• Share
  • Email
  • Embed
  • Like
  • Save
  • Private Content
Truck TireMoni product catalog 2014 in English
 

Truck TireMoni product catalog 2014 in English

on

  • 221 views

Truck TireMoni product catalog 2014: intelligent tyre pressure monitoring systems for trucks and busses for fast and easy retrofit. Drive safely, arrive safely: Every Time. Save fuel and prevent ...

Truck TireMoni product catalog 2014: intelligent tyre pressure monitoring systems for trucks and busses for fast and easy retrofit. Drive safely, arrive safely: Every Time. Save fuel and prevent blowouts: Clever. Reduce operating cost and increase service quality with a small investement with sort ROI.

Statistics

Views

Total Views
221
Views on SlideShare
221
Embed Views
0

Actions

Likes
0
Downloads
2
Comments
0

0 Embeds 0

No embeds

Accessibility

Upload Details

Uploaded via as Adobe PDF

Usage Rights

© All Rights Reserved

Report content

Flagged as inappropriate Flag as inappropriate
Flag as inappropriate

Select your reason for flagging this presentation as inappropriate.

Cancel
  • Full Name Full Name Comment goes here.
    Are you sure you want to
    Your message goes here
    Processing…
Post Comment
Edit your comment

    Truck TireMoni product catalog 2014 in English Truck TireMoni product catalog 2014 in English Document Transcript

    • TireMoni Truck TPMS intelligent tyre pressure monitoring systems for fast and easy installation! Drive safely, arrive safely. Every time! Save fuel, prevent blowouts. Clever!
    • tpm-systems AG Tyre Pressure Monitoring Cost and Usability Aspects for Commercial Vehicles Correct tyre pressure provides four benefits! Incorrect tyre pressure increases your operating cost and can be dangerous, too. With too little air in your tyres you will face excessive wear and in the end there is the risk of a break down. At the same time, overinflated tyres and excessive load will also reduct your mileage. The diagram on the right clearly shows: 20% too much load or 20% too little pressure will increase tyre wear by around 20%, i.e. you are only using 80% of maximum possible mileage. Bildnachweis: www.michelintransport.com > The impact on fuel consumption is just as serious. Produkt-Informationen > Der Luftdruck Studies by Shell, VDA, Wabco et. al. are agreeing on 2,5% higher fuel consumption at 20% below rated pressure. This percentage increases up to 8% for lower pressures. The third aspect is maintenance cost: Thorough tyre maintenance costs time: ca. 60 - 90 seconds per wheel and costs are repeating typically once a week. With labor costs of 15 - 20 Euro per hour, your yearly total per vehicle accumulates ca. 750 Euro. Finally there is the cost for neglected maintenance which will lead to more frequent tyre failures than with regular maintenance or with monitored tyres. These tyre failures are very costly when they occur. Costs of 1500 Euro per event are common; and in many cases there will be additional costs for the downtime of the vehicle plus penalties for failing to meet delivery commitments. With a tyre pressure monitoring system all four aspects will be improved: The tyre pressures are permanently monitored and (via a telematics system) it can be added as a parameter to the cost accounting; this adds another important variable to your calculations and MIS. The result: improved competitiveness in an ever narrower market and an improved bottom line without much effort. Typical ROI is achieved after only 6 - 9 months. The acquisition cost for TireMoni Truck TPMS can be subsidized under the DeMinimis Program (Germany) as safety equipment; this reduces your ROI by another very large factor. tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG LED Pressure Alarm Optical-electronic tyre pressure monitoring sensors The valve cap warns with a red flashing light when the pressure in your tyre is too low. LED pressure alarm is a strong tool to prevent flat tyres and to reduce operating costs (fuel consumption, tyre wear); at the same time driving safety is improved considerably. The sensor is installed on the valve in place of the valve cap; during installation it automatically calibrates to the pressure present in the tyre and monitors it permanently. If the pressure drops by more than 0,5 Bar, the sensor warns by a red flashing light. The LED is clearly visible for 20 m even in daylight. Pressure variations as a result of temperature changes are automatically compensated - no false warnings. Anti theft protection is included in the design. Highlights: ✔ Automatic calibration during installation ✔ Clearly visible warning ✔ Temperature compensation “by Design” ✔ Integrated anti theft protection ✔ Batteries replaceable (Service-Kit) The sensor caps are very robust and are installed in three easy steps: 1) Inflate cold tyre to required cold inflation pressure. 2) Install the LED Pressure Alarm sensor onto the valve using the key. 3) Check the sensor for tightness with leak-spray. Article-No.: LPA-HV-B LPA-HV-BL6 Description LED Pressure Alarm single LED Pressure Alarm 6-pack tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG The complete and flexible Tyre Pressure Monitoring System 1 w 01 Ne n 2 io rs Ve Truck TPMS Advantages: • Specially designed for trucks and large commercial vehicles • Easy handling of trailer changes using Smart-Booster • Monitors up to 38 wheels per system • Increases safety on the road and reliability • Reduces fuel consumption and CO2 emission • Increases tyre lifetime • Real-Time information about tyre pressure and temperature • Facilitates ‘CSR’ (Corporate Social Responsibility) • 3 low pressure warning threshold levels • Visual and acoustic alarm for rapid pressure loss • Visual and acoustic alarm for overpressure • Visual and acoustic alarm for overtemperature Article-No.: 10.01.012 10.01.018 10.01.041 10.01.040 10.01.021 10.01.030 Description TPMS Monitor for installation with suction cup TPMS Monitor for installation in DIN slot External antenna, cable length 10 m Sensor for Truck TPMS SmartBooster for trailer operation Hand programmier- and reader tool tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG new Design, improved Data Transmission Specifications Monitor Frequency: Receiver sensitivity: Display: Operating temperature: Operating voltage: Dimensions: Article number: 434.1 MHz -105 dBm LCD, adjustable backlight -30 °C ~ +75 °C 12 V or 24 V 104 x 65 x 25 mm 10.01.012 Sensor Frequency: TX power: Lifetime: Measurement range: Measurement accuracy: Operating temperature: Dimensions: Article number: 434.1 MHz 0 dBm 4 - 5 years 0 – 13 Bar ± 0.15 Bar -40 °C ~ +135 °C Ø 27,5 x 32,5 mm 10.01.040 Smart Booster Frequency: Receiver sensitivity: TX power: Operating temperature: Operating voltage: Dimensions: Article number: 434.1 MHz -105 dBm 0 dBm -40 °C ~ +85 °C 24 V 203x123x51 mm 10.01.021 Hand Tool Frequency: Receiver sensitivity: TX power: Operating voltage: Operating temperature: Dimensions: Article number: 434.1 MHz -95 dBm 0 dBm 9V -30 °C ~ +75 °C 210x110x30 mm 10.01.030 tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com w! Ne Truck TPMS
    • tpm-systems AG The Tyre Pressure Monitoring System for Integration into Onboard-Telematic-Systems Advantages: • RS232 or CAN Interfaces allows integration with Telematic-systems • Realtime monitoring of pressure and temperature • Alarm for fast pressure loss • Multi-stage pressure alarm for pressure loss (3 stages) • Pressure alarm for high pressure • Alarm for high temperature and sensor problem • Readable warnings log • Smart-Booster for easy trailer changes • Custom modifications possible • Central cost monitoring and analysis • Controllable and predictable maintenance Article-No.: 10.01.016 10.01.017 10.01.019 10.01.041 10.01.040 10.01.021 10.01.030 Description Monitor with RS232 interface Monitor with RS232 interface, custom software Monitor with CAN-Bus interface External antenna, cable length 10 m Sensor for truck TPMS SmartBooster for trailer operation Hand programming- and reading tool tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com w! Ne Telematic TPMS
    • tpm-systems AG For Road-Trains and Interlinks, Low Beds and Special Vehicles Advantages: • Special design for commercial vehicles with more than one trailer or several segments • Monitors up to 8 trailers and 180 wheels • Improves safety on the road and reliability • Reduces fuel consumption • Increases tyre lifetime • Realtime information about tyre pressure and temperature • Facilitates ‘CSR’ (Corporate Social Responsibility) • Acoustic and visual alarm for fast pressure loss • 3 pressure warning levels • Acoustic and visual alarm for high pressure • Acoustic and visual alarm for high temperature Article-No.: 10.01.210 10.01.041 10.01.221 10.01.040 10.01.130 Description RT-TPMS monitor External antenna, cable length 10 m RT-Smart Booster, 24V Truck TPMS sensor RT-Hand programming- and reading tool tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com w! Ne TPMS-RT
    • tpm-systems AG w! Ne Bus TPMS for Citybus, Service Buses, Coaches Advantages: • Reduces fuel consumption, CO2 emissions and tyre wear • Improves driving safety • In-slot display blends in with the dashboard Functions: • Low pressure alarm, hi-pressure alarm, alarm for fast pressure loss • Easy to install; suitable for manufacturer installation • Connection to permanent Vcc enables continuous monitoring Alarm-Functions: • Low pressure alarm: Level 1: -12.5 %; Level 2: -25 %; Level 3: -50 % • Fast leak alarm: when pressure loss > 0,2 Bar within 12 seconds • High pressure alarm: at +25 % • Transmitter problem alarm: when the transmitter is no longer working or in case of radio interferences • High temperature alarm: at more than 90°C tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG w! Ne Bus TPMS for a safe and relaxed journey Specifications: Monitor Frequency: Receiver sensitivity: Operating temperature: Operating voltage: Dimensions: Article number: 434.1 MHz -105 dBm -30 °C ~ +85 °C 12 V oder 24 V 132 x 99 x 51 mm 10.04.012 Sensor Frequency: TX-power: Lifetime: Measurement range: Measurement accuracy: Operating temperature: Dimensions: Article number: 434.1 MHz 0 dBm 4 - 5 years 0 – 13 Bar ± 0.15 Bar -40 °C ~ +125 °C Ø 27,5 x 32,5 mm 10.01.040 External antenna Cable length: Connectors: Frequency: Installation bracket: Article number: 10 m TNC 434,1 MHz Aluminium 10.01.043 tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG For OTR, Earth movers, Machines Advantages: • Realtime monitoring of pressure and temperature • Improves operating safety and reduces down time • Increases tyre life • Fast and easy installation • LCD monitor shows tyre pressure, temperature, sensor battery status • Automatic warning, when tyre pressure above or below set thresholds • Warning for low battery voltage (sensor) • Logs alarms in memory • Easy export of tyre pressure, temperature, alarms via USB-Port • Additional sensors to upgrade the system Delivery contents Monitor with USB connector, sensors V12 (4 pieces) Anti theft protection rings (4 pieces), user manual, wiring cables tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com w! Ne OTR-TPMS
    • tpm-systems AG For OTR, Earth movers, Machines Specifications LCD-Monitor Frequency: Display: Receiver sensitivity: Operating temperature: Operating voltage: Dimensions (mm): Article number: 434.1 MHz LCD with backlight -105 dBm -30 °C ~ +75 °C 12 V oder 24 V 173 x 102 x 53 10.06.011 Sensor Frequency: TX power: Range: Lifetime: Measurement range: Measuremen accuracy: Operating temperature: Dimensions: Article number: 434.1 MHz 0 dBm ca. 10 m 4 - 5 years 0 – 13 Bar ± 0.15 Bar -40 °C ~ +125 °C Ø 27,5 x 32,5 mm 10.06.040 tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com w! Ne OTR-TPMS
    • tpm-systems AG w! Ne Parkmatic Powerline Reversing sensor with 7 warning zones for trucks and trailers Specially designed for long vehicles such as trucks and busses, modular and flexibel; quick and easy installation. With Parkmatic Powerline you can use the comfort and safety of a professional reversing sensor system with little installation effort for your own fleet. Structure and function of the system The system consists of two parts: 1) Sensorbox (ECU) with 4 sensors is installed at the rear end of the vehicle and connected to the reversing light. Box is activated by reverse gear. 2) Optical and acoustic display Anzeige (LED with buzzer): The display will be attached to the vehicle electrical. Data transmission is done via the vehicle wire harness (“+”- line). No signal wirings are required! Advantages: ✔ Very robust data transmission (powerline) from ECU to display ✔ Easy trailer change: LE9 display recognizes all connected ECUs. ✔ Digital sensors with extra large horizontal detection angle ✔ Very high and adjustable sensor sensitivity ✔ ECU and sensors are waterproof The system structure is modular. You can decide if you want to monitor tractor or trailer only or both. When hooking up the trailer the Parkmatic Sensors on the tractor will be automatically disabled. A trailer change will be automatically recognized. Article-No.: PM-6924 PM-6024 Description 4 sensors, LE9 display, ECU, wire harness 4 sensors, ECU, wire harness tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG modular design, quick and easy installation System components 1 display / receiver unit LE9 4 digital sensors 1 ECU / transmitter unit wire harness for ECU / sensors Installation material User guide / Installation manual Article-No.: PM-6924 Display / Receiver Unit LE9 Distance range: 22 cm .. 2,5 m Last Zone selectable: 22, 50, 70 cm Installation: standing, hanging Warning: optical, acoustic Operating voltage: 10,5 .. 28 VDC Operating temperature: -30 °C ~ +80 °C Dimensions: 90 x 75 x 40 mm Article-No.: PM-LE9 ECU Sensitivity: Waterproof: Trailer detection: Operating voltage: Operating temperature: Dimensions: Article-No.: 4 steps selectable IP67 automatic 10,5 .. 28 VDC -30 °C ~ +80 °C 137 x 86 x 34 mm PM-H27A Digital Sensors Sensor type: Detection angle: Detection range: Transmission: Operating temperature: Dimensions: Article-No.: active, 40 kHz 60 ° 2,5 m digital -30 °C ~ +80 °C 210 x 110 x 30 mm PM-S24A tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com w! Ne Parkmatic Powerline
    • tpm-systems AG Tyre Repair and Prevention Mobility warranty for emergencies Flat tyre prevention: PremiumSeal Prevent PremiumSeal Prevent effectively helps to prevent down time due to tyre punctures. Damages of a tyre with up to 10 mm diameter will be immediately and effectively sealed. The tyre will remain in driveable condition and can be saved. At the same time the tyre sealant dynamically balances the tyre, which reduces the stress on the vehicle and the chassis as an aside. Article.-No.: PremiumSeal Prevent 1l: PS-P For the emergency: PremiumSeal Repair Kits PremiumSeal tyre repair kits for the case of a tyre puncture: a proven and tested method which will help you, too to always keep moving. Article-Numbers: PremiumSeal Truck-Set 1: PremiumSeal Truck-Set 2: PremiumSeal Comfort 1: PremiumSeal Comfort 2: PS-TS1 PS-TS2 PS-TC1 PS-TC2 tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG Q-Sensor and Accessories Q-Sensor: the new little queue helper Spare parts, installation materials Q-Sensor: Use waiting times more useful The new Q-Sensor keeps an eye out when you are standing in line. Install on your windshield or side mirror and connect to the cigarette lighter and it will alert you when the gap in front opens up. You are free to care about other things in the meantime without losing touch with your queue when things are moving again. Article-No.: PM-QS1 Valve extensions and clamps Tyre pressure sensors may only be installed on pressure proof valve extensions. We are providing essential installation materials for safely installing your tyre pressure sensors. Article-Numbers: Valve extension 45°: Valve extension with clamp: Valve extension 175 mm: Clamp 16 mm width: Clamp 26 mm width: LPA-OWE LPA-IWE VL-175 FK-16 FK-26 Silica Gel Protection Cover Protects LED pressure alarm of dirt and damage Article-No.: LPA-SP T-joints and Adapters For installation onto OTR-tyres and easier inflating and testing. Article-Numbers: T-Stück: 3-Wege Adapter: OTR Ventil-Adapter: LPA-TDT AD-3W LPA-OR Spare parts Any spare parts such as anti theft rings, allen wrench, wire harness, installation bracket are available as spare parts. Please contact us. tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
    • tpm-systems AG Company profile tpm-systems AG was founded in 2005 in Switzerland as specialist supplier for tyre pressure monitoring systems. The founders combine substancial Know-How in this area and their technology has been in use since 1997 with designated auto manufacturers in series production. Since 2007 a mix of genuine products, complementary commercial products, product extensions and accessories has been successfully introduced in the market. Major brands are TireMoni, Parkmatic and LED Pressure Alarm. Since early 2009 tpm GmbH is responsible for marketing the products in Germany and all other EU countries. The product portfolio is continuously developed to market requirements and technological possibilities. tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com