...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-C, WE-C)

0140-2c

46
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[GRAY]
EGR VALVE POSITION SENSOR

0140-217

[BLACK]
VARIABLE BOOST C...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-C, WE-C)

0140-2d

48
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[BLACK]
BOOST SENSOR/
INTAKE AIR TEMPERATURE SENSOR No.1

0140-223

...
Form No. F1A1-10-05L

CONTROL SYSTEM (WL-C, WE-C)

0140-2e

50
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

4
[BLACK]
ACCELERATOR PEDAL POSITION SENSOR

0140-229

[BLACK]
PCM

...
Form No. F1A1-10-05L

REMOTE FREEWHEEL CONTROL SYSTEM

0318-a

52
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[BLUE]
LOCK SOLENOID VALVE

0318-01

FREE SOLENOID VALVE

0318-02
MA...
Form No. F1A1-10-05L

REMOTE FREEWHEEL CONTROL SYSTEM

0318-b

54
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

[BROWN]
TRANSFER NEUTRAL SWITCH

[BLACK]
(F)-(E)

0318-05

C-05

[BL...
Form No. F1A1-10-05L

4 WHEEL ANTILOCK BRAKE SYSTEM (4WABS)

0413-1

56
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

C-08
(F)-(F2)

0413-104

(R)-(R2)

C-09

11

[BLACK]
ABS HU/CM

[GRA...
Form No. F1A1-10-05L

REAR ANTILOCK BRAKE SYSTEM

0413-2

58
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

9

[GRAY]
ABS SPEED SENSOR

ABS HU

0413-203

0413-204
10

MAIN FUSE...
Form No. F1A1-10-05L

HEATER AND AIR CONDITIONER

0740

60
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

A/C RELAY

0740-07
[GRAY]
(F)-(E)

[BLACK]
(F)-(E)

C-05

C-06
MAIN ...
62

Form No. F1A1-10-05L

AIR BAG SYSTEM SERVICE CAUTIONS / SERVICE WARNINGS

0810
63

Form No. F1A1-10-05L

AIR BAG SYSTEM SERVICE CAUTIONS / SERVICE WARNINGS

0810
Form No. F1A1-10-05L

AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION)

0810-1a

64
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

65
SHORT CONNECTOR

08...
Form No. F1A1-10-05L

AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION)

0810-1b

66
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]

[YELLOW]
DRIVER-SIDE PRE-TE...
Form No. F1A1-10-05L

REAR WINDOW DEFROSTER

0912-1

68
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
FILAMENT

0912-103

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]
M...
Form No. F1A1-10-05L

POWER WINDOW SYSTEM

0912-2a

70
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

POWER WINDOW MAIN SWIT...
Form No. F1A1-10-05L

POWER WINDOW SYSTEM

0912-2b

72
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

(F)-(DR1)

C-11

C-02
(F)-(R)

POWER WINDOW SUBSWITCH RR

0912-203

...
Form No. F1A1-10-05L

POWER OUTER MIRROR

0912-3

74
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)
POWER OUTER MIRROR SWITCH

F-...
Form No. F1A1-10-05L

POWER DOOR LOCK SYSTEM

0914-1a

76
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

DOOR LOCK-LINK SWITCH
...
Form No. F1A1-10-05L

POWER DOOR LOCK SYSTEM

0914-1b

78
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

DOOR LOCK CONTROL MODULE
WL-3

0914-101

(F)-(DR1)

C-10

0914-101

...
Form No. F1A1-10-05L

KEYLESS CONTROL MODULE

0914-2

80
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

81
5

6

F-02
0914-201...
Form No. F1A1-10-05L

IMMOBILIZER SYSTEM

0914-3

82
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[WL-C, WE-C]

COIL

0914-302
MAIN FUSE BLOCK
(REFER TO 00F SECTION)
...
Form No. F1A1-10-05L

THEFT-DETERRENT SYSTEM

0914-4a

84
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

[BLACK]
BONNET SWITCH
...
Form No. F1A1-10-05L

THEFT-DETERRENT SYSTEM

0914-4b

86
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[GRAY]
DOOR LOCK-LINK SWITCH RR

MAIN FUSE BLOCK
(REFER TO 00F SECTI...
0918-1
Form No. F1A1-10-05L

HEADLIGHT

88
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
[BLACK]
HEADLIGHT RH

0...
Form No. F1A1-10-05L

LICENSE PLATE LIGHT / PARKING LIGHT / TAILLIGHT

0918-2

90
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
TAILLIGHT RH

9

0918-204

[STRETCH CAB (WITH REAR ACCESS SYS...
0918-3
Form No. F1A1-10-05L

FRONT FOG LIGHT

92
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

1

0918-303
FRONT FOG ...
Form No. F1A1-10-05L

TURN AND HAZARD WARNING LIGHT

0918-4

94
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

[GRAY]
FRONT SIDE TURN LIGHT RH

[STRETCH CAB (WITH REAR ACCESS SYST...
0918-5
Form No. F1A1-10-05L

BACK-UP LIGHT

96
Form No. F1A1-10-05L

HARNESS SYMBOL:

[WL-C, WE-C]

(F)

(E)

(R)
[BLACK]
BACK-UP LIGHT RH

[BLACK]
(F)-(E)

C-05

MAIN F...
Form No. F1A1-10-05L

BRAKE LIGHT / HIGH-MOUNT BRAKE LIGHT

0918-6

98
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
BRAKE LIGHT RH

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]

MAIN...
Form No. F1A1-10-05L

ILLUMINATION LIGHT

0918-7

100
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

REAR WINDOW DEFROSTER SWITCH ILLUMINATION

0912-102

HAZARD WARNING ...
0918-8
Form No. F1A1-10-05L

INTERIOR LIGHT

102
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]
(R)-(DR3)

C-15
INTERIOR LIG...
Form No. F1A1-10-05L

WINDSHIELD WIPER AND WASHER

0919

104
Form No. F1A1-10-05L

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
WINDSHIELD WIPER MOTOR
...
Form No. F1A1-10-05L

ACCESSORY SOCKET / CIGARETTE LIGHTER

0920-1

106
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

107
5

6

F-02
FUSE BL...
0920-2a
Form No. F1A1-10-05L

AUDIO SYSTEM

108
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
[BLACK]
TWEETER RH

092...
0920-2b
Form No. F1A1-10-05L

AUDIO SYSTEM

110
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

REAR SPEAKER RH

0920-203

AUDIO UNIT

0920-201

(R)-(DR3)

C-19

(F...
Form No. F1A1-10-05L

INSTRUMENT CLUSTER

0922-1a

112
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)
[BROWN]
VEHICLE SPEEDOMETER SENSOR

[WL-C, WE-C]

MAIN FUSE BLOCK
(RE...
Form No. F1A1-10-05L

INSTRUMENT CLUSTER

0922-1b

114
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

BRAKE FLUID LEVEL SENSOR

0922-110

115

INSTRUMENT CLUSTER

0922-10...
Form No. F1A1-10-05L

INSTRUMENT CLUSTER

0922-1c

116
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

[GRAY]
SEDIMENTOR SWITCH

0922-112
[BLACK]
(F)-(E)

C-05
[GRAY]
(F)-...
0922-2
Form No. F1A1-10-05L

HORN

118
Form No. F1A1-10-05L

HARNESS SYMBOL:

(F)

(E)

(R)

HORN RELAY
MAIN FUSE BLOCK
(REFER TO 00F SECTION)

0922-201

F-01

0...
ALPHABETICAL INDEX
4

F
4X4 INDICATOR SWITCH ..................................... 54

FILAMENT..............................
ALPHABETICAL INDEX
L

TRANSFER NEUTRAL SWITCH............................ 54
TURN LIGHT .....................................
CONTENTS
SECTION

TITLE

FOREWORD
This wiring diagram incorporates the wiring schematics
of the RANGER and available optio...
VEHICLE IDENTIFICATION NUMBERS (VIN)
(CHASSIS NUMBERS)

WF0 LM1D10*W
WF0 LM1E10*W
WF0 LMAD10*W
WF0 LMAE10*W
WF0 LMED10*W
W...
SYSTEM INDEX
00 GENERAL INFORMATION
R READING WIRING DIAGRAMS
VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2
VEHICLE IDE...
00R

Reading Wiring Diagrams

VEHICLE IDENTIFICATION NUMBER (VIN) CODE

W F 0 L M 1 D 1 0 6W 1 2 3 4 5 6
Serial No.
Plant
...
Reading Wiring Diagrams

00R

VEHICLE IDENTIFICATION NUMBERS (VIN)

WF0 LM1D10*W
WF0 LM1E10*W
WF0 LMAD10*W
WF0 LMAE10*W
WF...
Form No. F1A4-20-06D

ELECTRICAL WIRING SCHEMATIC

00E

4
00F
Form No. F1A4-20-06D

FUSE BOX

6
Form No. F1A4-20-06D

COMMON CONNECTOR LIST

00C-1

8
00G-a
Form No. F1A4-20-06D

GROUND POINT

10
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

3
1

C-04
(F)-(R)

C-03

11

(F)-(R)

2

7
4
5

6

C-03
(F)-(R)

C-0...
00G-b
Form No. F1A4-20-06D

GROUND POINT

12
Form No. F1A4-20-06D

(F)

HARNESS SYMBOL:

(E)

(R)
9

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]

10

(R)-(DR3)

11

C-15

...
0119
Form No. F1A4-20-06D

STARTING SYSTEM

14
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

C-05
(F)-(E)
[BLACK]

...
0913
Form No. F1A4-20-06D

SEAT WARMER

16
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

[STRETCH CAB
(WITH REAR ACCESS SYSTEM)]

MAIN FUSE BLOCK
(REFER TO 0...
Form No. F1A4-20-06D

KEYLESS CONTROL MODULE

0914-2

18
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

19
5

6

F-02
FUSE BLO...
Form No. F1A4-20-06D

IMMOBILIZER SYSTEM

0914-3

20
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
3

21

COIL
IMMOBILIZER...
0918-1
Form No. F1A4-20-06D

HEADLIGHT

22
Form No. F1A4-20-06D

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
[BLACK]
HEADLIGHT RH

0...
Form No. F1A4-20-06D

LICENSE PLATE LIGHT / PARKING LIGHT / TAILLIGHT

0918-2

24
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
TAILLIGHT RH

9

0918-204

[STRETCH CAB (WITH REAR ACCESS SYS...
0918-3
Form No. F1A4-20-06D

FRONT FOG LIGHT

26
Form No. F1A4-20-06D

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01

1

0918-303

27

FRONT...
Form No. F1A4-20-06D

TURN AND HAZARD WARNING LIGHT

0918-4

28
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
REAR TURN LIGHT RH

[GRAY]
FRONT SIDE TURN LIGHT RH

0918-204...
0918-5
Form No. F1A4-20-06D

BACK-UP LIGHT

30
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
BACK-UP LIGHT RH

0918-204

[STRETCH CAB (WITH REAR ACCESS SY...
Form No. F1A4-20-06D

BRAKE LIGHT / HIGH-MOUNT BRAKE LIGHT

0918-6

32
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)
[BLACK]
BRAKE LIGHT RH

[STRETCH CAB (WITH REAR ACCESS SYSTEM)]

0918...
Form No. F1A4-20-06D

ILLUMINATION LIGHT

0918-7a

34
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

HAZARD WARNING SWITCH ILLUMINATION

0918-402
REAR WINDOW DEFROSTER S...
Form No. F1A4-20-06D

ILLUMINATION LIGHT

0918-7b

36
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

RFW MAIN SWITCH ILLUMINATION

0318-03
4

[BLUE]
PANEL LIGHT CONTROL ...
Form No. F1A4-20-06D

HEADLIGHT LEVELING SYSTEM

0918-9

38
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

1

0918-903
HEADLIGHT LEVELING ACTUATOR RH
[GRAY]

39
2

0918-902
HE...
0918-10
Form No. F1A4-20-06D

REAR FOG LIGHT

40
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

[BLACK]
(R2)-SHORT CORD

9
10

REAR FOG LIGHT SWITCH

0918-101

5

0...
Form No. F1A4-20-06D

WINDSHIELD WIPER AND WASHER

0919

42
Form No. F1A4-20-06D

(F)

HARNESS SYMBOL:

(E)

(R)

MAIN FUSE BLOCK
(REFER TO 00F SECTION)

F-01
WINDSHIELD WIPER MOTOR
...
Form No. F1A4-20-06D

INSTRUMENT CLUSTER

0922-1a

44
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)
[BROWN]
VEHICLE SPEEDOMETER SENSOR

0922-104

4

[STRETCH CAB (WITH R...
Form No. F1A4-20-06D

INSTRUMENT CLUSTER

0922-1b

46
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

BRAKE FLUID LEVEL SENSOR

0922-110

47

INSTRUMENT CLUSTER

0922-101...
Form No. F1A4-20-06D

INSTRUMENT CLUSTER

0922-1c

48
Form No. F1A4-20-06D

HARNESS SYMBOL:

(F)

(E)

(R)

[GRAY]
SEDIMENTOR SWITCH
[BLACK]
(F)-(E)

0922-112

C-05

49
INSTRUM...
ALPHABETICAL INDEX
O

B
BACK-UP LIGHT .................................................... 30
BACK-UP LIGHT SWITCH ..........
CONTENTS
TITLE

RANGER
Wiring Diagrams
Supplement
FOREWORD
This wiring diagram incorporates the wiring schematics
of the R...
VEHICLE IDENTIFICATION NUMBERS (VIN)
(CHASSIS NUMBERS)
Australian specs.
MNA BS1D90*W
MNA BS1E90*W
MNA BS2D90*W
MNA BS2E90...
SYSTEM INDEX
00 GENERAL INFORMATION
R READING WIRING DIAGRAMS
VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2
VEHICLE IDE...
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
manual electrico ranger courier (ford)
Upcoming SlideShare
Loading in...5
×

manual electrico ranger courier (ford)

3,367

Published on

0 Comments
2 Likes
Statistics
Notes
  • Be the first to comment

No Downloads
Views
Total Views
3,367
On Slideshare
0
From Embeds
0
Number of Embeds
1
Actions
Shares
0
Downloads
171
Comments
0
Likes
2
Embeds 0
No embeds

No notes for slide

manual electrico ranger courier (ford)

  1. 1. RANGER - EVEREST WIRING DIAGRAMS RHD / LHD MY 2006 - 2008 CONTENTS RANGER BASE MANUAL DEC. 2005 (F198-30-05L) SUPPLEMENTS APR. 2006 (F1A4-20-06D) JUL. 2006 (F1A5-30-06G) JUL. 2006 (F1A5-40-06G) RANGER / EVEREST SUPPLEMENTS AUG. 2006 (F1A9-30-06H) SEP. 2006 (F1B1-20-06I) SEP. 2006 (F1B1-30-06I)
  2. 2. RANGER CONTENTS SECTION TITLE PREVIOUS WIRING DIAGRAMS NEW GI (GENERAL INFORMATION) W (ELECTRICAL WIRING SCHEMATIC) FB (FUSE BLOCK) JB GENERAL INFORMATION (JOINT BOX) 00 X (COMMON CONNECTOR) Y (GROUND POINT) FOREWORD This wiring diagram incorporates the wiring schematics of the RANGER and available optional equipment. Actual vehicle wiring may vary slightly depending on optional equipment or local specifications, or both. U (DATA LINK CONNECTOR) A (CHARGING SYSTEM/ STARTING SYSTEM) B ENGINE 01 (ENGINE CONTROL SYSTEM) Q (CRUISE CONTROL SYSTEM) All the contents of this manual, including drawings and specifications, are the latest available at the time of printing. As modifications affecting repair or maintenance occur, relevant information supplementary to this volume will be made available at Ford dealers. This manual should be kept up-to-date. SUSPENSION — DRIVELINE/AXLE — BRAKES TRANSMISSION/ TRANSAXLE STEERING HEATER, VENTILATION & AIR CONDITIONING (HVAC) RESTRAINTS Ford Motor Company reserves the right to alter the specifications and contents of this manual without obligation or advance notice. All rights reserved. No part of this book may be reproduced or used in any form or by any means, electronic or mechanical-including photocopying and recording and the use of any kind of information storage and retrieval system-without permission in writing. BODY & ACCESSORIES SYSTEM CIRCUIT DIAGRAM/CONNECTOR LOCATIONS For proper repair and maintenance, a thorough familiarization with this manual is important, and it should always be kept in a handy place for quick and easy reference. O (ANTI-LOCK BRAKE SYSTEM) H (EC-AT CONTROL SYSTEM) N 02 03 04 05 (ELECTRIC POWER STEERING SYSTEM) 06 G 07 (AIR CONDITIONING SYSTEM) S (SEAT BELT/AIR BAG SYSTEM) 08 C (GAUGE CONTROL SYSTEM) D (WIPER SYSTEM) E (EXTERIOR LIGHTING SYSTEM) F (SIGNAL SYSTEM) I (INTERIOR LIGHTING SYSTEM) J (AUDIO SYSTEM) 09 K (DOOR/WINDOW SYSTEM) L (MIRROR SYSTEM) M (SUNROOF SYSTEM) P (POWER SEAT SYSTEM) T Ford Motor Company (SECURITY AND LOCKS SYSTEM/OPTION) ALPHABETICAL INDEX APPLICATION: This manual is applicable to vehicles beginning with the Vehicle Identification Numbers (VIN) shown on the following page. AI (ALPHABETICAL INDEX) AI © 2005 Ford Sales & Sarvice PRINTED IN THAILAND, DEC. 2005 F198-30-05L Form No. F198-30-05L
  3. 3. VEHICLE IDENTIFICATION NUMBERS (VIN) (CHASSIS NUMBERS) MNB BS****** MNB DS****** MNB LS****** MNB US****** Form No. F1A1-10-05L
  4. 4. SYSTEM INDEX 00 GENERAL INFORMATION R READING WIRING DIAGRAMS VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2 VEHICLE IDENTIFICATION NUMBERS (VIN)................3 CONTENTS OF WIRING DIAGRAMS ............................4 GROUND POINTS ..........................................................5 SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM ...6 ROUTING DIAGRAM ......................................................8 HARNESS SYMBOLS.....................................................9 WIRING COLOR CODE ..................................................9 SYMBOLS .....................................................................10 ABBREVIATIONS USED IN THIS MANUAL .................12 P ELECTRICAL SYSTEM GENERAL PROCEDURES......14 E F C G 08 RESTRAINTS 10 AIR BAG SYSTEM AIR BAG SYSTEM SERVICE CAUTIONS/ SERVICE WARNINGS................................................ 62 AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION) ...................................... 64 09 BODY & ACCESSORIES 12 GLASS/WINDOWS/MIRRORS REAR WINDOW DEFROSTER ................................... 68 POWER WINDOW SYSTEM ........................................ 70 POWER OUTER MIRROR ........................................... 74 14 SECURITY AND LOCKS POWER DOOR LOCK SYSTEM .................................. 76 KEYLESS CONTROL MODULE................................... 80 IMMOBILIZER SYSTEM............................................... 82 THEFT-DETERRENT SYSTEM .................................... 84 18 LIGHTING SYSTEMS HEADLIGHT ................................................................. 88 LICENSE PLATE LIGHT ............................................... 90 PARKING LIGHT........................................................... 90 TAILLIGHT .................................................................... 90 FRONT FOG LIGHT ..................................................... 92 TURN AND HAZARD WARNING LIGHT...................... 94 BACK-UP LIGHT .......................................................... 96 BRAKE LIGHT .............................................................. 98 HIGH-MOUNT BRAKE LIGHT...................................... 98 ILLUMINATION LIGHT................................................ 100 INTERIOR LIGHT ....................................................... 102 19 WIPER/WASHER SYSTEM WINDSHIELD WIPER AND WASHER ....................... 104 20 ENTERTAINMENT ACCESSORY SOCKET.............................................. 106 CIGARETTE LIGHTER............................................... 106 AUDIO SYSTEM ......................................................... 108 22 INSTRUMENTATION/DRIVER INFO. INSTRUMENT CLUSTER........................................... 112 HORN ......................................................................... 118 POWER, GROUND & COMMON CONNECTOR ELECTRICAL WIRING SCHEMATIC ...........................18 FUSE BOX ....................................................................20 COMMON CONNECTOR LIST .....................................22 GROUND POINT...........................................................26 DATA LINK CONNECTOR D DATA LINK CONNECTOR ............................................30 01 17 19 40 ENGINE CHARGING SYSTEM ...................................................32 STARTING SYSTEM.....................................................34 CONTROL SYSTEM WL-3 ..............................................................................36 WL-C, WE-C ..................................................................42 03 DRIVELINE/AXLE 18 4-WHEEL DRIVE REMOTE FREEWHEEL CONTROL SYSTEM..............52 04 BRAKES 13 ANTILOCK BRAKE SYSTEM 4 WHEEL ANTILOCK BRAKE SYSTEM (4WABS) .......56 REAR ANTILOCK BRAKE SYSTEM.............................58 07 HEATER, VENTILATION & AIR CONDITIONING (HVAC) AI ALPHABETICAL INDEX ALPHABETICAL INDEX ............................................. 120 40 CONTROL SYSTEM HEATER AND AIR CONDITIONER...............................60 Two digits (section ID) indicated in front of each title are commonly used with the Workshop Manual. 1 Form No. F1A1-10-05L
  5. 5. 00R Reading Wiring Diagrams VEHICLE IDENTIFICATION NUMBER (VIN) CODE M N B B S 1 D 1 0 6W 1 2 3 4 5 6 Serial No. Plant Production year W=A. A. Thailand 6= 2006 7= 2007 No meaning 0 Engine type 1= WL-C (2.5 L-DI) 2= WL-3 (2.5 L Diesel-Emission Turbo) 9= WE-C (3.0 L-DI) Gross vehicle weight Body style Product sorce Air bag World manufacturer identification D= 2268—2721 kg {5001—6000 lbs} E= 2722—3175 kg {6001—7000 lbs} A= Regular cab.-without box B= Regular cab.-with box E= Double cab.-without box F= Double cab.-with box 1= Stretch cab. (with Rear Access System) -without box 2= Stretch cab. (with Rear Access System) -with box S= Japan (for Thailand) B= Seatbelt only D= with Air bag (Driver side) L= with Air bag (Driver and Passenger) U= with Air bag (Driver, Passenger and Side air bag) MNB= FORD (Thailand) 2 Form No. F1A1-10-05L
  6. 6. Reading Wiring Diagrams 00R VEHICLE IDENTIFICATION NUMBERS (VIN) MNB BS****** MNB DS****** MNB LS****** MNB US****** 3 Form No. F1A1-10-05L
  7. 7. 00R Reading Wiring Diagrams CONTENTS OF WIRING DIAGRAMS • This manual comprises the sections shown below. NEW PREVIOUS P Electrical system general procedures A how-to on using and reading wiring diagrams, using test General information of equipment, checking harness GI wiring diagrams and connectors, and finding trouble spots E Electrical wiring schematic Shows main fuses and other fuses for each system R Reading wiring diagrams GENERAL INFORMATION Fuse box complete wiring 00 F system J Joint box/Junction box complete wiring system Shows internal circuits and connectors W Electrical wiring schematic Fuse block complete FB wiring system Joint box complete wiring JB system C Common connector list Shows connectors common throughout system G Ground point Ground routes from and to the Y battery D Data link connector X Common connector list Ground point U 14 Fuel system 17 Charging system Data link connector A 12 Cooling system Charging system/Starting system B Engine control system 01 18 Ignition system C Gauge control system 19 Starting system D Wiper system 20 Cruise control system E Lighting system 40 Control system ENGINE F Signal system G Air-conditioning system H Transmission control/Key interlock/Shift-lock system I Interior light system J Audio/Radio system SUSPENSION 02 12 Wheel and tires DRIVELINE/AXLE 03 18 4-Wheel drive BRAKES 04 14 Traction control system 13 Antilock brake system 15 Dynamic stability control 13 Automatic transmission TRANSMISSION/ TRANSAXLE 05 Automatic transmission shift 14 mechanism 17 Automatic transaxle 18 Automatic transaxle shift mechanism 13 Electric power steering (EPS) STEERING 06 HEATER, VENTILATION & AIR CONDITIONING (HVAC) 07 40 Control system RESTRAINTS 08 Shows circuit and connector diagrams and component and connector location diagrams K Power window/Power door lock system 14 Power steering L Remote control mirror system 10 Air bag system 11 Seat belt M Sliding sunroof system 12 Glass/Windows/Mirrors O Anti-lock brake system N Electric power steering (EPS) P Power seat/Seat warmer system Q Auto cruise control system 22 Instrumentation/Driver info. S Air bag system 40 Control system T Others 13 Seats 14 Security and locks 15 Sunroof BODY & ACCESSORIES 09 18 Lighting systems 19 Wiper/Washer system 20 Entertainment 21 Power systems AI Alphabetical Index Gives page number of circuit diagram for each component AI Alphabetical Index Depending on the vehicle model, the actual sections may be different. 4 Form No. F1A1-10-05L
  8. 8. 00R Reading Wiring Diagrams GROUND POINTS • This shows ground points of the harness. GROUND POINTS (4SD) 3 G-01 JOINT CONNECTOR(F) 8 4 G-02 JOINT CONNECTOR(F) B B B B B B B/O 3 4 6 B A D C B A D B B E C B B B B C B G-03 JOINT CONNECTOR(D) D B C A E B B B B B B B D E B B 12 B C B E E 10 7 D B B/W B 9 5 A A E D C B A (WITHOUT AIR BAG SYSTEM) D B C A E B B B B B B B E D C B A (WITH AIR BAG SYSTEM) WITH ABS B(EM) B(EM) 4 B(EM) 5 B(EM) B(F) B(F) B(F) TO EACH UNIT B (F) B(D) B(D) 5 B(EM) 1 10 G-03 B(D) 6 B(F) TO EACH UNIT B(D) 4 B(EM) G-01 B(F) EMISSION HARNESS (EM) B(D) 11 B(D) B(D) DASH HARNESS (D) B(D) B/W(EM) B(D) WITH AIR BAG SYSTEM TO EACH UNIT FRONT HARNESS (F) B(D) B(F) 3 B/O(D) G-02 3 WITHOUT AIR BAG SYSTEM B(F) B(I) 8 B(I) 9 B(I) B(F) 9 2 B(F) B(F) B(F) INSTRUMENT PANEL HARNESS (I) B(IN) 7 B B(F) 12 INTERIOR LIGHT HARNESS (IN) SHORT CORD Ground indication On vehide Indication On circuit diagrams and ground points The ground connection numbers in system circuit diagrams correspond to those in the ground point diagram. To circuit CONTROL SYSTEM BATTERY - IG KEY 60A MAIN 100A F-09 + D F-07 C-01 B(E) B/W(F) A INJ OR FIP 30A B/W(D) B F-05 BTN 40A B(F) J-05 G W/R(F) W/R(D) A L/R (D) ENGINE 10A 14 S T C-06 G F-04 F-03 2 U D L/R(E) J-04 IG1 IG2 L(D) W/Y (EM) 1E L/R(EM) AA C-06 SPV RELAY (SECTION 0140-1b) L/R (EM) 1B F H B/L (EM) 1A LG/R (EM) ACC C-03 J-01 B/L(D) MAIN RELAY C-09 C-03 OFF ENGINE SWITCH ST Y/L(F) I Y 1B J F-04 W/G(EM) F-04 ROOM 10A 8 A F-03 F-03 B(D) J-03 1F 0140-101 B/W (F) 0140-103 3W 0140-102 PCM 2M 3R 3P 1S 1N LG (EM) BR/B (EM) G/B (EM) G/W (EM) 23 GLOW PLUG RELAY 22 1Q 0140-101 L (EM) 0140-102 L (E) F-01 F-03 I B (E) J 0140-105 C-09 11 B 31 14 DATA LINK CONNECTOR(DLC) (SECTION 00D) B (EM) 0140-104 L/B (EM) V L(E) L (E) A/C RELAY (SECTION 0740-2) AD FAN RELAY (SECTION 0740-2) REFRIGERANT PRESSURE SWITCH (SECTION 0740-1) GLOW PLUG 5 0140-101 PCM(EM) 1U 1O 1S Y W/L 1V B/W 1K L/R 1I 1G 1T 1R 1C 1A 2O LG/R R/Y L/R G/R B/L V W/Y R 1F 1D 1B 2P 1E P/L V/W 0140-103 GLOW PLUG RELAY(F) 1M L/W 1Q W/R L/B W/G G/W 1P 1N 1L 1J 1H 0140-104 GLOW PLUG(SHORT CORD) 2K 2I 2G 2A 3Y R/Y GY/R P/B B/W 2E 2M L 2C LG/B BR/W R/L L/W 2N 0140-105 ENGINE(E)-SHORT CORD (E) 2L 2J 2H 2F 2D 3U 3W BR/Y L/Y 3Z 3X 3O 3M 3K 3I LG BR/B Y/B 3V 3T 3A 3G 3R 3E V R/B R/L O 2B 3Q 3S L/R 3P 3N R G W L 3L 3J 3H 3F 3C B G/R G/Y B/O 3D 0140-102 GLOW PLUG RELAY(E) L/R L B 3B (SHORT CORD) B L B 5 Form No. F1A1-10-05L
  9. 9. 00R Reading Wiring Diagrams SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM • These diagrams show the circuits for each system, from the power supply to the ground. The power supply side is on the upper part of the page, the ground side on the lower part. The diagrams describe circuits with the ignition switch off. Below is an explanation of the various points in the diagram. CONTROL SYSTEM System name BATTERY + - MAIN 100A F-09 IG KEY 60A D F-07 C-01 B(E) B/W(F) A B F-05 B(F) INJ OR FIP 30A G F-03 F-03 F-04 Y/L(F) W/G(EM) GLOW 40A Y Connector code 0517: 0518: 0613: 0614: 0740: 0810: 0811: 0912: 0913: 0914: 0915: 0918: 0919: 0920: 0921: 0922: 0940: W/Y (EM) 1E 1B 0140-101 3W 0140-102 2M 3P LG (EM) BR/B (EM) 22 0140-101 L (EM) 0140-102 F-01 B (E) 3R 23 GLOW PLUG RELAY Fuse box connectors Joint box/Junction box connectors Common connectors Ground point connectors Data link connector Cooling system connectors Fuel system connectors Charging system connectors Ignition system connectors Starting system connectors Cruise control system connectors Engine control system connectors Wheel and tires connectors 4-Wheel drive connectors Antilock brake system connectors Traction control system connectors Dynamic stability control connectors Automatic transmission connectors Automatic transmission shift mechanism connectors Automatic transaxle connectors Automatic transaxle shift mechanism connectors Electric power steering (EPS) connectors Power steering connectors Heater, ventilation & air conditioning (HVAC) control system connectors Air bag system connectors Seat belt connectors Glass/Windows/Mirrors connectors Seats connectors Security and locks connectors Sunroof connectors Lighting systems connectors Wiper/Washer system connectors Entertainment connectors Power systems Instrumentation/Driver info. Connectors Control system U LG/R (EM) L/R(EM) B/W (F) F: J: C: G: D: 0112: 0114: 0117: 0118: 0119: 0120: 0140: 0212: 0318: 0413: 0414: 0415: 0513: 0514: F-03 D L/R(E) 0140-103 F-03 I V L(E) L (E) C-09 G F-04 MAIN RELAY C-09 F-04 The prefix letter indicates the system in which the connector is used. S T I 0140-105 J B B (EM) DATA LINK CONNECTOR(DLC) (SECTION 00D) 0140-104 GLOW PLUG 5 0140-101 PCM(EM) 1U 1O L/B W/G W/L V/W 1V 1T 1R L/W L/R 1K 1I 1G 0140-103 GLOW PLUG RELAY(F) 1C 1A 2O LG/R R/Y R/W G/R B/L 1Q W/R 1M P/L 1S Y G/Y W/Y 1E W/Y G/W 1P 1N 1L 1J 1H 0140-104 GLOW PLUG(SHORT CORD) 1F 2K 1D 1B L 2G 2E 2A 2C LG/B BR/W R/L L/W R 2P 2N 2L 2J R/Y GY/R P/B BR/Y L/Y 2H 2F 2D O 2B 0140-105 ENGINE(E)-SHORT CORD (E) B/W 2I 2M (SHORT CORD) B L B Ground numbers A harness ground is represented differently than a unit ground. Types of grounds Symbol Harness 9 Unit Sensor 6 Form No. F1A1-10-05L
  10. 10. 00R Reading Wiring Diagrams The number indicates that the circuit continues to the related system diagram. System code Multiplex communication 0140-1a Indicates communication with connected parts. Signals are transmitted back and forth between connected parts. DATA LINK CONNECTOR(DLC) (SECTION 00D) B/W(D) B(D) 16 1B C-06 J-04 B G/Y (EM) W/Y (EM) R/W (EM) OFF ENGINE SWITCH ST ENGINE 10A 14 A C-03 IG1 IG2 J-01 ACC C-03 Current symbol L(D) B/L(D) AA F H Current flows in the direction of the arrow. B/L (EM) 0140-101 1F 1D 1I 1A PCM 2C 2A 1S 2B Indicates shielded wire.* 2E * Shielded wire : Prevents signal disturbances from electrical interference. Wire is covered by a metal meshing for grounding. R/Y (EM) SHIELD WIRE 0140-107 INTAKE AIR TEMPERATURE SENSOR NO.1 W/R (EM) P/B (EM) 0140-107 O (EM) GY/R (EM) O (EM) B (EM) 14 REFRIGERANT PRESSURE SWITCH (SECTION 0740-1) Connector symbols 0140-106 • Male and female connectors are represented as follows BOOST SENSOR in the circuit and connector diagrams. 4 3Y 3U 3W B/W 3Q 3X 3M 3K 3I 3S V LG BR/B Y/B 3V 3T 3R 3P 0140-106 BOOST SENSOR(EM) P/B GY/R 3N R 0140-102 GLOW PLUG RELAY(E) 3A 3G R/B L/R R/L 3Z 3O 3E 3C B G/Y G/R G W L 3L 3J 3H 3F B 3B 0140-107 INTAKE AIR TEMPERATURE SENSOR NO.1(EM) O O Connector diagram symbol L B/O 3D Circuit diagram symbol L/R L Male Male R/Y Female Female R L R Wire color code (harness symbol) • Like connectors are linked by dashed lines between the connector symbols. • Two-color wires are indicated by a two-letter • Connector diagrams show connectors on the harness symbol.The first indicates the base color of the wire, the second the color of the stripe. For example: W/R is a white wire with a red strip BR/Y is a brown wire with a yellow strip side. The terminal indicates the view from the harness side. (Example) Symbol (Example) Connector on harness side Solid color wire B Black (F) Striped wire W/R (F) White (base color) View from harness side Red(stripe) • Colors for connectors except white are given in locations. • Unused terminals are indicated by ∗. • The harness symbol is in ( ) following the harness symbols (refer to P-9.). 7 Form No. F1A1-10-05L
  11. 11. 00R Reading Wiring Diagrams ROUTING DIAGRAM • The routing diagram shows where electrical components are on the system circuit diagram by call out line and connector symbols. Connector symbol Component name Ground symbol Shows the system that uses the connector. Shows the names of components in routing diagrams. Shows the ground in system diagrams. (Example) Connector Symbol Common connectors C-02 System connectors HARNESS SYMBOL : 0922-05 (F) (E) (R) INSTRUMENT CLUSTER VACUUM SWITCH 0922-01 0922-05 (F)-(I) 6 C-02 1 (F)-(I) C-02 0922-06 PARKING BRAKE SWITCH 8 Form No. F1A1-10-05L
  12. 12. 00R Reading Wiring Diagrams HARNESS SYMBOLS DESCRIPTION OF HARNESS SYMBOL DESCRIPTION OF HARNESS SYMBOL FRONT HARNESS (F) DOOR No. 1 HARNESS (DR1) FRONT No. 2 HARNESS (F2) DOOR No. 2 HARNESS (DR2) ENGINE HARNESS (E) DOOR No. 3 HARNESS (DR3) DASH HARNESS (D) DOOR No. 4 HARNESS (DR4) REAR HARNESS (R) FLOOR HARNESS (FR) — REAR No. 2 HARNESS (R2) INTERIOR LIGHT HARNESS (IN) — REAR No. 3 HARNESS (R3) A/C HARNESS (AC) — INSTRUMENT PANEL HARNESS (I) INJECTION HARNESS (INJ) — HAND BRAKE HARNESS (HB) — — — EMISSION HARNESS (EM) EMISSION No. 2 HARNESS (EM2) EMISSION No. 3 HARNESS (EM3) — WIRING COLOR CODE COLOR CODE COLOR CODE BLACK B ORANGE O BLUE L PINK P BROWN BR RED R DARK BLUE DL SKY BLUE DARK GREEN DG TAN T GRAY GY VIOLET V GREEN G WHITE W LIGHT BLUE LB YELLOW Y LIGHT GREEN LG SB 9 Form No. F1A1-10-05L
  13. 13. 00R Reading Wiring Diagrams SYMBOLS Symbol Meaning Symbol Meaning Battery • Generates electricity through chemical reaction. • Supplies direct current to circuits. Light • Emits light and generates heat when current flows through filament. 3.4W Ground (1) 1 Ground (2) Ground (3) • Connecting point to vehicle body or other ground wire where current flows from positive to negative terminal of battery. • Ground (1) indicates a ground point to body through wire harness. • Ground (2) indicates point where component is grounded directly to body. ––––––––––––––– Resistance Remarks • Current will not flow through a circuit if ground is faulty. Motor • Converts electrical energy into mechanical energy. Pump • Pulls in and discharges gases and liquids. Cigarette lighter • Electrical coil that generates heat. • Melts when current flow exceeds that specified for circuit, interrupts current flow. Fuse Precautions • Do not replace with fuses exceeding specified capacity. <Blade type> • A resistor with a constant value. • Mainly used to protect electrical components in circuits by maintaining rated voltage. <Tube type> Fuse (For high current fuse)/ Fusible link Accessory socket <Cartridge type> • Interior power supply. <Fusible link> • Generates sound when current flows. Horn Speaker Transistor (1) Collector (C) Base (B) • Electrical switching component. • Turns on when voltage is applied to the base (B). NPN B Emitter (E) Transistor (2) Collector (C) Base (B) PNP Emitter (E) E C EC B C E B • Reading code. 2 S C 828 A Semiconductor Number of terminals • Generates heat when current flows. Heater Collector indication mark Ignition switch Revision mark B2 A:High-frequency PNP B:Low-frequency PNP C:High-frequency NPN D:Low-frequency NPN B1 ST IG2 OFF IG1 OFF ACC • Turning ignition key switches circuit to operate various component. (NOTE) Ignition switch is called engine switch on diesel vehicles. 10 Form No. F1A1-10-05L
  14. 14. 00R Reading Wiring Diagrams Symbol Switch (1) Meaning Symbol • Allows or breaks current flow by opening and closing curcuits. Meaning Harness Connection D When circuit C-D is connected to circuit A-B, the connection D is indicated by a black dot. Normally open Switch (2) B A C For vehicles with ABS, use the A-B circuit. Selection WITH ABS A Normally closed Autostop switch Relay (1) Diversion point D for the different circuits according to the vehicle’s specification is indicated by a white dot. • Automatically shuts off circuit when certain conditions are met. D B WITHOUT ABS C For vehicles without ABS, use the C-B circuit. • Current flowing through coil produces electromagnetic force causing contact to open or close. No current to coil Current to coil Flow No flow Normally open Relay (2) • Current flowing through coil produces electromagnetic force causing contact to close. No current to coil Current to coil Flow No flow Normally closed Sensor (1) • Detects characteristics such as intake manifold vacuum and airflow amount according to resistance variation. Solenoid Sensor (2) • Detects resistance variation according to operation of other parts. Diode Sensor (3) • A resistor whose resistance variation according to temperature variation. • When temperature increases, resistance decreases. Sensor (4) • Known as a semiconductor rectifier, the diode allows current flow in one direction only. Anode(A) Flow of electric current Cathode(K) K • Detects pulse signals from rotating object. Sensor (5) • Current flowing through coil generates electromagnetic force to operate plungers. • Generates potential difference when tension or pressure is applied. Light-emitting diode (LED) A K A K A • A diode that lights when current flows. • Unlike ordinary bulbs, the diode does not generate heat when lit. Cathode(K) Anode(A) Cathode(K) Anode(A) Flow of current Capacitor • Component that temporarily stores electrical charge. Reference diode (Zener diode) • Allows current to flow in one direction up to a certain voltage; allows current to flow in the other direction once that voltage is exceeded. 11 Form No. F1A1-10-05L
  15. 15. 00R Reading Wiring Diagrams Symbol Meaning • The wiring position can be exchanged freely within the connector. Extent of the change in the wiring position (1) C B B F A B E C A B D E B B B F D B • The wiring position can be exchanged according to the following combinations only. Between A and B, Between C and D, Between E and F Extent of the change in the wiring position (2) C B B F A B E C A B D E B B B F D B Extent of the change in the wiring position (3) 3 L 5 8 B/Y 2 L 7 B 4 B 1 1 4 B 6 2 B R • The wiring position can be exchanged according to the following combinations only. Between 1, 2, 4 and 7. • The wiring positions may be indicated by numbers for some connectors. 7 ABBREVIATIONS USED IN THIS MANUAL 3GR THIRD GEAR COMBI COMBINATION 4GR FOURTH GEAR CON CONDITIONER A AMPERE CONT CONTROL A/C AIR CONDITIONING CPU CENTRAL PROCESSING UNIT A/F AIR FUEL DEF DEFROSTER AAS AUTO ADJUSTING SUSPENSION DI DISTRIBUTOR IGNITION ABS ANTI-LOCK BRAKING SYSTEM DLC DATA LINK CONNECTOR ACC ACCESSORIES DLI DISTRIBUTORLESS IGNITION ACV AIR CONTROL VALVE DOHC DOUBLE-OVERHEAD CAMSHAFT ADD ADDITIONAL DRL DAYTIME RUNNING LIGHT AIS AIR INJECTION SYSTEM DTC DIAGNOSTIC TROUBLE CODE(S) ALL AUTOMATIC LOAD LEVELING DTM DIAGNOSTIC TEST MODE AM AMPLITUDE MODULATION AMP AMPLIFIER ECPS ELECTRONICALLY CONTROLLED POWER STEERING ANT ANTENNA ECT ENGINE CONTROL TEMPERATURE ASV AIR SUPPLY VALVE EGR EXHAUST GAS RECIRCULATION AT AUTOMATIC TRANSMISSION ATX AUTOMATIC TRANSAXLE EHPAS ELECTRO HYDRAULIC POWER ASSIST STEERING B+ BATTERY POSITIVE VOLTAGE EI ELECTRONIC IGNITION BAC BYPASS AIR CONTROL ELEC ELECTRIC CAN CONTROLLER AREA NETWORK ELR EMERGENCY LOCKING RETRACTOR CIGAR CIGARETTE ET ELECTRONIC THROTTLE CIS CONTINUOUS FUEL INJECTION SYSTEM EPS ELECTRIC POWER STEERING EVAP EVAPORATIVE EMISSION CKP CRANKSHAFT POSITION SENSOR F FRONT CM CONTROL MODULE F/I FUEL INJECTOR CMP CAMSHAFT POSITION SENSOR FICB FAST-IDLE CAM BREAKER 12 Form No. F1A1-10-05L
  16. 16. 00R Reading Wiring Diagrams FM FREQUENCY MODULATION PNP PARK/NEUTRAL POSITION FP FUEL PUMP PRC PRESSURE REGULATOR CONTROL FPR FUEL PUMP RELAY PRG PURGE SOLENOID VALVE GEN GENERATOR PSP POWER STEERING PRESSURE GND GROUND H/D HEATER/DEFROSTER PTC POSITIVE TEMPERATURE COEFFICIENT HEATER HEAT HEATER PWM PULSE WIDTH MODULATION HI HIGH QSS QUICK-START SYSTEM HO2S HEATED OXYGEN SENSOR R REAR HS HIGH SPEED REC RECIRCULATION HU HYDRAULIC UNIT RF RIGHT FRONT IAC IDLE AIR CONTROL RH RIGHT HAND IAT INTAKE AIR TEMPERATURE RPM REVOLUTIONS PER MINUTE IG IGNITION RR RIGHT REAR ILLUMI ILLUMINATION SAS SOPHISTICATED AIR BAG SENSOR INT INTERMITTENT JB JOINT BOX SFI SEQUENTIAL MULTIPOINT FUEL INJECTION KS KNOCK SENSOR SOL SOLENOID LCD LIQUID CRYSTAL DISPLAY SPV SPILL VALVE LF LEFT FRONT ST START LH LEFT HAND SW SWITCH LO LOW TC TURBOCHARGER LR LEFT REAR TCC TORQUE CONVERTER CLUTCH TCM TRANSMISSION(TRANSAXLE) CONTROL MODULE M MOTOR MAF MASS AIR FLOW MAP MANIFOLD ABSOLUTE PRESSURE TCS TRACTION CONTROL SYSTEM MFI MULTIPORT FUEL INJECTION TEMP TEMPERATURE MID MIDDLE TFT TRANSAXLE FLUID TEMPERATURE TICS TRIPLE INDUCTION CONTROL SYSTEM MIL MALFUNCTION INDICATOR LAMP MIN MINUTE MIX MIXTURE TNS TAIL NUMBER SIDE LIGHTS MPX MULTIPLEX TP THROTTLE POSITION SENSOR MS MIDDLE SPEED TR TRANSMISSION(TRANSAXLE) RANGE MT MANUAL TRANSMISSION TWS TOTAL WIRING SYSTEM MTX MANUAL TRANSAXLE V VOLT N NEUTRAL VAF VOLUME AIR FLOW SENSOR NC NORMALLY CLOSED VENT VENTILATION NO NORMALLY OPEN O2S OXYGEN SENSOR VICS VARIABLE INERTIA CHARGING SYSTEM OBD ON-BOARD DIAGNOSTIC VOL VOLUME O/D OVER DRIVE VR VOLTAGE REGULATOR OFF SWITCH OFF ON SWITCH ON VRIS VARIABLE RESONANCE INDUCTION SYSTEM OSC OSCILLATOR VSS VEHICLE SPEED SENSOR P POWER P/S POWER STEERING VTCS VARIABLE TUMBLE CONTROL SYSTEM PCM POWERTRAIN CONTROL MODULE W WATT(S) PJB PASSENGER JUNCTION BOX WOT WIDE OPEN THROTTLE 13 Form No. F1A1-10-05L
  17. 17. 00P Electrical System General Procedures ELECTRICAL PARTS Battery Cable B6U000000006W03 • Before disconnecting connectors or removing electrical parts, disconnect the negative battery cable. NEGATIVE BATTERY CABLE WGIWXX0007E Wiring Harness • To remove the wiring harness from the clip in the engine room, pry up the hook of the clip using a flathead screwdriver. WGIWXX0039E Caution • Do not remove the Harness protective tape. Otherwise, the wires could rub against the body, which could result in water penetration and electrical shorting. NO GOOD CONNECTORS Data Link Connector WGIWXX0040E • Insert the probe into the terminal when connecting a jumper wire to the data link connector. GOOD NO GOOD Caution • Inserting a jumper wire probe into the data link connector terminal may damage the terminal. X3U000WAY Disconnecting Connectors • When disconnecting connector, grasp the connectors, not the wires. NO GOOD WGIWXX0041E 14 Form No. F1A1-10-05L
  18. 18. Electrical System General Procedures 00P • Connectors can be disconnected by pressing or pulling the lock lever as shown. WGIWXX0042E Locking Connector • When locking connectors, listen for a click indicating they are securely locked. X3U000WB1 Inspection • When a tester is used to inspect for continuity or measuring voltage, insert the tester probe from the wiring harness side. NO GOOD WGIWXX0044E • Inspect the terminals of waterproof connectors from the connector side since they cannot be accessed from the wiring harness side. Caution • To prevent damage to the terminal, wrap a thin wire around the tester probe before inserting into terminal. NO GOOD WGIWXX0045E 15 Form No. F1A1-10-05L
  19. 19. 00P Electrical System General Procedures Terminals Inspection • Pull lightly on individual wires to verify that they are secured in the terminal. X3U000WB4 Replacement • Use the appropriate tools to remove a terminal as shown. When installing a terminal, be sure to insert it until it locks securely. • Insert a thin piece of metal from the terminal side of the connector and with the terminal locking tab pressed down, pull the terminal out from the connector. X3U000WB5 Sensors, Switches, And Relays • Handle sensors, switches, and relays carefully. Do not drop them or strike them against other objects. NO GOOD X3U000WB6 Fuse Replacement • When replacing a fuse, be sure to replace it with one of the same capacity. If a fuse fails again, the circuit probably has a short and the wiring should be inspected. • Be sure the negative battery terminal is disconnected before replacing a main fuse. YMU000WA1 16 Form No. F1A1-10-05L
  20. 20. Electrical System General Procedures 00P • When replacing a pullout fuse, use the fuse puller. YMU000WAK ELECTRICAL TROUBLESHOOTING TOOLS Jumper Wire • A jumper wire is used to create a temporary circuit. Connect the jumper wire between the terminals of a circuit to bypass a switch. Caution • Do not connect a jumper wire from the power source line to a body ground. This may cause burning or other damage to wiring harnesses or electronic components. X3U000WBB Voltmeter • The DC voltmeter is used to measure circuit voltage. A voltmeter with a range of 15 V or more is used by connecting the positive (+) probe (red lead wire) to the point where voltage will be measured and the negative (-) probe (black lead wire) to a body ground. X3U000WBC Ohmmeter • The ohmmeter is used to measure the resistance between two points in a circuit and to inspect for continuity and short circuits. POWER SOURCE LINE NO GOOD Caution • Do not connect the ohmmeter to any circuit where voltage is applied. This will damage the ohmmeter. GROUND LINE OHMMETER YMU000WAL 17 Form No. F1A1-10-05L
  21. 21. Form No. F1A1-10-05L ELECTRICAL WIRING SCHEMATIC 00E 18
  22. 22. 00F Form No. F1A1-10-05L FUSE BOX 20
  23. 23. Form No. F1A1-10-05L COMMON CONNECTOR LIST 00C-1 22
  24. 24. Form No. F1A1-10-05L COMMON CONNECTOR LIST 23 00C-2
  25. 25. Form No. F1A1-10-05L COMMON CONNECTOR LIST 00C-3 24
  26. 26. Form No. F1A1-10-05L COMMON CONNECTOR LIST 25 00C-4
  27. 27. 00G-a Form No. F1A1-10-05L GROUND POINT 26
  28. 28. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) 4 [WL-C, WE-C] 5 3 1 6 C-04 WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM (F)-(R) (F)-(FR) 27 2 3 [WL-3] 1 C-04 (F)-(R) (F)-(FR) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 2 00G-a
  29. 29. 00G-b Form No. F1A1-10-05L GROUND POINT 28
  30. 30. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) 9 11 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] (R)-(DR3) 10 C-15 13 9 14 10 C-03 8 (F)-(R) 29 [REGULAR CAB] 14 9 8 10 15 [DOUBLE CAB] C-03 14 (F)-(R) 8 12 00G-b
  31. 31. Form No. F1A1-10-05L DATA LINK CONNECTOR 00D 30
  32. 32. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) (F)-(F2) [WL-C, WE-C] C-09 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 (F)-(F2) C-09 3 [GRAY] DATA LINK CONNECTOR 5 D-02 1 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH D-01 DATA LINK CONNECTOR-2 [BLACK] (F)-(F2) C-09 31 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 2 [WL-3] 3 [GRAY] DATA LINK CONNECTOR D-02 1 2 00D
  33. 33. 0117 Form No. F1A1-10-05L CHARGING SYSTEM 32
  34. 34. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] (F)-(E) C-05 [GRAY] (F)-(E) C-06 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 33 0117-01 GENERATOR [GRAY] 0117-01 GENERATOR 01 ENGINE 17 CHARGING SYSTEM 0117
  35. 35. 0119 Form No. F1A1-10-05L STARTING SYSTEM 34
  36. 36. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] (F)-(E) C-05 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 35 0119-01 STARTER C-01 ENGINE SWITCH 01 ENGINE 19 STARTING SYSTEM 0119
  37. 37. Form No. F1A1-10-05L CONTROL SYSTEM (WL-3) 0140-1a 36
  38. 38. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) [GRAY] FUEL PUMP SPEED SENSOR 0140-109 [BLACK] EGR SOLENOID VALVE (VENT) [BLACK] (F)-(E) C-05 MAIN FUSE BLOCK (REFER TO 00F SECTION) [GRAY] (F)-(E) F-01 C-06 0140-104 3 [BLACK] EGR SOLENOID VALVE (VACUUM) 0140-103 NEUTRAL SWITCH 0140-112 [BROWN] GLOW PLUG RELAY 0140-107 0140-107 GLOW PLUG RELAY 0140-105 37 EGR CONTROL SOLENOID VALVE 4 0140-108 CLUTCH PEDAL POSITION SWITCH GLOW PLUG 5 0140-111 JOINT CONNECTOR C-25 0140-101 PCM C-01 0140-106 ENGINE SWITCH MAIN RELAY F-02 FUSE BLOCK (REFER TO 00F SECTION) 0140-110 IDLE SWITCH 01 ENGINE 40 CONTROL SYSTEM 0140-1a
  39. 39. Form No. F1A1-10-05L CONTROL SYSTEM (WL-3) 0140-1b 38
  40. 40. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) [GRAY] FUEL INJECTION PUMP 0140-113 [BLACK] (F)-(E) C-05 [GRAY] (F)-(E) 3 C-06 0140-117 BOOST SENSOR [BLACK] 0140-116 39 EGR VALVE POSITION SENSOR [GRAY] 0140-115 INTAKE AIR TEMPERATURE SENSOR No.1 [BLACK] 0140-114 ENGINE COOLANT TEMPERATURE SENSOR [GRAY] [BLACK] ACCELERATOR PEDAL POSITION SENSOR 0140-118 JOINT CONNECTOR C-25 0140-101 PCM 01 ENGINE 40 CONTROL SYSTEM 0140-1b
  41. 41. Form No. F1A1-10-05L CONTROL SYSTEM (WL-3) 0140-1c 40
  42. 42. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [GRAY] FUEL INJECTION PUMP 3 0140-119 [GRAY] CKP SENSOR 0140-121 41 0140-120 MASS AIR FLOW SENSOR/ INTAKE AIR TEMPERATURE SENSOR No.2 [BLACK] JOINT CONNECTOR C-25 0140-101 PCM 01 ENGINE 40 CONTROL SYSTEM 0140-1c
  43. 43. Form No. F1A1-10-05L CONTROL SYSTEM (WL-C, WE-C) 0140-2a 42
  44. 44. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) (F)-SHORT CORD 0140-204 F-01 [GRAY] (F)-(E) GLOW PLUG RELAY NEUTRAL SWITCH C-06 0140-207 0140-203 1 43 MAIN RELAY 0140-202 4 5 0140-203 GLOW PLUG RELAY [BROWN] [BLACK] PCM 2 0140-201 0140-205 GLOW PLUG F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 0140-206 CLUTCH PEDAL POSITION SWITCH 01 ENGINE 40 CONTROL SYSTEM 0140-2a
  45. 45. Form No. F1A1-10-05L CONTROL SYSTEM (WL-C, WE-C) 0140-2b 44
  46. 46. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] FUEL INJECTOR No.3 0140-214 [BLACK] FUEL INJECTOR No.4 [GRAY] (F)-(E) 0140-215 C-06 0140-212 FUEL INJECTOR No.1 [BLACK] 0140-213 FUEL INJECTOR No.2 [BLACK] 0140-210 45 INTAKE SHUTTER SOLENOID VALVE (HALF) [BROWN] 0140-211 FUEL METERING VALVE [BLACK] [BLACK] PCM 0140-209 INTAKE SHUTTER SOLENOID VALVE (FULL) [GREEN] 01 ENGINE 40 CONTROL SYSTEM 0140-208 0140-201 MASS AIR FLOW SENSOR/ INTAKE AIR TEMPERATURE SENSOR No.2 [BLACK] 0140-2b
  47. 47. Form No. F1A1-10-05L CONTROL SYSTEM (WL-C, WE-C) 0140-2c 46
  48. 48. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [GRAY] EGR VALVE POSITION SENSOR 0140-217 [BLACK] VARIABLE BOOST CONTROL SOLENOID VALVE 0140-222 47 0140-219 0140-221 VARIABLE SWIRL CONTROL SOLENOID VALVE [BROWN] EGR SOLENOID VALVE [BLACK] 0140-216 FUEL PRESSURE SENSOR [BLACK] 0140-218 [BLACK] PCM 0140-220 0140-201 EGR CONTROL SOLENOID VALVE [GREEN] CAMSHAFT POSITION SENSOR [BLACK] 01 ENGINE 40 CONTROL SYSTEM 0140-2c
  49. 49. Form No. F1A1-10-05L CONTROL SYSTEM (WL-C, WE-C) 0140-2d 48
  50. 50. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] BOOST SENSOR/ INTAKE AIR TEMPERATURE SENSOR No.1 0140-223 [GRAY] (F)-(E) C-06 0922-106 (F)-SHORT CORD [BLACK] 49 0140-227 0922-105 [BLACK] PCM FUEL TEMPERATURE SENSOR ENGINE COOLANT TEMPERATURE SENSOR [GRAY] 0140-228 5 4 0140-201 CRANKSHAFT POSITION SENSOR [BLACK] 0140-224 IDLE SWITCH 01 ENGINE 40 CONTROL SYSTEM 0140-2d
  51. 51. Form No. F1A1-10-05L CONTROL SYSTEM (WL-C, WE-C) 0140-2e 50
  52. 52. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) 4 [BLACK] ACCELERATOR PEDAL POSITION SENSOR 0140-229 [BLACK] PCM 51 0140-201 01 ENGINE 40 CONTROL SYSTEM 0140-2e
  53. 53. Form No. F1A1-10-05L REMOTE FREEWHEEL CONTROL SYSTEM 0318-a 52
  54. 54. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLUE] LOCK SOLENOID VALVE 0318-01 FREE SOLENOID VALVE 0318-02 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 53 4 5 RFW MAIN SWITCH 0318-03 [BLACK] PCM 0140-201 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 03 DRIVELINE/AXLE 18 4-WHEEL DRIVE 0318-a
  55. 55. Form No. F1A1-10-05L REMOTE FREEWHEEL CONTROL SYSTEM 0318-b 54
  56. 56. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) [BROWN] TRANSFER NEUTRAL SWITCH [BLACK] (F)-(E) 0318-05 C-05 [BLACK] 4 4 INDICATOR SWITCH [GRAY] (F)-(E) 0318-04 C-06 1 55 0318-06 RFW LOCK SWITCH [BLACK] [BLACK] PCM 0140-201 2 03 DRIVELINE/AXLE 18 4-WHEEL DRIVE 0318-b
  57. 57. Form No. F1A1-10-05L 4 WHEEL ANTILOCK BRAKE SYSTEM (4WABS) 0413-1 56
  58. 58. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) C-08 (F)-(F2) 0413-104 (R)-(R2) C-09 11 [BLACK] ABS HU/CM [GRAY] ABS WHEEL-SPEED SENSOR LR [STRETCH CAB (WITH REAR ACCESS SYSTEM)] (F)-(F2) C-13 (R)-(F2) 0413-101 C-14 MAIN FUSE BLOCK (REFER TO 00F SECTION) [BLACK] G SENSOR F-01 0413-106 0413-105 ABS WHEEL-SPEED SENSOR RR [GRAY] [GRAY] ABS WHEEL-SPEED SENSOR LR 0413-104 C-14 (R)-(R2) C-13 (R)-(F2) [BLACK] G SENSOR 0413-103 0413-106 57 ABS WHEEL-SPEED SENSOR RF [GRAY] 0413-105 [REGULAR CAB] 0413-102 ABS WHEEL-SPEED SENSOR LF [GRAY] ABS WHEEL-SPEED SENSOR RR [GRAY] [GRAY] ABS WHEEL-SPEED SENSOR LR C-14 0413-104 (R)-(F2) (R)-(R2) C-13 (F)-(F2) C-09 (F)-(F2) C-08 [BLACK] G SENSOR 0413-106 [DOUBLE CAB] 0413-105 ABS WHEEL-SPEED SENSOR RR [GRAY] F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH C-14 (R)-(F2) 04 BRAKES 13 ANTILOCK BRAKE SYSTEM 0413-1
  59. 59. Form No. F1A1-10-05L REAR ANTILOCK BRAKE SYSTEM 0413-2 58
  60. 60. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) 9 [GRAY] ABS SPEED SENSOR ABS HU 0413-203 0413-204 10 MAIN FUSE BLOCK (REFER TO 00F SECTION) (R)-(R2) F-01 C-13 1 0413-202 ABS RELAY 0413-201 8 C-02 ABS CM [GRAY] C-04 (F)-(R) 59 (F)-(R) (F)-(FR) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 2 (F)-(R) C-02 TEST CONNECTOR 0413-205 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH C-04 WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 04 BRAKES 13 ANTILOCK BRAKE SYSTEM (F)-(R) (F)-(FR) 0413-2
  61. 61. Form No. F1A1-10-05L HEATER AND AIR CONDITIONER 0740 60
  62. 62. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) A/C RELAY 0740-07 [GRAY] (F)-(E) [BLACK] (F)-(E) C-05 C-06 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 BLOWER RELAY 61 0740-09 0740-08 0740-02 REFRIGERANT PRESSURE SWITCH [BLACK] MAGNETIC CLUTCH WL-C, WE-C 4 5 A/C SWITCH 0740-11 (F)-BLOWER UNIT 0740-03 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) 0740-05 RESISTOR 0740-10 A/C AMPLIFIER C-01 ENGINE SWITCH WL-3 0740-02 BLOWER RELAY 0740-04 0740-06 BLOWER MOTOR RESISTOR 0740-01 CLIMATE CONTROL UNIT 07 HEATER, VENTILATION & AIR CONDITIONING (HVAC) 40 CONTROL SYSTEM 0740
  63. 63. 62 Form No. F1A1-10-05L AIR BAG SYSTEM SERVICE CAUTIONS / SERVICE WARNINGS 0810
  64. 64. 63 Form No. F1A1-10-05L AIR BAG SYSTEM SERVICE CAUTIONS / SERVICE WARNINGS 0810
  65. 65. Form No. F1A1-10-05L AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION) 0810-1a 64
  66. 66. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 65 SHORT CONNECTOR 0810-102 [YELLOW] DRIVER-SIDE AIR BAG MODULE 0810-105 [YELLOW] PASSENGER-SIDE AIR BAG MODULE 0810-104 0810-103 (F)-CLOCK SPRING [YELLOW] 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) 0810-101 SAS CONTROL MODULE [YELLOW] 08 RESTRAINTS 10 AIR BAG SYSTEM C-01 ENGINE SWITCH 0810-1a
  67. 67. Form No. F1A1-10-05L AIR BAG SYSTEM (INCLUDES PRE-TENSIONER SEAT BELT INFORMATION) 0810-1b 66
  68. 68. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) [STRETCH CAB (WITH REAR ACCESS SYSTEM)] [YELLOW] DRIVER-SIDE PRE-TENSIONER SEAT BELT 0810-106 [YELLOW] DRIVER-SIDE PRE-TENSIONER SEAT BELT 0810-106 [BLACK] DRIVER-SIDE SIDE AIR BAG SENSOR [YELLOW] (R)-(DR3) 0810-110 C-16 [BLACK] DRIVER-SIDE SIDE AIR BAG SENSOR 0810-110 [DOUBLE CAB] C-18 0810-107 0810-107 (R)-(DR4) [YELLOW] PASSENGER-SIDE PRE-TENSIONER SEAT BELT [YELLOW] PASSENGER-SIDE PRE-TENSIONER SEAT BELT [YELLOW] 0810-111 PASSENGER-SIDE SIDE AIR BAG SENSOR [BLACK] 0810-111 PASSENGER-SIDE SIDE AIR BAG SENSOR [BLACK] 0810-101 67 SAS CONTROL MODULE [YELLOW] 0810-109 DRIVER-SIDE SIDE AIR BAG MODULE [YELLOW] PASSENGER-SIDE SIDE AIR BAG MODULE [YELLOW] 0810-108 0810-108 DRIVER-SIDE SIDE AIR BAG MODULE [YELLOW] 0810-101 SAS CONTROL MODULE 0810-109 [YELLOW] PASSENGER-SIDE SIDE AIR BAG MODULE [YELLOW] [YELLOW] DRIVER-SIDE PRE-TENSIONER SEAT BELT 0810-106 [REGULAR CAB] 0810-107 PASSENGER-SIDE PRE-TENSIONER SEAT BELT [YELLOW] 0810-101 SAS CONTROL MODULE [YELLOW] 08 RESTRAINTS 10 AIR BAG SYSTEM 0810-1b
  69. 69. Form No. F1A1-10-05L REAR WINDOW DEFROSTER 0912-1 68
  70. 70. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] FILAMENT 0912-103 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 0912-103 FILAMENT [BLACK] [BLACK] FILAMENT 0912-103 14 C-02 (F)-(R) [REGULAR CAB] 0912-103 69 FILAMENT [BLACK] 14 REAR WINDOW DEFROSTER RELAY 0912-101 C-02 (F)-(R) WL-3 [BLACK] FILAMENT 0912-103 REAR WINDOW DEFROSTER SWITCH 0912-102 5 (F)-(R) C-02 0912-103 [DOUBLE CAB] 6 0912-101 FILAMENT [BLACK] 14 WL-C, WE-C REAR WINDOW DEFROSTER RELAY F-02 FUSE BLOCK (REFER TO 00F SECTION) C-02 (F)-(R) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 12 GLASS/WINDOWS/MIRRORS 0912-1
  71. 71. Form No. F1A1-10-05L POWER WINDOW SYSTEM 0912-2a 70
  72. 72. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 POWER WINDOW MAIN SWITCH 0912-201 [BLUE] FRONT POWER WINDOW REGULATOR RH 0912-205 (F)-(DR1) C-11 C-02 0912-202 (F)-(R) POWER WINDOW SUBSWITCH LF 0912-206 FRONT POWER WINDOW REGULATOR LH 71 C-12 (F)-(DR2) 4 (F)-(DR1) C-11 5 (F)-(R) C-02 (F)-(DR2) C-12 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 12 GLASS/WINDOWS/MIRRORS 0912-2a
  73. 73. Form No. F1A1-10-05L POWER WINDOW SYSTEM 0912-2b 72
  74. 74. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) (F)-(DR1) C-11 C-02 (F)-(R) POWER WINDOW SUBSWITCH RR 0912-203 73 0912-207 C-04 WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM REAR POWER WINDOW REGULATOR RH (F)-(R) (F)-(FR) (R)-(DR3) POWER WINDOW MAIN SWITCH 0912-201 C-20 (R)-(DR3) C-19 (F)-(DR1) C-11 0912-208 REAR POWER WINDOW REGULATOR LH 0912-204 POWER WINDOW SUBSWITCH LR C-23 C-02 (F)-(R) (R)-(DR4) WITH AIR BAG SYSTEM (FR)-(DR4) WITHOUT AIR BAG SYSTEM C-04 (F)-(R) (F)-(FR) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM C-22 (R)-(DR4) WITH AIR BAG SYSTEM (FR)-(DR4) WITHOUT AIR BAG SYSTEM 09 BODY & ACCESSORIES 12 GLASS/WINDOWS/MIRRORS 0912-2b
  75. 75. Form No. F1A1-10-05L POWER OUTER MIRROR 0912-3 74
  76. 76. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) POWER OUTER MIRROR SWITCH F-01 0912-301 POWER OUTER MIRROR RH/ RETRACT/RETURN MOTOR RH 0912-303 (F)-(DR1) (F)-(DR1) C-11 C-10 0912-302 C-12 POWER OUTER MIRROR LH/ RETRACT/RETURN MOTOR LH (F)-(DR2) 75 (F)-(DR1) C-10 4 5 (F)-(DR1) C-11 (F)-(DR2) C-12 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 12 GLASS/WINDOWS/MIRRORS 0912-3
  77. 77. Form No. F1A1-10-05L POWER DOOR LOCK SYSTEM 0914-1a 76
  78. 78. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 DOOR LOCK-LINK SWITCH 0914-102 (F)-(DR1) (F)-(DR1) C-10 C-11 77 DOOR LOCK CONTROL MODULE WL-3 0914-101 (F)-(DR1) C-10 5 (F)-(DR1) 4 C-11 0914-101 WL-C, WE-C DOOR LOCK CONTROL MODULE F-02 FUSE BLOCK (REFER TO 00F SECTION) 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS 0914-1a
  79. 79. Form No. F1A1-10-05L POWER DOOR LOCK SYSTEM 0914-1b 78
  80. 80. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) DOOR LOCK CONTROL MODULE WL-3 0914-101 (F)-(DR1) C-10 0914-101 WL-C, WE-C DOOR LOCK CONTROL MODULE (F)-(DR2) C-12 C-02 (F)-(R) 79 [GRAY] DOOR LOCK ACTUATOR RR 0914-105 (R)-(DR3) C-04 WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM C-20 (F)-(R) (F)-(FR) DOOR LOCK ACTUATOR RF 0914-103 (F)-(DR1) C-10 0914-106 C-23 DOOR LOCK ACTUATOR LR [GRAY] (R)-(DR4) WITH AIR BAG SYSTEM (FR)-(DR4) WITHOUT AIR BAG SYSTEM C-02 (F)-(R) 0914-104 DOOR LOCK ACTUATOR LF C-12 (F)-(DR2) C-04 (F)-(R) (F)-(FR) 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 0914-1b
  81. 81. Form No. F1A1-10-05L KEYLESS CONTROL MODULE 0914-2 80
  82. 82. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 81 5 6 F-02 0914-201 KEYLESS CONTROL MODULE FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS 0914-2
  83. 83. Form No. F1A1-10-05L IMMOBILIZER SYSTEM 0914-3 82
  84. 84. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [WL-C, WE-C] COIL 0914-302 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 IMMOBILIZER UNIT 3 0914-301 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 83 [WL-3] MAIN FUSE BLOCK (REFER TO 00F SECTION) 3 F-01 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS 0914-3
  85. 85. Form No. F1A1-10-05L THEFT-DETERRENT SYSTEM 0914-4a 84
  86. 86. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 [BLACK] BONNET SWITCH DOOR KEY CYLINDER SWITCH RF 0914-102 0914-403 (F)-(DR1) C-11 0914-402 DOOR KEY CYLINDER SWITCH LF C-12 (F)-(DR2) 85 4 (F)-(DR1) C-11 5 THEFT-DETERRENT CONTROL MODULE 0914-401 (F)-(DR2) C-12 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS 0914-4a
  87. 87. Form No. F1A1-10-05L THEFT-DETERRENT SYSTEM 0914-4b 86
  88. 88. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [GRAY] DOOR LOCK-LINK SWITCH RR MAIN FUSE BLOCK (REFER TO 00F SECTION) 0914-405 F-01 (R)-(DR3) C-21 0914-404 DOOR LOCK-LINK SWITCH LR [GRAY] C-02 C-24 (F)-(R) 0914-406 THEFT-DETERRENT HORN RELAY WITH AIR BAG SYSTEM (R)-(DR4) (FR)-(DR4) WITHOUT AIR BAG SYSTEM C-03 8 (F)-(R) 12 C-04 87 0914-407 (F)-(R) (F)-(FR) THEFT-DETERRENT HORN WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 4 5 THEFT-DETERRENT CONTROL MODULE 0914-401 C-02 C-03 (F)-(R) (F)-(R) F-02 FUSE BLOCK (REFER TO 00F SECTION) C-04 WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS (F)-(R) (F)-(FR) 0914-4b
  89. 89. 0918-1 Form No. F1A1-10-05L HEADLIGHT 88
  90. 90. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 [BLACK] HEADLIGHT RH 0918-105 HEADLIGHT RELAY 89 0918-102 WL-3 5 0918-104 HEADLIGHT LH [BLACK] 0918-101 HEADLIGHT SWITCH [GRAY] 6 0918-103 WL-C, WE-C TNS RELAY F-02 0918-102 WL-C, WE-C FUSE BLOCK HEADLIGHT RELAY (REFER TO 00F SECTION) WL-3 0918-103 TNS RELAY 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-1
  91. 91. Form No. F1A1-10-05L LICENSE PLATE LIGHT / PARKING LIGHT / TAILLIGHT 0918-2 90
  92. 92. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] TAILLIGHT RH 9 0918-204 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] [BLACK] TAILLIGHT LH 0918-203 (R)-(R2) C-13 0918-205 1 [GRAY] PARKING LIGHT RH LICENSE PLATE LIGHT [GRAY] 0918-202 10 [BLACK] TAILLIGHT RH 0918-204 [GRAY] LICENSE PLATE LIGHT 0918-205 9 10 [BLACK] TAILLIGHT LH 0918-203 (R)-(R2) C-13 C-03 (F)-(R) [BLACK] TAILLIGHT RH 91 0918-204 [REGULAR CAB] 2 [GRAY] LICENSE PLATE LIGHT 0918-201 PARKING LIGHT LH [GRAY] 9 0918-205 (R)-(R2) C-13 10 C-03 (F)-(R) [DOUBLE CAB] C-03 (F)-(R) 0918-203 C-03 TAILLIGHT LH [BLACK] (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-2
  93. 93. 0918-3 Form No. F1A1-10-05L FRONT FOG LIGHT 92
  94. 94. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 1 0918-303 FRONT FOG LIGHT RH [BLACK] 93 FRONT FOG LIGHT RELAY 0918-301 2 WL-3 0918-302 FRONT FOG LIGHT LH [BLACK] 5 0918-301 WL-C, WE-C FRONT FOG LIGHT RELAY 6 0918-101 FRONT FOG LIGHT SWITCH [GRAY] F-02 FUSE BLOCK (REFER TO 00F SECTION) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-3
  95. 95. Form No. F1A1-10-05L TURN AND HAZARD WARNING LIGHT 0918-4 94
  96. 96. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) [GRAY] FRONT SIDE TURN LIGHT RH [STRETCH CAB (WITH REAR ACCESS SYSTEM)] [BLACK] REAR TURN LIGHT RH 9 0918-204 0918-405 [BLACK] REAR TURN LIGHT LH MAIN FUSE BLOCK (REFER TO 00F SECTION) (R)-(R2) F-01 0918-203 C-13 [GRAY] FRONT SIDE TURN LIGHT LH 1 0918-406 FRONT TURN LIGHT RH 0918-403 10 [BLACK] REAR TURN LIGHT RH 0918-204 9 10 [BLACK] REAR TURN LIGHT LH 0918-203 (R)-(R2) C-13 C-03 (F)-(R) 95 [REGULAR CAB] 2 [BLACK] REAR TURN LIGHT RH 0918-404 FRONT TURN LIGHT LH 0918-204 FLASHER CONTROL MODULE WL-3 9 0918-401 C-03 [BLACK] REAR TURN LIGHT LH 0918-203 (F)-(R) (R)-(R2) FLASHER CONTROL MODULE WL-C, WE-C 10 C-13 0918-401 4 5 HAZARD WARNING SWITCH 0918-402 [DOUBLE CAB] 0918-101 TURN SWITCH [GRAY] 6 C-03 F-02 (F)-(R) FUSE BLOCK (REFER TO 00F SECTION) C-01 C-03 (F)-(R) ENGINE SWITCH 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-4
  97. 97. 0918-5 Form No. F1A1-10-05L BACK-UP LIGHT 96
  98. 98. Form No. F1A1-10-05L HARNESS SYMBOL: [WL-C, WE-C] (F) (E) (R) [BLACK] BACK-UP LIGHT RH [BLACK] (F)-(E) C-05 MAIN FUSE BLOCK (REFER TO 00F SECTION) [BLACK] BACK-UP LIGHT SWITCH 0918-501 0918-204 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 9 10 F-01 [BLACK] BACK-UP LIGHT LH 0918-203 (R)-(R2) C-13 [BLACK] BACK-UP LIGHT RH 9 0918-204 10 [BLACK] BACK-UP LIGHT LH 0918-203 (R)-(R2) C-13 C-03 (F)-(R) 97 [REGULAR CAB] [BLACK] (F)-(E) [BLACK] BACK-UP LIGHT RH C-03 C-05 0918-204 (F)-(R) 9 [WL-3] MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 10 (R)-(R2) C-13 C-03 C-01 ENGINE SWITCH (F)-(R) F-02 FUSE BLOCK (REFER TO 00F SECTION) 0918-501 BACK-UP LIGHT SWITCH [DOUBLE CAB] 0918-203 C-03 BACK-UP LIGHT LH [BLACK] (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-5
  99. 99. Form No. F1A1-10-05L BRAKE LIGHT / HIGH-MOUNT BRAKE LIGHT 0918-6 98
  100. 100. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BLACK] BRAKE LIGHT RH [STRETCH CAB (WITH REAR ACCESS SYSTEM)] MAIN FUSE BLOCK (REFER TO 00F SECTION) 0918-204 HIGH-MOUNT BRAKE LIGHT F-01 0918-602 10 9 [BLACK] BRAKE LIGHT LH 0918-203 (R)-(DR3) C-15 (R)-(R2) C-13 13 [BLACK] BRAKE LIGHT RH 0918-204 9 [BLACK] BRAKE LIGHT LH 10 0918-203 (R)-(R2) C-13 C-03 (F)-(R) 99 [REGULAR CAB] [BLACK] BRAKE LIGHT RH 0918-204 HIGH-MOUNT BRAKE LIGHT 0918-602 9 [BLACK] BRAKE LIGHT LH BRAKE SWITCH 0918-601 4 C-03 10 (F)-(R) 0918-203 5 (R)-(R2) C-13 [DOUBLE CAB] C-03 (F)-(R) F-02 FUSE BLOCK (REFER TO 00F SECTION) C-03 (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-6
  101. 101. Form No. F1A1-10-05L ILLUMINATION LIGHT 0918-7 100
  102. 102. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) REAR WINDOW DEFROSTER SWITCH ILLUMINATION 0912-102 HAZARD WARNING SWITCH ILLUMINATION 0918-402 INSTRUMENT CLUSTER ILLUMINATION 0922-101 AUDIO UNIT ILLUMINATION 0920-201 4 5 RFW MAIN SWITCH ILLUMINATION A/C SWITCH ILLUMINATION 0318-03 0740-11 (F)-SHORT CORD 101 C-26 6 0918-701 HEATER CONTROL ILLUMINATION 0918-703 GLOVE COMPARTMENT LIGHT [BLACK] 0918-702 CONSOLE ILLUMINATION [BLACK] 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-7
  103. 103. 0918-8 Form No. F1A1-10-05L INTERIOR LIGHT 102
  104. 104. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) [STRETCH CAB (WITH REAR ACCESS SYSTEM)] (R)-(DR3) C-15 INTERIOR LIGHT 0918-801 MAIN FUSE BLOCK (REFER TO 00F SECTION) [BLACK] DOOR SWITCH RF F-01 0918-802 C-17 (R)-(DR4) (FR)-(DR4) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 0918-803 DOOR SWITCH LF [BLACK] C-04 C-03 (F)-(R) (F)-(FR) (F)-(R) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM C-07 (F)-(IN) INTERIOR LIGHT 0918-801 103 [BLACK] DOOR SWITCH RF INTERIOR LIGHT 0918-802 0918-801 [BLACK] DOOR SWITCH RR [BLACK] DOOR SWITCH RF [REGULAR CAB] 0918-804 0918-802 [BLACK] DOOR SWITCH LR 0918-805 0918-803 (F)-(IN) DOOR SWITCH LF [BLACK] C-07 C-03 (F)-(R) C-03 F-02 (F)-(R) [DOUBLE CAB] C-07 (F)-(IN) FUSE BLOCK (REFER TO 00F SECTION) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM C-04 (F)-(R) (F)-(FR) 0918-806 (R)-SHORT CORD WITH AIR BAG SYSTEM (FR)-SHORT CORD WITHOUT AIR BAG SYSTEM C-03 (F)-(R) 0918-803 C-04 (F)-(R) (F)-(FR) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS C-07 (F)-(IN) C-04 (F)-(R) (F)-(FR) DOOR SWITCH LF [BLACK] WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 0918-8
  105. 105. Form No. F1A1-10-05L WINDSHIELD WIPER AND WASHER 0919 104
  106. 106. Form No. F1A1-10-05L (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 WINDSHIELD WIPER MOTOR 0919-02 1 105 0919-03 WINDSHIELD WASHER MOTOR 2 5 0919-01 WINDSHIELD WIPER AND WASHER SWITCH [BLACK] 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 19 WIPER/WASHER SYSTEM 0919
  107. 107. Form No. F1A1-10-05L ACCESSORY SOCKET / CIGARETTE LIGHTER 0920-1 106
  108. 108. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 107 5 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) 0920-101 CIGARETTE LIGHTER [BLACK] C-01 ENGINE SWITCH 0920-102 ACCESSORY SOCKET [BLACK] 09 BODY & ACCESSORIES 20 ENTERTAINMENT 0920-1
  109. 109. 0920-2a Form No. F1A1-10-05L AUDIO SYSTEM 108
  110. 110. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 [BLACK] TWEETER RH 0920-207 (F)-(DR1) FRONT SPEAKER RH C-11 0920-206 0920-204 TWEETER LH [BLACK] 0920-205 FRONT SPEAKER LH C-12 109 (F)-(DR2) AUDIO UNIT 0920-201 (F)-SHORT CORD C-26 [BLACK] AUDIO UNIT 0920-201 (F)-(DR1) C-11 15 (F)-(DR2) C-12 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 20 ENTERTAINMENT 0920-2a
  111. 111. 0920-2b Form No. F1A1-10-05L AUDIO SYSTEM 110
  112. 112. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) REAR SPEAKER RH 0920-203 AUDIO UNIT 0920-201 (R)-(DR3) C-19 (F)-SHORT CORD C-26 [DOUBLE CAB] C-03 0920-202 (F)-(R) REAR SPEAKER LH C-22 (R)-(DR4) WITH AIR BAG SYSTEM (FR)-(DR4) WITHOUT AIR BAG SYSTEM C-04 C-04 WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM C-03 (F)-(R) (F)-(FR) (F)-(R) (F)-(R) (F)-(FR) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 111 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] (R)-(DR3) C-15 REAR SPEAKER RH 0920-203 C-17 (R)-(DR4) (FR)-(DR4) WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 0920-202 REAR SPEAKER LH C-03 (F)-(R) C-04 (F)-(R) (F)-(FR) 09 BODY & ACCESSORIES 20 ENTERTAINMENT WITH AIR BAG SYSTEM WITHOUT AIR BAG SYSTEM 0920-2b
  113. 113. Form No. F1A1-10-05L INSTRUMENT CLUSTER 0922-1a 112
  114. 114. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [BROWN] VEHICLE SPEEDOMETER SENSOR [WL-C, WE-C] MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 0922-104 4 2 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 0922-104 [GRAY] (F)-(E) FUEL GAUGE SENDER UNIT 0922-107 [GRAY] VEHICLE SPEEDOMETER SENSOR 4 (R)-(R2) 4 C-13 3 C-06 [BLACK] IGNITION KEY ILLUMINATION 0922-103 FUEL GAUGE SENDER UNIT 0922-107 INSTRUMENT CLUSTER 0922-101 (R)-(R2) C-13 KEY REMINDER SWITCH 0922-106 0922-102 (F)-SHORT CORD [BLACK] C-03 (F)-(R) 0922-105 WATER TEMPERATURE SENDER UNIT [GRAY] [REGULAR CAB] 113 FUEL GAUGE SENDER UNIT C-03 0922-107 (F)-(R) [WL-3] F-02 [BLACK] (F)-(E) FUSE BLOCK (REFER TO 00F SECTION) C-05 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 C-03 (F)-(R) (R)-(R2) C-13 C-01 ENGINE SWITCH 3 [GRAY] VEHICLE SPEEDOMETER SENSOR 0922-104 [DOUBLE CAB] C-03 (F)-(R) 0922-105 WATER TEMPERATURE SENDER UNIT 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 0922-1a
  115. 115. Form No. F1A1-10-05L INSTRUMENT CLUSTER 0922-1b 114
  116. 116. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) BRAKE FLUID LEVEL SENSOR 0922-110 115 INSTRUMENT CLUSTER 0922-101 (F)-SHORT CORD 0922-108 4 5 PARKING BRAKE SWITCH 0922-109 6 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 0922-1b
  117. 117. Form No. F1A1-10-05L INSTRUMENT CLUSTER 0922-1c 116
  118. 118. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) [GRAY] SEDIMENTOR SWITCH 0922-112 [BLACK] (F)-(E) C-05 [GRAY] (F)-(E) C-06 117 INSTRUMENT CLUSTER 0922-101 4 5 0922-111 OIL PRESSURE SWITCH 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 0922-1c
  119. 119. 0922-2 Form No. F1A1-10-05L HORN 118
  120. 120. Form No. F1A1-10-05L HARNESS SYMBOL: (F) (E) (R) HORN RELAY MAIN FUSE BLOCK (REFER TO 00F SECTION) 0922-201 F-01 0922-203 HORN RH 119 [BLACK] HORN SWITCH 0922-202 0919-01 HORN LH SHORT CONNECTOR 0810-102 0922-204 HORN SWITCH F-02 FUSE BLOCK (REFER TO 00F SECTION) 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 0922-2
  121. 121. ALPHABETICAL INDEX 4 F 4X4 INDICATOR SWITCH ..................................... 54 FILAMENT...............................................................68 FLASHER CONTROL MODULE .............................94 FOG LIGHT .............................................................92 FOG LIGHT RELAY ................................................92 FOG LIGHT SWITCH ..............................................92 FREE SOLENOID VALVE.......................................52 FRONT FOG LIGHT................................................92 FRONT FOG LIGHT RELAY ...................................92 FRONT FOG LIGHT SWITCH.................................92 FRONT POWER WINDOW REGULATOR .............70 FRONT SIDE TURN LIGHT ....................................94 FRONT SPEAKER ................................................108 FRONT TURN LIGHT..............................................94 FUEL GAUGE SENDER UNIT ..............................112 FUEL INJECTION PUMP ..................................38, 40 FUEL INJECTOR ....................................................44 FUEL METERING VALVE.......................................44 FUEL PRESSURE SENSOR ..................................46 FUEL PUMP SPEED SENSOR...............................36 FUEL TEMPERATURE SENSOR ...........................48 FUSE BOX ..............................................................20 A A/C AMPLIFIER...................................................... 60 A/C RELAY ............................................................. 60 A/C SWITCH........................................................... 60 ABBREVIATION ..................................................... 12 ABS CM .................................................................. 58 ABS HU .................................................................. 58 ABS HU/CM ........................................................... 56 ABS RELAY............................................................ 58 ABS SPEED SENSOR ........................................... 58 ABS WHEEL-SPEED SENSOR ............................. 56 ACCELERATOR PEDAL POSITION SENSOR ..................................... 38, 50 ACCESSORY SOCKET ....................................... 106 AIR BAG MODULE................................................. 64 AUDIO UNIT ......................................................... 108 B BACK-UP LIGHT .................................................... 96 BACK-UP LIGHT SWITCH ..................................... 96 BLOWER MOTOR.................................................. 60 BLOWER RELAY ................................................... 60 BLOWER UNIT....................................................... 60 BONNET SWITCH.................................................. 84 BOOST SENSOR ............................................. 38, 48 BRAKE FLUID LEVEL SENSOR.......................... 114 BRAKE LIGHT ........................................................ 98 BRAKE SWITCH .................................................... 98 C G G SENSOR..............................................................56 GENERAL INFORMATION .......................................2 GENERATOR..........................................................32 GLOVE COMPARTMENT LIGHT .........................100 GLOW PLUG.....................................................36, 42 GLOW PLUG RELAY ........................................36, 42 GROUND POINT.....................................................26 H CAMSHAFT POSITION SENSOR.......................... 46 CIGARETTE LIGHTER......................................... 106 CKP SENSOR ........................................................ 40 CLIMATE CONTROL UNIT .................................... 60 CLOCK SPRING..................................................... 64 CLUTCH PEDAL POSITION SWITCH ............. 36, 42 COIL ....................................................................... 82 COMMON CONNECTOR LIST .............................. 22 CRANKSHAFT POSITION SENSOR ..................... 48 HAZARD WARNING SWITCH ................................94 HEADLIGHT ............................................................88 HEADLIGHT RELAY ...............................................88 HEADLIGHT SWITCH.............................................88 HIGH-MOUNT BRAKE LIGHT ................................98 HORN ....................................................................118 HORN RELAY .......................................................118 HORN SWITCH.....................................................118 I D IDLE SWITCH ...................................................36, 48 ILLUMINATION A/C SWITCH ......................................................100 AUDIO UNIT.......................................................100 CONSOLE ..........................................................100 HAZARD WARNING SWITCH ...........................100 HEATER CONTROL ..........................................100 IGNITION KEY ...................................................112 INSTRUMENT CLUSTER ..................................100 REAR WINDOW DEFROSTER SWITCH ..........100 RFW MAIN SWITCH ..........................................100 IMMOBILIZER UNIT................................................82 INSTRUMENT CLUSTER .....................................112 INTAKE AIR TEMPERATURE SENSOR ............................................38, 40, 44, 48 INTAKE SHUTTER SOLENOID VALVE .................44 INTERIOR LIGHT..................................................102 DATA LINK CONNECTOR ..................................... 30 DATA LINK CONNECTOR-2.................................. 30 DOOR KEY CYLINDER SWITCH .......................... 84 DOOR LOCK ACTUATOR ..................................... 78 DOOR LOCK CONTROL MODULE ....................... 76 DOOR LOCK-LINK SWITCH............................ 76, 86 DOOR SWITCH.................................................... 102 DRIVER-SIDE AIR BAG MODULE......................... 64 DRIVER-SIDE PRE-TENSIONER SEAT BELT...... 66 DRIVER-SIDE SIDE AIR BAG MODULE ............... 66 DRIVER-SIDE SIDE AIR BAG SENSOR ............... 66 E EGR CONTROL SOLENOID VALVE ............... 36, 46 EGR SOLENOID VALVE.................................. 36, 46 EGR VALVE POSITION SENSOR ................... 38, 46 ELECTRICAL WIRING SCHEMATIC ..................... 18 ENGINE COOLANT TEMPERATURE SENSOR ........................... 38, 48 120 Form No.F1A1-10-05L K KEY REMINDER SWITCH ....................................112 KEYLESS CONTROL MODULE .............................80
  122. 122. ALPHABETICAL INDEX L TRANSFER NEUTRAL SWITCH............................ 54 TURN LIGHT .......................................................... 94 TURN SWITCH....................................................... 94 TWEETER ............................................................ 108 LICENSE PLATE LIGHT......................................... 90 LOCK SOLENOID VALVE ...................................... 52 M MAGNETIC CLUTCH ............................................. 60 MAIN RELAY .................................................... 36, 42 MASS AIR FLOW SENSOR ............................. 40, 44 V VARIABLE BOOST CONTROL SOLENOID VALVE.............................................. 46 VARIABLE SWIRL CONTROL SOLENOID VALVE.............................................. 46 VEHICLE IDENTIFICATION NUMBERS (VIN)......... 3 VEHICLE SPEEDOMETER SENSOR.................. 112 N NEUTRAL SWITCH .......................................... 36, 42 O OIL PRESSURE SWITCH .................................... 116 W WATER TEMPERATURE SENDER UNIT................................................... 112 WINDOW DEFROSTER RELAY ............................ 68 WINDOW DEFROSTER SWITCH.......................... 68 WINDSHIELD WASHER MOTOR ........................ 104 WINDSHIELD WIPER AND WASHER SWITCH ............................................ 104 WINDSHIELD WIPER MOTOR ............................ 104 WIRING COLOR CODE ........................................... 9 P PARKING BRAKE SWITCH ................................. 114 PARKING LIGHT .................................................... 90 PASSENGER-SIDE AIR BAG MODULE ................ 64 PASSENGER-SIDE PRE-TENSIONER SEAT BELT.......................................................... 66 PASSENGER-SIDE SIDE AIR BAG MODULE....... 66 PASSENGER-SIDE SIDE AIR BAG SENSOR ....... 66 PCM ............................................................ 36, 42, 52 POWER OUTER MIRROR ..................................... 74 POWER OUTER MIRROR SWITCH ...................... 74 POWER WINDOW MAIN SWITCH ........................ 70 POWER WINDOW REGULATOR (FRONT) .............................................................. 70 (REAR)................................................................. 72 POWER WINDOW SUBSWITCH ........................... 70 PRE-TENSIONER SEAT BELT .............................. 66 R REAR POWER WINDOW REGULATOR ............... 72 REAR SPEAKER .................................................. 110 REAR TURN LIGHT ............................................... 94 REAR WINDOW DEFROSTER RELAY ................. 68 REAR WINDOW DEFROSTER SWITCH ............... 68 REFRIGERANT PRESSURE SWITCH .................. 60 RESISTOR.............................................................. 60 RETRACT/RETURN MOTOR................................. 74 RFW LOCK SWITCH .............................................. 54 RFW MAIN SWITCH............................................... 52 S SAS CONTROL MODULE ...................................... 64 SEDIMENTOR SWITCH ....................................... 116 SIDE AIR BAG MODULE........................................ 66 SIDE AIR BAG SENSOR ........................................ 66 SIDE TURN LIGHT ................................................. 94 SPEAKER (FRONT) ............................................................ 108 (REAR)............................................................... 110 STARTER ............................................................... 34 T TAILLIGHT.............................................................. 90 TEST CONNECTOR............................................... 58 THEFT-DETERRENT CONTROL MODULE .......... 84 THEFT-DETERRENT HORN.................................. 86 THEFT-DETERRENT HORN RELAY ..................... 86 THERMISTOR ........................................................ 60 TNS RELAY ............................................................ 88 121 Form No.F1A1-10-05L
  123. 123. CONTENTS SECTION TITLE FOREWORD This wiring diagram incorporates the wiring schematics of the RANGER and available optional equipment. Actual vehicle wiring may vary slightly depending on optional equipment or local specifications, or both. NEW GI RANGER Wiring Diagrams Supplement PREVIOUS (GENERAL INFORMATION) W (ELECTRICAL WIRING SCHEMATIC) FB (FUSE BLOCK) JB GENERAL INFORMATION (JOINT BOX) 00 X (COMMON CONNECTOR) Y (GROUND POINT) U (DATA LINK CONNECTOR) A (CHARGING SYSTEM/ STARTING SYSTEM) B ENGINE 01 (ENGINE CONTROL SYSTEM) Q (CRUISE CONTROL SYSTEM) All the contents of this manual, including drawings and specifications, are the latest available at the time of printing. As modifications affecting repair or maintenance occur, relevant information supplementary to this volume will be made available at Ford dealers. This manual should be kept up-to-date. SUSPENSION — DRIVELINE/AXLE — BRAKES TRANSMISSION/ TRANSAXLE STEERING HEATER, VENTILATION & AIR CONDITIONING (HVAC) RESTRAINTS Ford Motor Company reserves the right to alter the specifications and contents of this manual without obligation or advance notice. All rights reserved. No part of this book may be reproduced or used in any form or by any means, electronic or mechanical-including photocopying and recording and the use of any kind of information storage and retrieval system-without permission in writing. BODY & ACCESSORIES SYSTEM CIRCUIT DIAGRAM/CONNECTOR LOCATIONS For proper repair and maintenance, a thorough familiarization with this manual is important, and it should always be kept in a handy place for quick and easy reference. O (ANTI-LOCK BRAKE SYSTEM) H (EC-AT CONTROL SYSTEM) N 02 03 04 05 (ELECTRIC POWER STEERING SYSTEM) 06 G 07 (AIR CONDITIONING SYSTEM) S (SEAT BELT/AIR BAG SYSTEM) 08 C (GAUGE CONTROL SYSTEM) D (WIPER SYSTEM) E (EXTERIOR LIGHTING SYSTEM) F (SIGNAL SYSTEM) I (INTERIOR LIGHTING SYSTEM) J (AUDIO SYSTEM) 09 K (DOOR/WINDOW SYSTEM) L (MIRROR SYSTEM) M (SUNROOF SYSTEM) P (POWER SEAT SYSTEM) T Ford Motor Company (SECURITY AND LOCKS SYSTEM/OPTION) ALPHABETICAL INDEX APPLICATION: This manual is applicable to vehicles beginning with the Vehicle Identification Numbers (VIN) shown on the following page. AI (ALPHABETICAL INDEX) AI © 2006 Ford Motor Company PRINTED IN GERMANY, APR. 2006 F1A4-20-06D Form No. F1A4-20-06D
  124. 124. VEHICLE IDENTIFICATION NUMBERS (VIN) (CHASSIS NUMBERS) WF0 LM1D10*W WF0 LM1E10*W WF0 LMAD10*W WF0 LMAE10*W WF0 LMED10*W WF0 LMEE10*W WF0 UM1D10*W WF0 UM1E10*W WF0 UMAD10*W WF0 UMAE10*W WF0 UMED10*W WF0 UMEE10*W Form No. F1A4-20-06D
  125. 125. SYSTEM INDEX 00 GENERAL INFORMATION R READING WIRING DIAGRAMS VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2 VEHICLE IDENTIFICATION NUMBERS (VIN)................3 E F C G 09 BODY & ACCESSORIES 13 SEATS SEAT WARMER ........................................................... 16 14 SECURITY AND LOCKS KEYLESS CONTROL MODULE................................... 18 IMMOBILIZER SYSTEM............................................... 20 18 LIGHTING SYSTEMS HEADLIGHT ................................................................. 22 LICENSE PLATE LIGHT ............................................... 24 PARKING LIGHT........................................................... 24 TAILLIGHT .................................................................... 24 FRONT FOG LIGHT ..................................................... 26 TURN AND HAZARD WARNING LIGHT...................... 28 BACK-UP LIGHT .......................................................... 30 BRAKE LIGHT .............................................................. 32 HIGH-MOUNT BRAKE LIGHT...................................... 32 ILLUMINATION LIGHT.................................................. 34 HEADLIGHT LEVELING SYSTEM ............................... 38 REAR FOG LIGHT........................................................ 40 19 WIPER/WASHER SYSTEM WINDSHIELD WIPER AND WASHER ......................... 42 22 INSTRUMENTATION/DRIVER INFO. INSTRUMENT CLUSTER............................................. 44 POWER, GROUND & COMMON CONNECTOR ELECTRICAL WIRING SCHEMATIC .............................4 FUSE BOX ......................................................................6 COMMON CONNECTOR LIST .......................................8 GROUND POINT...........................................................10 01 ENGINE 19 STARTING SYSTEM.....................................................14 AI ALPHABETICAL INDEX ALPHABETICAL INDEX ............................................... 50 Two digits (section ID) indicated in front of each title are commonly used with the Workshop Manual. 1 Form No. F1A4-20-06D
  126. 126. 00R Reading Wiring Diagrams VEHICLE IDENTIFICATION NUMBER (VIN) CODE W F 0 L M 1 D 1 0 6W 1 2 3 4 5 6 Serial No. Plant Production year W=A. A. Thailand 6= 2006 7= 2007 No meaning 0 Engine type 1= WL-C (2.5 L) Gross vehicle weight Body style Product sorce Air bag World manufacturer identification D= 2268—2721 kg {5001—6000 lbs} E= 2722—3175 kg {6001—7000 lbs} A= Regular cab.-without box E= Double cab.-without box 1= Stretch cab. (with Rear Access System) -without box M= Thailand (for Europe) L= with Air bag (Driver and Passenger) U= with Air bag (Driver, Passenger and Side air bag) WF0= FORD (Europe) 2 Form No. F1A4-20-06D
  127. 127. Reading Wiring Diagrams 00R VEHICLE IDENTIFICATION NUMBERS (VIN) WF0 LM1D10*W WF0 LM1E10*W WF0 LMAD10*W WF0 LMAE10*W WF0 LMED10*W WF0 LMEE10*W WF0 UM1D10*W WF0 UM1E10*W WF0 UMAD10*W WF0 UMAE10*W WF0 UMED10*W WF0 UMEE10*W 3 Form No. F1A4-20-06D
  128. 128. Form No. F1A4-20-06D ELECTRICAL WIRING SCHEMATIC 00E 4
  129. 129. 00F Form No. F1A4-20-06D FUSE BOX 6
  130. 130. Form No. F1A4-20-06D COMMON CONNECTOR LIST 00C-1 8
  131. 131. 00G-a Form No. F1A4-20-06D GROUND POINT 10
  132. 132. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) 3 1 C-04 (F)-(R) C-03 11 (F)-(R) 2 7 4 5 6 C-03 (F)-(R) C-04 (F)-(R) 00G-a
  133. 133. 00G-b Form No. F1A4-20-06D GROUND POINT 12
  134. 134. Form No. F1A4-20-06D (F) HARNESS SYMBOL: (E) (R) 9 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 10 (R)-(DR3) 11 C-15 13 14 9 10 8 13 14 9 10 [REGULAR CAB] 8 [DOUBLE CAB] 15 14 8 00G-b
  135. 135. 0119 Form No. F1A4-20-06D STARTING SYSTEM 14
  136. 136. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 C-05 (F)-(E) [BLACK] 15 0119-01 STARTER F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 0119-02 STARTER RELAY 01 ENGINE 19 STARTING SYSTEM 0119
  137. 137. 0913 Form No. F1A4-20-06D SEAT WARMER 16
  138. 138. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [STRETCH CAB (WITH REAR ACCESS SYSTEM)] MAIN FUSE BLOCK (REFER TO 00F SECTION) (R)-(DR3) C-15 F-01 13 SEAT WARMER UNIT RH 0913-03 SEAT WARMER UNIT RH 0913-03 8 0913-02 C-02 SEAT WARMER UNIT LH (F)-(R) C-03 C-04 (F)-(R) (F)-(R) 17 [REGULAR CAB] 8 C-02 (F)-(R) C-04 (F)-(R) C-03 (F)-(R) 4 5 0913-02 SEAT WARMER UNIT LH SEAT WARMER UNIT RH 0913-03 6 C-02 (F)-(R) [DOUBLE CAB] C-03 (F)-(R) 0913-01 F-02 SEAT WARMER SWITCH C-01 C-04 (F)-(R) FUSE BLOCK (REFER TO 00F SECTION) ENGINE SWITCH C-02 8 (F)-(R) 0913-02 C-03 (F)-(R) C-04 SEAT WARMER UNIT LH (F)-(R) 09 BODY & ACCESSORIES 13 SEATS 0913
  139. 139. Form No. F1A4-20-06D KEYLESS CONTROL MODULE 0914-2 18
  140. 140. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 19 5 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 0914-201 KEYLESS CONTROL MODULE 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS 0914-2
  141. 141. Form No. F1A4-20-06D IMMOBILIZER SYSTEM 0914-3 20
  142. 142. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 3 21 COIL IMMOBILIZER UNIT 0914-302 0914-301 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS 0914-3
  143. 143. 0918-1 Form No. F1A4-20-06D HEADLIGHT 22
  144. 144. Form No. F1A4-20-06D (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 [BLACK] HEADLIGHT RH 0918-105 23 LIGHT SWITCH 0918-104 0918-101 5 HEADLIGHT LH [BLACK] 6 0918-103 TNS RELAY F-02 0918-102 HEADLIGHT RELAY FUSE BLOCK (REFER TO 00F SECTION) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-1
  145. 145. Form No. F1A4-20-06D LICENSE PLATE LIGHT / PARKING LIGHT / TAILLIGHT 0918-2 24
  146. 146. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [BLACK] TAILLIGHT RH 9 0918-204 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] [GRAY] PARKING LIGHT RH 0918-202 [GRAY] LICENSE PLATE LIGHT 0918-205 10 [BLACK] (R2)-SHORT CORD 0918-206 (R)-(R2) C-13 1 0918-203 TAILLIGHT LH [BLACK] [BLACK] TAILLIGHT RH 0918-204 [GRAY] LICENSE PLATE LIGHT 0918-205 9 10 [BLACK] (R2)-SHORT CORD 0918-206 0918-203 TAILLIGHT LH [BLACK] C-03 [BLACK] TAILLIGHT RH (F)-(R) 25 0918-204 [GRAY] LICENSE PLATE LIGHT [REGULAR CAB] 2 0918-205 0918-201 10 PARKING LIGHT LH [GRAY] C-13 (R)-(R2) (R)-(R2) C-13 C-03 9 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] TAILLIGHT LH 0918-203 (F)-(R) [DOUBLE CAB] C-03 (F)-(R) C-03 (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-2
  147. 147. 0918-3 Form No. F1A4-20-06D FRONT FOG LIGHT 26
  148. 148. Form No. F1A4-20-06D (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 1 0918-303 27 FRONT FOG LIGHT RH [BLACK] 2 0918-302 FRONT FOG LIGHT SWITCH 5 FRONT FOG LIGHT LH [BLACK] 0918-101 0918-301 6 FRONT FOG LIGHT RELAY F-02 FUSE BLOCK (REFER TO 00F SECTION) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-3
  149. 149. Form No. F1A4-20-06D TURN AND HAZARD WARNING LIGHT 0918-4 28
  150. 150. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [BLACK] REAR TURN LIGHT RH [GRAY] FRONT SIDE TURN LIGHT RH 0918-204 0918-405 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] MAIN FUSE BLOCK (REFER TO 00F SECTION) 9 10 0918-206 [BLACK] REAR TURN LIGHT LH (R)-(R2) F-01 [BLACK] (R2)-SHORT CORD 0918-203 C-13 [GRAY] FRONT SIDE TURN LIGHT LH 1 0918-406 FRONT TURN LIGHT RH 0918-403 [BLACK] REAR TURN LIGHT RH 0918-204 (R)-(R2) [BLACK] (R2)-SHORT CORD 0918-206 9 10 C-13 [BLACK] REAR TURN LIGHT LH 0918-203 C-03 (F)-(R) 29 [REGULAR CAB] 0918-404 2 [BLACK] REAR TURN LIGHT RH FRONT TURN LIGHT LH 0918-204 FLASHER CONTROL MODULE 0918-401 (R)-(R2) C-13 TURN SWITCH 4 0918-101 5 9 10 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] REAR TURN LIGHT LH 0918-203 C-03 HAZARD WARNING SWITCH (F)-(R) 0918-402 [DOUBLE CAB] 6 C-03 (F)-(R) F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH C-03 (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-4
  151. 151. 0918-5 Form No. F1A4-20-06D BACK-UP LIGHT 30
  152. 152. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [BLACK] BACK-UP LIGHT RH 0918-204 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 9 10 [BLACK] (F)-(E) [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] BACK-UP LIGHT LH C-05 (R)-(R2) [BLACK] BACK-UP LIGHT SWITCH 0918-203 C-13 0918-501 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 [BLACK] BACK-UP LIGHT RH 0918-204 10 9 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] BACK-UP LIGHT LH 0918-203 (R)-(R2) C-13 C-03 (F)-(R) 31 [REGULAR CAB] [BLACK] BACK-UP LIGHT RH 0918-204 9 (R)-(R2) C-13 10 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] BACK-UP LIGHT LH 0918-203 C-03 (F)-(R) [DOUBLE CAB] C-03 (F)-(R) C-01 ENGINE SWITCH F-02 FUSE BLOCK (REFER TO 00F SECTION) C-03 (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-5
  153. 153. Form No. F1A4-20-06D BRAKE LIGHT / HIGH-MOUNT BRAKE LIGHT 0918-6 32
  154. 154. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [BLACK] BRAKE LIGHT RH [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 0918-204 HIGH-MOUNT BRAKE LIGHT 0918-602 MAIN FUSE BLOCK (REFER TO 00F SECTION) 10 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] BRAKE LIGHT LH 9 (R)-(DR3) F-01 (R)-(R2) 0918-203 C-15 C-13 13 [BLACK] BRAKE LIGHT RH 0918-204 9 10 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] BRAKE LIGHT LH (R)-(R2) 0918-203 C-13 C-03 (F)-(R) 33 [REGULAR CAB] [BLACK] BRAKE LIGHT RH 0918-204 HIGH-MOUNT BRAKE LIGHT 0918-602 BRAKE SWITCH 4 (F)-(R) 5 [BLACK] (R2)-SHORT CORD 0918-206 [BLACK] BRAKE LIGHT LH C-03 0918-601 9 10 (R)-(R2) 0918-203 C-13 [DOUBLE CAB] F-02 C-03 (F)-(R) FUSE BLOCK (REFER TO 00F SECTION) C-03 (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-6
  155. 155. Form No. F1A4-20-06D ILLUMINATION LIGHT 0918-7a 34
  156. 156. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) HAZARD WARNING SWITCH ILLUMINATION 0918-402 REAR WINDOW DEFROSTER SWITCH ILLUMINATION 0912-102 INSTRUMENT CLUSTER ILLUMINATION 0922-101 A/C SWITCH ILLUMINATION AUDIO UNIT ILLUMINATION 0740-11 0920-201 35 (F)-SHORT CORD C-26 0918-701 HEATER CONTROL ILLUMINATION 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-7a
  157. 157. Form No. F1A4-20-06D ILLUMINATION LIGHT 0918-7b 36
  158. 158. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) RFW MAIN SWITCH ILLUMINATION 0318-03 4 [BLUE] PANEL LIGHT CONTROL SWITCH 0918-704 HEADLIGHT LEVELING SWITCH ILLUMINATION 0918-901 5 37 6 0913-01 SEAT WARMER SWITCH ILLUMINATION 0918-703 GLOVE COMPARTMENT LIGHT [BLACK] 0918-702 CONSOLE ILLUMINATION [BLACK] 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-7b
  159. 159. Form No. F1A4-20-06D HEADLIGHT LEVELING SYSTEM 0918-9 38
  160. 160. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) 1 0918-903 HEADLIGHT LEVELING ACTUATOR RH [GRAY] 39 2 0918-902 HEADLIGHT LEVELING ACTUATOR LH [GRAY] 4 5 HEADLIGHT LEVELING SWITCH 0918-901 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-9
  161. 161. 0918-10 Form No. F1A4-20-06D REAR FOG LIGHT 40
  162. 162. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [BLACK] (R2)-SHORT CORD 9 10 REAR FOG LIGHT SWITCH 0918-101 5 0918-206 (R)-(R2) C-13 [REGULAR CAB] 0918-1002 6 REAR FOG LIGHT [GRAY] C-02 (F)-(R) 0918-1001 REAR FOG LIGHT RELAY C-02 (F)-(R) 41 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 9 10 10 9 [BLACK] (R2)-SHORT CORD (R)-(R2) 0918-206 [BLACK] (R2)-SHORT CORD 0918-206 C-13 (R)-(R2) C-13 [DOUBLE CAB] 0918-1002 0918-1002 REAR FOG LIGHT [GRAY] REAR FOG LIGHT [GRAY] C-02 (F)-(R) C-02 (F)-(R) 09 BODY & ACCESSORIES 18 LIGHTING SYSTEMS 0918-10
  163. 163. Form No. F1A4-20-06D WINDSHIELD WIPER AND WASHER 0919 42
  164. 164. Form No. F1A4-20-06D (F) HARNESS SYMBOL: (E) (R) MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 WINDSHIELD WIPER MOTOR 0919-02 1 0919-03 WINDSHIELD WASHER MOTOR 43 [BLACK] WINDSHIELD WIPER AND WASHER SWITCH 2 0919-01 5 6 F-02 FUSE BLOCK (REFER TO 00F SECTION) C-01 ENGINE SWITCH 09 BODY & ACCESSORIES 19 WIPER/WASHER SYSTEM 0919
  165. 165. Form No. F1A4-20-06D INSTRUMENT CLUSTER 0922-1a 44
  166. 166. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [BROWN] VEHICLE SPEEDOMETER SENSOR 0922-104 4 [STRETCH CAB (WITH REAR ACCESS SYSTEM)] 2 FUEL GAUGE SENDER UNIT [GRAY] VEHICLE SPEEDOMETER SENSOR [GRAY] (F)-(E) C-06 0922-104 4 0922-107 4 (R)-(R2) C-13 MAIN FUSE BLOCK (REFER TO 00F SECTION) F-01 FUEL GAUGE SENDER UNIT 0922-107 (R)-(R2) C-13 0922-106 C-03 (F)-SHORT CORD [BLACK] (F)-(R) 0922-105 45 WATER TEMPERATURE SENDER UNIT [GRAY] [REGULAR CAB] INSTRUMENT CLUSTER 7 0922-101 FUEL GAUGE SENDER UNIT 0922-107 [BLACK] IGNITION KEY ILLUMINATION (R)-(R2) 0922-103 C-13 C-03 (F)-(R) 0922-102 KEY REMINDER SWITCH [DOUBLE CAB] C-03 (F)-(R) F-02 C-01 FUSE BLOCK (REFER TO 00F SECTION) ENGINE SWITCH C-03 (F)-(R) 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 0922-1a
  167. 167. Form No. F1A4-20-06D INSTRUMENT CLUSTER 0922-1b 46
  168. 168. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) BRAKE FLUID LEVEL SENSOR 0922-110 47 INSTRUMENT CLUSTER 0922-101 (F)-SHORT CORD 0922-108 4 5 PARKING BRAKE SWITCH 0922-109 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 0922-1b
  169. 169. Form No. F1A4-20-06D INSTRUMENT CLUSTER 0922-1c 48
  170. 170. Form No. F1A4-20-06D HARNESS SYMBOL: (F) (E) (R) [GRAY] SEDIMENTOR SWITCH [BLACK] (F)-(E) 0922-112 C-05 49 INSTRUMENT CLUSTER 0922-101 0922-111 OIL PRESSURE SWITCH 09 BODY & ACCESSORIES 22 INSTRUMENTATION/DRIVER INFO. 4 5 0922-1c
  171. 171. ALPHABETICAL INDEX O B BACK-UP LIGHT .................................................... 30 BACK-UP LIGHT SWITCH ..................................... 30 BRAKE FLUID LEVEL SENSOR............................ 46 BRAKE LIGHT ........................................................ 32 BRAKE SWITCH .................................................... 32 OIL PRESSURE SWITCH.......................................48 P PANEL LIGHT CONTROL SWITCH .......................36 PARKING BRAKE SWITCH ....................................46 PARKING LIGHT.....................................................24 C COIL ....................................................................... 20 COMMON CONNECTOR LIST ................................ 8 R REAR FOG LIGHT ..................................................40 REAR FOG LIGHT RELAY .....................................40 REAR FOG LIGHT SWITCH ...................................40 REAR TURN LIGHT ................................................28 E ELECTRICAL WIRING SCHEMATIC ....................... 4 S F FLASHER CONTROL MODULE ............................ 28 FOG LIGHT (FRONT) .............................................................. 26 (REAR) ................................................................ 40 FOG LIGHT RELAY (FRONT) .............................................................. 26 (REAR) ................................................................ 40 FOG LIGHT SWITCH (FRONT) .............................................................. 26 (REAR) ................................................................ 40 FRONT FOG LIGHT ............................................... 26 FRONT FOG LIGHT RELAY .................................. 26 FRONT FOG LIGHT SWITCH................................ 26 FRONT SIDE TURN LIGHT ................................... 28 FRONT TURN LIGHT............................................. 28 FUEL GAUGE SENDER UNIT ............................... 44 FUSE BOX................................................................ 6 G GENERAL INFORMATION ...................................... 2 GLOVE COMPARTMENT LIGHT........................... 36 GROUND POINT.................................................... 10 H HAZARD WARNING SWITCH ............................... 28 HEADLIGHT ........................................................... 22 HEADLIGHT LEVELING ACTUATOR.................... 38 HEADLIGHT LEVELING SWITCH ......................... 38 HEADLIGHT RELAY .............................................. 22 HIGH-MOUNT BRAKE LIGHT................................ 32 I ILLUMINATION A/C SWITCH........................................................ 34 AUDIO UNIT ........................................................ 34 CONSOLE ........................................................... 36 HAZARD WARNING SWITCH ............................ 34 HEADLIGHT LEVELING SWITCH ...................... 36 HEATER CONTROL............................................ 34 IGNITION KEY..................................................... 44 INSTRUMENT CLUSTER ................................... 34 REAR WINDOW DEFROSTER SWITCH............ 34 RFW MAIN SWITCH ........................................... 36 SEAT WARMER SWITCH................................... 36 IMMOBILIZER UNIT ............................................... 20 INSTRUMENT CLUSTER ...................................... 44 K KEY REMINDER SWITCH ..................................... 44 KEYLESS CONTROL MODULE ............................ 18 L LICENSE PLATE LIGHT ........................................ 24 LIGHT SWITCH ...................................................... 22 50 Form No.F1A4-20-06D SEAT WARMER SWITCH.......................................16 SEAT WARMER UNIT ............................................16 SEDIMENTOR SWITCH .........................................48 SIDE TURN LIGHT..................................................28 STARTER................................................................14 STARTER RELAY ...................................................14 T TAILLIGHT ..............................................................24 TNS RELAY.............................................................22 TURN LIGHT ...........................................................28 TURN SWITCH .......................................................28 V VEHICLE IDENTIFICATION NUMBERS (VIN) .........3 VEHICLE SPEEDOMETER SENSOR ....................44 W WATER TEMPERATURE SENDER UNIT .....................................................44 WINDSHIELD WASHER MOTOR...........................42 WINDSHIELD WIPER AND WASHER SWITCH...............................................42 WINDSHIELD WIPER MOTOR...............................42
  172. 172. CONTENTS TITLE RANGER Wiring Diagrams Supplement FOREWORD This wiring diagram incorporates the wiring schematics of the RANGER and available optional equipment. Actual vehicle wiring may vary slightly depending on optional equipment or local specifications, or both. For proper repair and maintenance, a thorough familiarization with this manual is important, and it should always be kept in a handy place for quick and easy reference. All the contents of this manual, including drawings and specifications, are the latest available at the time of printing. As modifications affecting repair or maintenance occur, relevant information supplementary to this volume will be made available at Ford dealers. This manual should be kept up-to-date. Ford Motor Company reserves the right to alter the specifications and contents of this manual without obligation or advance notice. All rights reserved. No part of this book may be reproduced or used in any form or by any means, electronic or mechanical-including photocopying and recording and the use of any kind of information storage and retrieval system-without permission in writing. Ford Motor Company SECTION GENERAL INFORMATION 00 ENGINE 01 SUSPENSION 02 DRIVELINE/AXLE 03 BRAKES 04 TRANSMISSION/TRANSAXLE 05 STEERING 06 HEATER, VENTILATION & AIR CONDITIONING (HVAC) 07 RESTRAINTS 08 BODY & ACCESSORIES 09 ALPHABETICAL INDEX AI © 2006 Ford Motor Company PRINTED IN , JUL. 2006 F1A5-30-06G APPLICATION: This manual is applicable to vehicles beginning with the Vehicle Identification Numbers (VIN) shown on the following page. Form No. F1A5-30-06G
  173. 173. VEHICLE IDENTIFICATION NUMBERS (VIN) (CHASSIS NUMBERS) Australian specs. MNA BS1D90*W MNA BS1E90*W MNA BS2D90*W MNA BS2E90*W MNA BSAD10*W MNA BSAD90*W MNA BSAE10*W MNA BSAE90*W MNA BSBD10*W MNA BSBD90*W MNA BSBE10*W MNA BSBE90*W MNA BSED90*W MNA BSEE90*W MNA BSFD90*W MNA BSFE90*W MNA DS1D90*W MNA DS1E90*W MNA DS2D90*W MNA DS2E90*W MNA DSAD10*W MNA DSAD90*W MNA DSAE10*W MNA DSAE90*W MNA DSBD10*W MNA DSBD90*W MNA DSBE10*W MNA DSBE90*W MNA DSED90*W MNA DSEE90*W MNA DSFD90*W MNA DSFE90*W MNA LS1D90*W MNA LS1E90*W MNA LS2D90*W MNA LS2E90*W MNA LSAD10*W MNA LSAD90*W MNA LSAE10*W MNA LSAE90*W MNA LSBD10*W MNA LSBD90*W MNA LSBE10*W MNA LSBE90*W MNA LSED90*W MNA LSEE90*W MNA LSFD90*W MNA LSFE90*W MNA US1D90*W MNA US1E90*W MNA US2D90*W MNA US2E90*W MNA USAD10*W MNA USAD90*W MNA USAE10*W MNA USAE90*W MNA USBD10*W MNA USBD90*W MNA USBE10*W MNA USBE90*W MNA USED90*W MNA USEE90*W MNA USFD90*W MNA USFE90*W General (R.H.D.) specs. MNB BSAD40*W MNB USAE40*W MNB BSAE40*W MNB USBD40*W MNB BSBD40*W MNB USBE40*W MNB BSBE40*W MNB USED10*W MNB BSED10*W MNB USED40*W MNB BSED40*W MNB USED90*W MNB BSED90*W MNB USEE10*W MNB BSEE10*W MNB USEE40*W MNB BSEE40*W MNB USEE90*W MNB BSEE90*W MNB USFD10*W MNB BSFD10*W MNB USFD40*W MNB BSFD40*W MNB USFD90*W MNB BSFD90*W MNB USFE10*W MNB BSFE10*W MNB USFE40*W MNB BSFE40*W MNB USFE90*W MNB BSFE90*W MNB DSAD40*W MNB DSAE40*W MNB DSBD40*W MNB DSBE40*W MNB DSED10*W MNB DSED40*W MNB DSED90*W MNB DSEE10*W MNB DSEE40*W MNB DSEE90*W MNB DSFD10*W MNB DSFD40*W MNB DSFD90*W MNB DSFE10*W MNB DSFE40*W MNB DSFE90*W MNB LSAD40*W MNB LSAE40*W MNB LSBD40*W MNB LSBE40*W MNB LSED10*W MNB LSED40*W MNB LSED90*W MNB LSEE10*W MNB LSEE40*W MNB LSEE90*W MNB LSFD10*W MNB LSFD40*W MNB LSFD90*W MNB LSFE10*W MNB LSFE40*W MNB LSFE90*W MNB USAD40*W Form No. F1A5-30-06G
  174. 174. SYSTEM INDEX 00 GENERAL INFORMATION R READING WIRING DIAGRAMS VEHICLE IDENTIFICATION NUMBER (VIN) CODE.......2 VEHICLE IDENTIFICATION NUMBERS (VIN)................3 E F C G 09 BODY & ACCESSORIES 14 SECURITY AND LOCKS IMMOBILIZER SYSTEM............................................... 32 18 LIGHTING SYSTEMS LICENSE PLATE LIGHT ............................................... 34 PARKING LIGHT........................................................... 34 TAILLIGHT .................................................................... 34 FRONT FOG LIGHT ..................................................... 36 BACK-UP LIGHT .......................................................... 38 ILLUMINATION LIGHT.................................................. 40 20 ENTERTAINMENT AUDIO SYSTEM ........................................................... 44 22 INSTRUMENTATION/DRIVER INFO. INSTRUMENT CLUSTER............................................. 48 POWER, GROUND & COMMON CONNECTOR ELECTRICAL WIRING SCHEMATIC .............................4 FUSE BOX ......................................................................6 COMMON CONNECTOR LIST .......................................8 GROUND POINT...........................................................10 DATA LINK CONNECTOR D DATA LINK CONNECTOR ............................................14 01 17 19 40 ENGINE CHARGING SYSTEM ...................................................16 STARTING SYSTEM.....................................................18 CONTROL SYSTEM WLT WITHOUT IMMOBILIZER SYSTEM ..................20 WLT WITH IMMOBILIZER SYSTEM ..........................24 AI ALPHABETICAL INDEX ALPHABETICAL INDEX ............................................... 56 03 DRIVELINE/AXLE 18 4-WHEEL DRIVE REMOTE FREEWHEEL CONTROL SYSTEM WLT ............................................................................28 07 HEATER, VENTILATION & AIR CONDITIONING (HVAC) 40 CONTROL SYSTEM HEATER AND AIR CONDITIONER...............................30 Two digits (section ID) indicated in front of each title are commonly used with the Workshop Manual. 1 Form No. F1A5-30-06G

×