1. Welcome ToS.E.S. Labour SolutionsSafety Induction
2. Introduction•This induction is a general safetyinduction to help you work safely.•The induction requires you to readand understand this presentation.• At the end of this presentation thereis a short assessment that you arerequired to complete•Completing this induction andsuccessfully completing theassessment is a condition of youremployment
3. Rules & Legislation•You have an obligation (responsibility)under the WHS Act 2011 QLD to take allreasonable steps to prevent accidents.•You must–Comply with instructions–Use personal protective equipment (PPE)•You must not–Willfully or recklessly interfere with or misuseanything in the workplace–Willfully place other people at risk–Willfully injure yourself
4. Rules & LegislationReportingReporting You must report to your Site SupervisorYou must report to your Site Supervisor All accidents or incidents you are involved in.All accidents or incidents you are involved in. Anything you consider to be unsafeAnything you consider to be unsafe Where you have been asked by the SiteWhere you have been asked by the SiteSupervisor or their representatives to performSupervisor or their representatives to performwhat you consider as unsafe work, you mustwhat you consider as unsafe work, you mustreport it to S.E.S. Labour Solutions immediately.report it to S.E.S. Labour Solutions immediately.
5. Fit for Work Rules and regulations require that you are in aRules and regulations require that you are in afit condition for workfit condition for work You must ensure that you areYou must ensure that you are Physically and physiologically fit for dutyPhysically and physiologically fit for duty You are not impaired from alcohol or drugsYou are not impaired from alcohol or drugs You must not take onto site any alcohol or drugsYou must not take onto site any alcohol or drugs You must not consume any alcohol or drugs onYou must not consume any alcohol or drugs onsitesite You will undergo a drug and alcohol test ifYou will undergo a drug and alcohol test ifinvolved in a major accident.involved in a major accident.
6. Unacceptable BehaviourDo notDo notEngage in horseplayEngage in horseplayPlay practical jokesPlay practical jokesHarass peopleHarass peopleDiscriminate against peopleDiscriminate against peopleCome to work under the influence of alcohol or drugsCome to work under the influence of alcohol or drugsSleep on the jobSleep on the jobFight, use threatening or abusive languageFight, use threatening or abusive languageSmoke in non smoking areaSmoke in non smoking areaIgnore or disregard proceduresIgnore or disregard proceduresWillfully damage equipmentWillfully damage equipmentOperate any equipment or machinery unless authorisedOperate any equipment or machinery unless authorisedand qualified (licenced, ticketed)and qualified (licenced, ticketed)
7. General SafetySafety SignsSafety Signs Safety signs draw your attention to safetySafety signs draw your attention to safetysituation and objects.situation and objects. Safety signs must be complied with andSafety signs must be complied with andhave the same authority as a supervisor’shave the same authority as a supervisor’sinstructioninstruction Do not damage, destroy or remove safetyDo not damage, destroy or remove safetysignssigns
8. Road Traffic Signs Same meaning as on roadsSame meaning as on roads Controls trafficControls traffic
9. Mandatory Signs Signs are blue and whiteSigns are blue and white in colourin colour.. Pictured instructionsPictured instructions mustmust be carried out.be carried out.
10. Prohibitory Signs Red, black and white with the red circle andRed, black and white with the red circle andred diagonal.red diagonal. Pictured action or activity is not permitted.Pictured action or activity is not permitted.
11. Warning Signs Black and yellowBlack and yellow Hazard or hazardous condition.Hazard or hazardous condition. Not life threatening but use caution.Not life threatening but use caution.
12. Danger Signs Red, black and whiteRed, black and white Hazard or hazardous conditionHazard or hazardous condition Life threatening - Do not proceed unlessLife threatening - Do not proceed unlessauthorised.authorised.
13. Emergency Information Signs Green and white.Green and white. Location or direction to emergency relatedLocation or direction to emergency relatedfacilities. eg first aid kits or exits.facilities. eg first aid kits or exits.
14. Fire Related Signs Red and white.Red and white. Location of fire fighting equipment.Location of fire fighting equipment.
15. Personal Protective Equipment (PPE)PPE must be worn at all time when:-PPE must be worn at all time when:- Instructed by a procedureInstructed by a procedure Safety signs displayedSafety signs displayed Instructed by a supervisorInstructed by a supervisor You think added safety protection isYou think added safety protection isrequired.required.
16. PPE PPE you must wear includes:-PPE you must wear includes:- Safety boots (steel toe capped boots)Safety boots (steel toe capped boots) Safety helmet (hard hat)Safety helmet (hard hat) Eye protection (safety glasses, face shields,Eye protection (safety glasses, face shields,goggles)goggles) GlovesGloves Hearing protection (ear plugs, ear muffs)Hearing protection (ear plugs, ear muffs) Respirators (disposable masks, cartridgeRespirators (disposable masks, cartridgerespirators)respirators) Sun protection (hat, clothing, sun screen)Sun protection (hat, clothing, sun screen) Protective clothing (long sleeved shirt, longProtective clothing (long sleeved shirt, longtrousers)trousers)
17. PPEPPE should be :-• Suited for the intended task• Inspected prior to use• Fitted properly• Hygienic
18. Workplace Hazards A hazard is a thing or situation with the potentialA hazard is a thing or situation with the potentialto cause injury or illness to a person.to cause injury or illness to a person. You are required to continually identify andYou are required to continually identify andcontrol hazards in the workplace.control hazards in the workplace. You should conduct informal risk assessments byYou should conduct informal risk assessments byaskingasking What am I about to do?What am I about to do? What can go wrong?What can go wrong? What can I do to stop it going wrong?What can I do to stop it going wrong?
19. Workplace HazardsSome typical workplace hazards are:-–Manual handling – lifting–Using ladders–Working at heights and falling objects–Working with electricity–Working with compressed air–Working with chemicals and hazardoussubstances–Vehicles and mobile equipment–Rotating machinery
20. Manual Handling - Lifting Take care of your back. About 25% of all workTake care of your back. About 25% of all workinjuries are back injuriesinjuries are back injuries When lifting:-When lifting:- Use straight backUse straight back Lift with your legsLift with your legs Feet apart for good balanceFeet apart for good balance Use firm gripUse firm grip Use mechanical lifting equipmentUse mechanical lifting equipment Get help to move the loadGet help to move the load
21. Working at Heights and Falling Objects If 2.4 M above the ground and outsideIf 2.4 M above the ground and outsidehandrails, wear a safety harness (fall arresthandrails, wear a safety harness (fall arrestequipment)equipment) When working at heights, make sure theWhen working at heights, make sure thearea beneath you is barricaded againstarea beneath you is barricaded againstpeople getting hit by falling objects such aspeople getting hit by falling objects such asdropped tools.dropped tools.
22. Working with Electricity•Inspect leads and electrical equipment for damageand defects before use•Check electrical inspection tags•Use earth leakage protection devices (electrical safetyswitches)•Never operate electrical equipment while standing inwater•Treat extension leads carefully•Look out for overhead power lines•Do not use double adaptors
23. Compressed Air Safety Do not blow yourself down (clean clothes)Do not blow yourself down (clean clothes)using compressed airusing compressed air Do not crimp air hosesDo not crimp air hoses Use safety clips at hose connectionsUse safety clips at hose connections Do not allow compressed air to contact skinDo not allow compressed air to contact skin– air embolism results in death.– air embolism results in death.
24. Chemicals and Hazardous Substances Many workplace deaths, accidents and injuriesMany workplace deaths, accidents and injuriesresult from chemicalsresult from chemicals Chemicals must be used, handled and stored inChemicals must be used, handled and stored inaccordance with Material Safety Data Sheetsaccordance with Material Safety Data Sheets(MSDS)(MSDS) MSDS describe the safety precautions to beMSDS describe the safety precautions to befollowed for that chemicalfollowed for that chemical
25. Vehicles and Mobile Equipment Make sure you are authorised to drive on siteMake sure you are authorised to drive on site Follow the site road rulesFollow the site road rules Watch out for pedestriansWatch out for pedestrians Park in designated car parksPark in designated car parks Wear the seat beltWear the seat belt Only ride in the provided seatingOnly ride in the provided seating Operate equipment (and drive vehicles) in a safeOperate equipment (and drive vehicles) in a safemannermanner
26. Rotating Machinery•Keep hands and clothing away frommachinery nip points (pinch points)•Ensure machine guards are in place and wellmaintained•Never remove a guard to work on a movingmachine•Ensure machinery has fully stopped beforecommencing working on the machine (somemachinery takes several minutes to coast to astop)
27. Fire•Check for the location of the nearest fireextinguisher (first activity in a new workarea)•Find the location of the button (switch, etc)for the fire alarm•Find the location of the nearest fireassembly point (muster point)•Prevent fires by–Maintain high standards of housekeeping–Do not smoke around flammable materials–Take precautions when conduct welding or oxywork around flammable materials
28. First Aid First aid kits are generally located inFirst aid kits are generally located inlunchrooms, office or control room.lunchrooms, office or control room. Find the location of your nearest first aidFind the location of your nearest first aidkit.kit. Report to the Site Supervisor any injury thatReport to the Site Supervisor any injury thatrequired first aid treatmentrequired first aid treatment..
29. Lock out/Tag out - Isolation Danger tags and locks are used to protect youDanger tags and locks are used to protect youfrom machinery being started up by someonefrom machinery being started up by someoneelse while you are working on itelse while you are working on it Always use danger tags and locksAlways use danger tags and locks When even you see a tag, you should read itWhen even you see a tag, you should read it Only you can remove your danger tagsOnly you can remove your danger tags Do not remove other people’s danger tagsDo not remove other people’s danger tags Ensure the correct switch is isolatedEnsure the correct switch is isolated Test by trying to restart to ensure correctTest by trying to restart to ensure correctisolationisolation
30. Out of Service Tags Out of service tags are use to protectOut of service tags are use to protectmachinery that should not be used ormachinery that should not be used orthat could be a hazard if used.that could be a hazard if used. Out of service tags should be placed onOut of service tags should be placed onthe main isolating switchthe main isolating switch Out of service tags can be removed byOut of service tags can be removed bythe person who completes the repairs orthe person who completes the repairs oran authorised person.an authorised person.
31. Finish This is the end of the induction presentationThis is the end of the induction presentation Please complete the provided writtenPlease complete the provided writtenassessmentassessment Please do not hesitate to ask for help if youPlease do not hesitate to ask for help if youhave any questions, concerns or havinghave any questions, concerns or havingdifficulties.difficulties.